Linear Technology DC1228A Guía de configuración rápida

dc1228af

DEMO MANUAL DC1228A

Description

LT3573

Isolated Monolithic

Flyback Converter

Demonstration circuit 1228A is an isolated flyback con-

verterfeaturingtheLT

3573.Thisdemocircuitisdesigned

for a 5.0V output from a 10V to 30V input. The maximum

output current is 1A when the input voltage is higher than

20V. No third winding or opto-isolator is required for

regulation. The part senses the isolated output voltage

directly from the primary-side flyback waveform.

The LT3573 operates with input supply voltages from 3V

to 40V, and can deliver an output power up to 7W with

no external power devices. The LT3573 utilizes bound-

ary mode operation to provide a small magnetic solution L, LT, LTC, LTM, Linear Technology and the Linear logo are registered trademarks of Linear

Technology Corporation. All other trademarks are the property of their respective owners.

performance summary

with improved load regulation. The LT3573 can be used

in industrial, automotive and medical applications where

an isolated output is required.

The LT3573 data sheet gives a complete description of

the part, operation and application information. The data

sheet must be read in conjunction with this quick start

guide for demonstration circuit 1228A.

Design files for this circuit board are available at

http://www.linear.com/demo/DC1228A

Specifications are at TA= 25°C

PARAMETER CONDITION MIN TYP MAX UNITS

Input Voltage Range 10 30 V

Output Voltage VOUT VIN = 10V to 30V 4.75 5 5.25 V

Maximum Output Current IOUT VIN = 10V to 20V

VIN = 20V to 30V 0.7

1.0 A

Switching Frequency VIN = 12V, IOUT = 0.7A

VIN = 24V, IOUT = 1A 169

238 kHz

kHz

Voltage Ripple VOUT VIN = 24V, IOUT = 1A 100 mV

Efficiency VIN = 24V, IOUT = 1A 84 %

dc1228af

DEMO MANUAL DC1228A

Quick start proceDure

Demonstration circuit 1228A is easy to set up to evalu-

ate the performance of the LT3573. Refer to Figure 1 for

proper measurement equipment setup and follow the

procedure below:

NOTE: When measuring the input or output voltage ripple,

care must be taken to avoid a long ground lead on the

oscilloscope probe. See Figure 2 for proper scope probe

technique.

1. With power off, connect the input power supply to VIN

and GND.

2. Turn on the power at the input.

NOTE: Make sure that the input voltage does not exceed

30V.

3. Check for the proper output voltages.

NOTE: If there is no output, temporarily disconnect the

load to make sure that the load current is not set too

high.

4. Once the proper output voltage is established, adjust

the load current within the operating range and observe

the output voltage regulation, ripple voltage, efficiency

and other parameters.

dc1228af

DEMO MANUAL DC1228A

Figure 2. Measuring Input or Output Ripple

Figure 1. Proper Measurement Equipment Setup

VIN OR VOUT GND

Quick start proceDure

dc1228af

DEMO MANUAL DC1228A

parts List

ITEM QTY REFERENCE PART DESCRIPTION MANUFACTURER/PART NUMBER

Required Circuit Components

1 1 C2 CAP., X7R, 4.7µF 50V, 1210 MURATA, GRM32ER71H475K

2 1 C4 CAP., X7R, 47µF 10V, 1210 MURATA, GRM32ER71A476K

3 1 C7 CAP., X7R, 0.1µF 16V, 0402 TDK, C1005X7R1C104MT

4 1 C8 CAP., NPO, 100pF 50V,0402 AVX, 04025A101JAT2A

5 2 C12, C9 CAP., X7R, 1µF 50V, 0805 MURATA, GRM21BR71H105K

6 1 C10 CAP., X7R, 0.22µF 25V, 0603 MURATE, GRM188R71E224K

7 1 C11 CAP., X7R, 4700pF 25V, 0402 AVX, 04023C472KAT2A

8 1 C13 CAP., NPO, 10pF 50V, 0402 AVX, 04025A100JAT2A

9 1 D1 DIODE, SCHOTTKY BARRIER RECTIFIER 3.0A DIODES INC., B340A-13-F

10 1 D2 DIODE, SWITCHING, SOD323 DIODES INC., 1N4148WS-7-F

11 1 D3 DIODE, SCHOTTKY MINI, SOD323 CENTRAL SEMI., CMDSH-3

12 1 R3 RES., CHIP 357k 1/16W 1%, 0402 VISHAY, CRCW0402357KFKED

13 1 R6 RES., CHIP 93.1k 1/16W 1%, 0402 VISHAY, CRCW040293K1FKED

14 1 R7 RES., CHIP 84.5k 1/16W 1%, 0402 VISHAY, CRCW040284K5FKED

15 1 R8 RES., CHIP 2k 1/10W 1%, 0805 VISHAY, CRCW08052K00FKEA

16 1 R9 RES., CHIP 20k 1/16W 1%, 0402 VISHAY, CRCW040220K0FKED

17 1 R10 RES., CHIP 10k 1/16W 1%, 0402 VISHAY, CRCW040210K0FKED

18 1 R11 RES., CHIP 6.04k 1/16W 1%, 0402 VISHAY, CRCW04026K04FKED

19 1 R15 RES., CHIP 12.4k 1/16W 1%, 0402 VISHAY, CRCW040212K4FKED

20 1 T1 XFMR, 750370047 WÜRTH, 750370047

21 1 U1 IC., LT3573EMSE, MSE16 LINEAR TECH., LT3573EMSE

Additional Demo Board Circuit Components

1 1 C1 CAP., ELECTROLYTIC, 22µF 50V, C-SANYO-CE-BS-6.3X6.0 SANYO, 50CE22BS

2 0 C5 CAP., 22µF 50V, C-SANYO-CE-BS-6.3X6.0 OPT SANYO, 50CE22BS

3 0 C14 CAP., 1206 OPT OPT

4 0 C19 CAP., X7R, 4.7µF 50V, 1210 OPT MURATA, GRM32ER71H475K

5 0 C20 CAP., X7R, 0.01µF 50V, 0603 OPT AVX, 06035C103KAT

6 0 FB1 BEAD, 1206 OPT TAIYO YUDEN, FB MJ3216HS800

7 0 L1 IND, PWR, L-CDRH4D22/HP OPT SUMIDA, CDRH4D22HPNP-100MC

8 0 R2 RES., 0603 OPT OPT

9 1 R4 RES., CHIP 499Ω 1/10W 1%, 0805 VISHAY, CRCW0805499RFKEA

Hardware: For Demo Board Only

1 5 E1, E2, E3, E5, E6 TP, TURRET, 0.094" MILL-MAX, 2501-2-00-80-00-00-07-0

dc1228af

DEMO MANUAL DC1228A

Information furnished by Linear Technology Corporation is believed to be accurate and reliable.

However, no responsibility is assumed for its use. Linear Technology Corporation makes no representa-

tion that the interconnection of its circuits as described herein will not infringe on existing patent rights.

schematic Diagram

D D

C C

B B

A A

























   











  



  



  



  



  



  





 

 









TECHNOLOGY





























































 

 









TECHNOLOGY





























































 

 









TECHNOLOGY



































































































































































 

















 

 





 





























































































































 





















































































































 























































dc1228af

DEMO MANUAL DC1228A

Linear Technology Corporation

1630 McCarthy Blvd., Milpitas, CA 95035-7417

(408) 432-1900 ●FAX: (408) 434-0507 ●www.linear.com

 LINEAR TECHNOLOGY CORPORATION 2013

LT 0913 • PRINTED IN USA

DEMONSTRATION BOARD IMPORTANT NOTICE

Linear Technology Corporation (LT C) provides the enclosed product(s) under the following AS IS conditions:

Thisdemonstration board(DEMO BOARD) kit being soldor providedby Linear Technologyis intendedfor use for ENGINEERING DEVELOPMENT

OR EVALUATION PURPOSES ONLY and is not provided by LTC for commercial use. As such, the DEMO BOARD herein may not be complete

in terms of required design-, marketing-, and/or manufacturing-related protective considerations, including but not limited to product safety

measures typically found in finished commercial goods. As a prototype, this product does not fall within the scope of the European Union

directive on electromagnetic compatibility and therefore may or may not meet the technical requirements of the directive, or other regulations.

If this evaluation kit does not meet the specifications recited in the DEMO BOARD manual the kit may be returned within 30 days from the date

of delivery for a full refund. THE FOREGOING WARRANTY IS THE EXCLUSIVE WARRANTY MADE BY THE SELLER TO BUYER AND IS IN LIEU

OF ALL OTHER WARRANTIES, EXPRESSED, IMPLIED, OR STATUTORY, INCLUDING ANY WARRANTY OF MERCHANTABILITY OR FITNESS

FOR ANY PARTICULAR PURPOSE. EXCEPT TO THE EXTENT OF THIS INDEMNITY, NEITHER PARTY SHALL BE LIABLE TO THE OTHER FOR

ANY INDIRECT, SPECIAL, INCIDENTAL, OR CONSEQUENTIAL DAMAGES.

The user assumes all responsibility and liability for proper and safe handling of the goods. Further, the user releases LTC from all claims

arising from the handling or use of the goods. Due to the open construction of the product, it is the user’s responsibility to take any and all

appropriate precautions with regard to electrostatic discharge. Also be aware that the products herein may not be regulatory compliant or

agency certified (FCC, UL, CE, etc.).

No License is granted under any patent right or other intellectual property whatsoever. LT C assumes no liability for applications assistance,

customer product design, software performance, or infringement of patents or any other intellectual property rights of any kind.

LTC currently services a variety of customers for products around the world, and therefore this transaction is not exclusive.

Please read the DEMO BOARD manual prior to handling the product. Persons handling this product must have electronics training and

observe good laboratory practice standards. Common sense is encouraged.

This notice contains important safety information about temperatures and voltages. For further safety concerns, please contact a LTC applica-

tion engineer.

Mailing Address:

Linear Technology

1630 McCarthy Blvd.

Milpitas, CA 95035

X-ON Electronics

Largest Supplier of Electrical and Electronic Components

Click to view similar products for Power Management IC Development Tools category:

Click to view products by Analog Devices manufacturer:

Other Similar products are found below :

EVAL6482H-DISC EVAL-AD5522EBUZ EVAL-ADM1060EBZ EVAL-ADM1073MEBZ EVAL-ADM1166TQEBZ EVAL-

ADM1168LQEBZ EVAL-ADM1171EBZ EVAL-ADM1276EBZ EVB-EN5319QI EVB-EN5365QI EVB-EN6347QI EVB-EP5348UI

MIC23158YML EV MIC23451-AAAYFL EV MIC5281YMME EV 124352-HMC860LP3E ADM00513 ADM8611-EVALZ ADM8612-

EVALZ ADM8613-EVALZ ADP1046ADC1-EVALZ ADP1055-EVALZ ADP122-3.3-EVALZ ADP130-0.8-EVALZ ADP130-1.2-EVALZ

ADP130-1.5-EVALZ ADP130-1.8-EVALZ ADP160UJZ-REDYKIT ADP166UJ-EVALZ ADP1712-3.3-EVALZ ADP1714-3.3-EVALZ

ADP1715-3.3-EVALZ ADP1716-2.5-EVALZ ADP1740-1.5-EVALZ ADP1752-1.5-EVALZ ADP1754-1.5-EVALZ ADP1828LC-EVALZ

ADP1870-0.3-EVALZ ADP1871-0.6-EVALZ ADP1873-0.6-EVALZ ADP1874-0.3-EVALZ ADP1876-EVALZ ADP1879-1.0-EVALZ

ADP1882-1.0-EVALZ ADP1883-0.6-EVALZ ADP197CB-EVALZ ADP199CB-EVALZ ADP2102-1.25-EVALZ ADP2102-1.2-EVALZ

ADP2102-1.875EVALZ

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Convertidor de medios de Linear Technology

Linear Technology

Linear Technology Analog Devices LT8301 Manual de usuario

Linear Technology

Linear Technology LTC3444 Manual de usuario

Linear Technology

Linear Technology DC2221A Guía de configuración rápida

Linear Technology

Linear Technology LT3512 Guía de configuración rápida

Linear Technology

Linear Technology DC2312A-A Guía de configuración rápida

Linear Technology

Linear Technology LTC3725 Manual de usuario

Linear Technology

Linear Technology LTC3765 Guía de configuración rápida

Linear Technology

Linear Technology DC1185B-A Guía de configuración rápida

Linear Technology

Linear Technology DC2050A Manual de usuario

Linear Technology

Linear Technology DC627A-A Manual de usuario

Linear Technology

Linear Technology DC1687A Guía de configuración rápida

Linear Technology

Linear Technology LTC3459ES6 Manual de usuario

Linear Technology

Linear Technology DC1345 Manual de usuario

Linear Technology

Linear Technology DC2056A Guía de configuración rápida

Linear Technology

Linear Technology LT8494 Guía de configuración rápida

Linear Technology

Linear Technology LTC3118EUFD Guía de configuración rápida

Linear Technology

Linear Technology DC1745A Guía de configuración rápida

Linear Technology

Linear Technology LTC3765 Guía de configuración rápida

Linear Technology

Linear Technology LTC2668 Guía de configuración rápida

Linear Technology

Linear Technology 431 Manual de usuario

Linear Technology

Linear Technology LT3956 Series Manual de usuario

Linear Technology

Linear Technology DC2641A Guía de configuración rápida

Linear Technology

Linear Technology LTM8045 Guía de configuración rápida

Linear Technology

Linear Technology DC2283A Guía de configuración rápida

Manuales populares de Convertidor de medios de otras marcas

SoundTraxx

SoundTraxx Blunami BLU-2200 Manual de usuario

SPROLINK

SPROLINK VA1 Manual de usuario

Acclaim Lighting

Acclaim Lighting DDC-1-AC Manual de usuario

Nikon

Nikon AF-S TC-20E III Manual de usuario

Axis

Axis AXIS Q7406 Manual de usuario

Omega

Omega TAC80B-J Manual de usuario

Zoom

Zoom Thunderbolt TAC-2R Manual de usuario

OST

OST iConverter 10/100M Manual de usuario

Vertiv

Vertiv Netsure Manual de usuario

birddog

birddog MINI Manual de usuario

Roland

Roland GI-10 Manual de usuario

Wallenstein

Wallenstein WX310 Manual de usuario

Pace

Pace MSS 200-1 Manual de usuario

Solar Converters

Solar Converters EQ 12/24-50 Manual de usuario

CYP

CYP EL-7400V Manual de usuario

TIE

TIE MIDI 1i1o Manual de usuario

DCS

DCS Vivaldi Upsampler Manual de usuario

Westermo

Westermo MCW-211 SERIES Manual de usuario