Lincat ECO8 Guía del usuario

IS 331 ECN 3823 Page 1 of 12

Installation, Operating and Servicing

Instructions

Electric Convection Oven

ECO8, ECO9

Please make a note of your product details for

future use:

Date Purchased:_________________________

Model Number:__________________________

Serial Number:__________________________

Dealer:_________________________________

_______________________________________

IS 331 ECN 3823 Page 2 of 12

CONTENTS

Important Information

Warnings and Precautions

Technical Data

Checklist of Enclosures

Installation and Commissioning

3-5

Operating Instructions

5-7

Cleaning

Servicing, Maintenance and Component Replacement

8-9

Fault Finding

Spare Parts List

Accessories

Service Information and Guarantee

IMPORTANT INFORMATION

Read these instructions carefully before using this product, paying particular

attention to all sections that carry warning symbols, caution symbols and notices.

Ensure that these are understood at all times.

WARNING!

This symbol is used whenever there is a risk of personal injury.

CAUTION!

This symbol is used whenever there is a risk of damaging your Lincat product.

NOTE:

This symbol is used to provide additional information, hints and tips.

KEEP THIS MANUAL FOR FUTURE REFERENCE

IS 331 ECN 3823 Page 3 of 12

WARNINGS AND PRECAUTIONS

This appliance must be installed, commissioned and serviced by a qualified person

in accordance with national and local regulations in force in the country of

installation.

If the supply cord is damaged, it must be replaced by the manufacturer, its service

agent or similarly qualified person.

Ensure that the plug/socket is accessible at all times.

Strip plastic coating and clean the appliance before use.

During operation parts may become hot - avoid accidental contact.

Disconnect this appliance before servicing, maintenance or cleaning.

TECHNICAL DATA

Model

Height (mm)

Width (mm)

Depth (mm)

Weight (kg)

ECO8

570

790

700

ECO9

650

765

810

CHECK LIST OF ENCLOSURES

Warranty Card

Instructions Manual

Shelves (3 off ECO8, 4 off ECO9)

Water connection hose

INSTALLATION AND COMMISSIONING

This appliance must be earthed.

An equipotential bonding terminal is provided to allow cross bonding with other

equipment.

If replacing the plug connect the terminals as follows:

Green and Yellow wire Earth E

Blue wire Neutral N

Brown wire Live L

IS 331 ECN 3823 Page 4 of 12

Means of isolation with at least 3mm contact separation in all poles must be

incorporated into the fixed wiring of the ECO9.

The fixed wiring insulation must be protected by insulated sleeving having a

temperature rating of 60 Deg C.

Supply cords shall be oil resistant, sheathed flexible cable not lighter than ordinary

polychloroprene or equivalent elastomer sheathed cord (code 60245 IEC 57)

Install this appliance on a level surface ensuring all vents are unobstructed. Any

partitions, walls or furniture must be of non-combustible material. Minimum

distances A 100mm B 1000mm –see Fig 1. Leave 100mm clearance at the back,

as the flue is rear facing.

Fig 1

IS 331 ECN 3823 Page 5 of 12

Model ECO8 is fitted with a 3 pin plug for connection to a standard switched socket.

Model ECO9 must be connected by a qualified electrician (see power ratings).

The ECO9 electrical inlet (A) and water supply valve (B) are shown in Fig 2. The

ECO8 has the water supply valve on the opposite side. The water supply pressure

must be from 0.2-10 bar (20kPa-1,000kPa). Screw one end of the connection hose

to the back of the oven and the other to your water supply tap. Use the hose set

supplied with the appliance –old hose sets are not to be re-used.

Fig 2

Power Ratings

ECO8

3.0kW

ECO9

7.5kW

OPERATING INSTRUCTIONS

Only qualified or trained personnel should use this appliance.

IS 331 ECN 3823 Page 6 of 12

Fig 3

1. On/Off switch 2. Power supply indicator 3. Oven temperature indicator 4.Temperature

control knob 5. Cook and hold switch 6. Cook and hold indicator 7. Cook and hold timer

8. 60 minute timer 9. Interior light switch 10. Water injection switch

IS 331 ECN 3823 Page 7 of 12

Cooking

(Fig 3)

Connect the appliance to the electricity supply. The green neon (2) illuminates

indicating power to the appliance.

Turn the mains switch (1) on.

Turn the control knob (4) to the required temperature.

The amber neon (3) goes out when the oven reaches temperature.

Cook and hold function

Switch the cook and hold switch (5) on –the cook and hold indicator (6) illuminates.

Set the timer (7) to the required cooking time. After the time set has elapsed, the

oven cools to 80oC and maintains this temperature until switched off.

Additional functions

The light switch (9) operates the interior light.

The water injection switch (10) sprays water into the oven to create steam.

The 60 minute timer knob (8) rings when the set time has elapsed.

CLEANING

Do not use a water jet or steam cleaner, and do not immerse this appliance.

Clean all panels with warm water and mild detergent, do not use abrasive

materials. Dry with a soft cloth.

Avoid damaging the thermostat bulbs inside the oven when cleaning.

Carb’n Off or a similar cleaner may be used.

To assist cleaning remove shelf supports –see Servicing.

IS 331 ECN 3823 Page 8 of 12

SERVICING, MAINTENANCE AND

COMPONENT REPLACEMENT

Door inner glass

Slide the glass up and out of the lower clamps, slide down to remove from upper

clamps.

Slide new glass into lower clamps. Clip into top clamps.

Light bulb

Carefully remove the glass cover using a flat bladed screwdriver. Unscrew the

bulb.

Fit new bulb and replace cover.

Shelf racks

(Fig 4 –Door removed for clarity)

To remove shelf racks, swivel locking tabs (A) and lift rack upwards. Lift the rack

free from lower retaining pins, then tilt bottom inwards and lower from top retaining

pins to remove.

Refit by sliding rack upwards onto upper retaining pins, then pull down over lower

retaining pins. Secure by swivelling locking tabs down.

On ECO9, use inner pins for shelves, outer pins for standard baking trays.

IS 331 ECN 3823 Page 9 of 12

Fig 4

Please refer to the Service Help Desk number on the final page of this manual.

FAULT FINDING

IS 331 ECN 3823 Page 10 of 12

Part Number

Description

Used on

BU81

Bush –parking lever

ECO8, ECO9

CO215

Contactor

ECO9

EL141

Side element

ECO9

EL190

Base element

ECO9

EL236

Element

ECO8

FA102

Fan blade

ECO9

FA106

Fan

ECO8

FA12

Fan

ECO9

FE10

Foot

ECO8, ECO9

GL205

Inner glass

ECO8

GL503

Inner glass

ECO9

KN246

Door handle knob

ECO8, ECO9

KN247

60 minute timer knob

ECO8, ECO9

KN248

180 minute timer knob

ECO8, ECO9

KN249

Thermostat knob

ECO8, ECO9

LA14

Light assembly

ECO8, ECO9

NE42

Green neon

ECO8, ECO9

NE43

Amber neon

ECO8, ECO9

PI12

Inlet connection hose

ECO8, ECO9

PL202

Plug and lead

ECO8

SE05

Door seal

ECO9

SE76

Door seal

ECO8

SH109

Shelf

ECO8, ECO9

SO1

Solenoid valve

ECO8, ECO9

S/R0079

Cooling fan

ECO9

SW23

Rocker switch

ECO8, ECO9

SW32

Plunger microswitch

ECO8, ECO9

SW34

Changeover switch

ECO8, ECO9

SW35

Momentary switch

ECO8, ECO9

SW66

Switch –black/green

ECO8, ECO9

TE10

Terminal block - small

ECO9

TE45

Terminal block –3 phase

ECO9

TH107

Thermostat

ECO8, ECO9

TI34

180 minute timer

ECO8, ECO9

TI37

60 minute timer

ECO8, ECO9

TH63

Cut out thermostat

ECO9

SPARE PARTS LIST

Otros manuales para ECO8

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Horno de Lincat

Lincat

Lincat CO133M Manual del propietario

Lincat

Lincat V6 Instrucciones de funcionamiento

Lincat

Lincat PO425 Instrucciones de funcionamiento

Lincat

Lincat OE8008 Manual del propietario

Lincat

Lincat CIBO Manual de usuario

Lincat

Lincat LMO9 Manual

Lincat

Lincat PO69X Manual de funcionamiento

Lincat

Lincat Lynx 400 Manual del propietario

Lincat

Lincat LYNX 400 LCO Manual de servicio

Lincat

Lincat Silverlink 600 Guía del usuario

Lincat

Lincat SLR6 Guía del usuario

Lincat

Lincat Silverlink 600 Manual del propietario

Manuales populares de Horno de otras marcas

Bosch

Bosch HVA531NS0 Manual de usuario

Electrolux

Electrolux EOF6P46X Manual de usuario

NEFF

NEFF B44S32 5GB Series Manual de usuario

Combi

Combi BLODGETT BC142GDS Manual de usuario

AEG

AEG COMPETENCE 311704300 Manual de usuario

Falcon

Falcon DOMINATOR PLUS G3106 Series Guía del usuario

Rational

Rational SCC WE 61G Manual de usuario

Smeg

Smeg DOSPA38X Manual de instalación y operación

Electrolux

Electrolux air-o-convect 20 GN 2/1 Manual de usuario

Miele

Miele HR 1954-2 Manual de usuario

KHIND

KHIND OT50 Manual de usuario

Henny Penny

Henny Penny Smoker Box Manual de usuario

Lang

Lang ECOD-AP Manual de usuario

AEG

AEG BEK455310M Manual de usuario

Frigidaire

Frigidaire FNGE90JGR Manual de usuario

Hotpoint

Hotpoint FE9 S831 JSH IX Manual de usuario

GE Advantium SCB2000 Manual de usuario

AEG

AEG DE401301DM Manual de usuario