Look Solutions VIPER DELUXE Manual de usuario

a Look Solutions product

Operating manual

viper

deluxe

Set of Equipment supplied

– 1Viper 2.6deLuxe (3050W) or Viper NT deLuxe (1750W)

– 1powerCONTRUE1TOPcable

– 1tanklidwithquickconnector,silicontubeandairvalvelter

– 1Operatingmanual

 Pleasecheckwhetheralltheproductsyouorderedaresupplied.

Originaloperatingmanual,version01/2022

Pleasenote:Dependingontheinstalleddevice,wattandvoltspecicationswillchange.

The device cannot be operated from 110 V - 240 V.ThedeLuxeisdeliveredinthe

230Vversion.

If110Voperationisplanned,a110VViperNTandanappropriatetransformerforthefan

mustbeinstalled.TheViper2.6isnotsuitablefor110Voperation.

Content

1. Introduction 4

2. Safety instructions 5

3. Description of the parts 6

4. Fluid 8

 4.1GeneralNotes

 4.2Rellingtheuidcontainer

5. Operating the Viper deLuxe9

 5.1Selectingthelocation 9

 5.2Puttingintooperation 9

 5.3Switchingthedeviceo 10

 5.4ControlviaDMX512 10

 5.4.1AdjustingtheDMXstartaddress

 5.4.2RDM

 5.5Standalonemode 11

 5.6Wiringofthesockets 11

6. Cleaning, Care and Maintenance12

7. Troubleshooting 13

8. Specications 14

9. Warranty Conditions 15

1. Introduction

TheViper deLuxeisthetouringversionoftheViper2.6resp.ViperNT.

Builtintoarobustightcasewithapowerfulfan,theViper deLuxeisreadyforanyuse.

Newfeaturesmakeiteveneasiertouse-placingandfoggingwithoutwastingalotof

timesettingandpreparing.

Thenew20Lattankcanbelledconvenientlyandeasily,guaranteeingalongerope-

ratingtime.

Thecastordishesallowforeasyandsafestackingandstowingoftheequipment.

Theperformanceofthemachineallowsapplicationsfromsmallclubstolargehalls,festivals

andevents,aswellasuseforairoworleaktestinginlargebuildings.

Theintendeduseofthedeviceistocreatearticialfog.

2. Safety instructions

• Veryhotsteamescapesfromthenozzle.Dangerofgettingburnt.

• Occasionallyveryhotdropletsofuidmayescapewheninoperation.Thusneveraimat

personsdirectlyandkeepaminimumdistanceof3mtothenozzle.

• Nevertouchthenozzlewheninoperation.Dangerofgettingburnt.

• Thelocationforthemachinemustbenon-ammable,non-combustibleandnotsensitive

toheat.Ithastobetwiceasbigasthemachine.

• Keepaminimumdistanceof60cmtoallammable,combustibleobjectsandobjects

sensitivetoheat.

• Glycolisalcoholandburnswithaslightlybluish,almostinvisibleame.Neverpointthe

fogatstrongsourcesofignitionlikereorpyrotechniceects.

• Neveropenthemachineandleavethemachineunattendedwhenconnectedtoapower

supply.

• Itisonlyallowedtoy/hangthemachinebyusingtheoriginalhangingset.

• Thevisibilityhastobemorethan2minroomswherepeoplewalkaround.

• Donotswallowthefoguid.Keepitawayfromchildren.Incaseofeyecontact,rinse

withalotofwater.Consultadoctorshouldyouhaveaccidentallyswallowedsomeuid.

• Spilleduidorsplasheduiddropletscancausesliphazard.Mopuptheuidanddispose

ofitaccordingtoregulations.

• Fogmayactivatesmokedetectors.

Articially-madefogcanbeproducedinmanydierentways.Themethodusedhereto

producefog,withadevicewhichworksaccordingtothevaporizerprinciple,isthemost

harmlessone.

Nocasehassofarbeenreportedinwhichasoundhumanbeinghasbeenharmedbecause

ofusingourdevicetoproducearticialfog.However,thiscanonlybeguaranteedifthe

professionalfoggeneratorsareusedaccordingly,i.e.atthecorrectvaporizationtemperatures

aswellaswiththecorrectlymixedfoguid.

We,however,recommend:People with health problems or problems of the respiratory

tract or with an inclination for allergies should avoid any contact with articially-made fog.

A fog machine is not a toy!

3. Description of the parts

Rear view

Front view

1:Fognozzle

2:Diverter

3:Fangrilleandfan

4:Carryinghandles

5:Filter

6:Castordishes

7:Automaticwheels

Control-Box

Connectorsfromlefttoright:

•DMX in (5pin)

•DMX out (5pin)

•Power in: ConnectorforpowerCONTRUE1TOP-cable

•Power out: 1xforfogmachineand1xforfan(alreadyconnectedwhensupplied)

•Analog out (Fog): Fogmachine(alreadyconnectedwhensupplied)

•Analog out (Fan): Fan(alreadyconnectedwhensupplied)

XXX= address · PXX = pump · FXX = fan

dmxin

active

power in

in out

dmx 512 power out power out analog out

(FOG)

analog out

(FAN)



~ ~

~

   



   





2.0

viper de luxe



Look Solutions



3. Description of the parts

13

Tank lid

Plasticspigot

Quickcoupling

Tanklid

Filter

12:

13:

14:

15:

8:Control-Box

9:Cableoutlet

10:20L-Fluidtank

11:Velcrotapeto

 securethetank

Rear view

4. Fluid

4.2 Relling the uid tank

– Disconnectthetanklidbypressingthespringsinthengerrecessesinwardsandliftout

thecover.

– Disconnecttheuidtubefromthelidbypressingthequickcoupling[13]andremoving

theplasticspigot[12].

– LoosentheVelcroandtiltthecanisterabout45degrees.

– Torell,unscrewthelargebluecapfromthecanisterandllthetankwithuid.

– TiltthecanisterbackinanuprightpositionandtightenitwiththeVelcrostrap.

– Pushtheplasticspigot[12]intothequickcoupling[13],untilyouhearaclick.Thespigot

isnowlockedrmly.

4.1 General notes

Beforerellingtheuidcanister,makesurethattherearenoimpuritiesinsidethetank.

Ifnecessary,thecanistermustberinsedout.Thiswillpreventcloggingoftheheater.

TheViper deLuxe hasbeendesignedtobeusedwithoriginalLookfoguids.

ThefollowingLookfoguidsareavailable:

Quick-Fog  thick,quickdisappearingfoguid

Regular-Fog  thick,longlastingfoguid

Slow-Fog  thick,extremelylonglastingfoguid

IfuidshavebeenusedotherthanLookfoguidswecan‘tgrantwarranty.

PLEASE NOTE:Thevaporizerofourmachines does not havetobecleaned!Cleaners,

availableonthemarket,candamagethevaporizer!Wecannotgrantwarrantyinthiscase.

5. Operating the Viper deLuxe

5.2 Putting into operation

Removethefrontcasecover.Therearcovercanremainonthecase.Simplyreleasethe

upperpartbypressingthespringsinthengerrecessesinwardandfoldingthecoverdown.

Thecontrolboxcanthenbeoperatedwithoutanyproblems.Theconnectionsforthefog

generatorandfanarealreadyconnectedtothecontrolbox.

XXX= address · PXX = pump · FXX = fan

dmxin

active

 Upbutton

Downbutton

Pleasenote:TheModebuttonisnotsuitablefor„scrolling“throughthemenu.Itmustbe

pressedbrieyoneatatime.

EnterbuttonModebutton

Active-LED

DMX-LED

a. ConnectthesuppliedpowerCONTRUE1TOPcabletothe„Powerin“connectoronthe

operatingboxandinsertthe mains plugintoan earthed socket. Makesurethat the

correctoperatingvoltage(230V/50Hz)isavailable.

 InthedisplayofthecontrolboxappearseitherthelaststoredDMXaddress(ifthedevice

isconnectedviaDMX)oraPandtwonumbers(seegureabove).

5.1 Selecting the location

ThelocationinwhichtheViper deLuxeisoperatedshould

– bedry,

– befreefromdustyorpollutedair,

– befreefromvibrations,

– beannon-ammableplaceorsurface,

– bewell-ventilatedwithfog-freeairkeepingtheambientoperatingtemperaturebetween

5°Cand45°Candtherelativeairhumiditybelow80%.

5. Operating the Viper deLuxe

5.3 Switching the device o

a. PresstheModebuttonuntil„OFF”appearsonthedisplay.After15secondsthemachine

willswitchoautomatically.Ontherightbottomedgeofthedisplayareddotwillappear,

indicatingthatthemachineisnotheatinganymore.

 Youcanalsoswitchothemachinewithinthese15secondsbypressingthe

 Enterbutton.

b. IftheDMXsignalislost,thedevicewillbeswitchedoautomaticallyafter15seconds

forsafetyreasons.

5.4 Operating via DMX 512

ConnecttheViper deLuxetoaDMX-deskusingthe5pin-XLRsocket„DMXin“ofthecon-

trolbox.AssoonasthemachinereceivesacorrectDMXsignal,theyellowDMX-LEDshines.

Nowthepumpandthefancanbeadjustedviathelightingconsole.

Please note:

TheViper deLuxe usestwochannelsatthedesk!Channel 1 = Pump, Channel 2 = Fan.

a)PresstheModebuttononthecontrolpanel,untilthreeguresappearontheLEDdisplay.

b) AdjusttherequestedstartaddressbypressingtheUp/Downbuttons.

5.4.1 Adjusting the DMX start address

b. Afteraheatingtimeofapprox.sevenminutes(ViperNT)orapprox.12minutes(Viper

2.6),thedeviceisreadyforoperation.

c. PresstheModebuttonuntilaPandtwoguresappearinthedisplay.Setthedesired

pumpvalueusingtheUp/Downbuttons.

d. PresstheModebuttonuntilanFandtwoguresappearinthedisplay.Setthedesired

fanvaluehere.

e. PresstheEnterbuttontostarttheunit.Thegreen„Active“LEDlightsup.

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Equipos industriales de Look Solutions

Look Solutions

Look Solutions OCTA JET Manual de usuario

Look Solutions

Look Solutions Cryo-Gate Manual de usuario

Manuales populares de Equipos industriales de otras marcas

ABB

ABB Unifix AD Manual

Mark 7

Mark 7 Evolution Manual de usuario

Husky

Husky HyPET Manual de usuario

bora

bora PM-1800 Manual de usuario

Grizzly

Grizzly T32428 Manual de usuario

Siemens

Siemens 8MF1 Series Manual de usuario

ABB

ABB HT610965 Manual de usuario

ABB

ABB SafeLink Manual de usuario

Phoenix

Phoenix PHX-150 Manual de usuario

ABB

ABB A165-L32 Manual de usuario

ABB

ABB HT842936 Manual de usuario

Rioned

Rioned UrbanJet Manual de usuario

Hermetica

Hermetica 10 Series Manual de usuario

HORNER

HORNER OEE Solution Manual de usuario

Hammerhead

Hammerhead HG375 Manual de usuario

SCHUNK

SCHUNK VERO-S NSE-A3 138 Instrucciones de uso

ABB

ABB HT566657 Manual de usuario

Webasto

Webasto GSE CAN Manual de usuario