Lenovo ThinkPad X200si Manual del propietario

Removing and replacing a FRU

This chapter presents directions and drawings for use in removing and replacing a

FRU. Be sure to observe the following general rules:

1. Do not try to service any computer unless you have been trained and certified.

An untrained person runs the risk of damaging parts.

2. Before replacing any FRU, review “FRU replacement notices” on page 79.

3. Begin by removing any FRUs that have to be removed before the failing FRU.

Any such FRUs are listed at the top of the page. Remove them in the order in

which they are listed.

4. Follow the correct sequence in the steps for removing the FRU, as given in the

drawings by the numbers in square callouts.

5. When turning a screw to replace a FRU, turn it in the direction as given by the

arrow in the drawing.

6. When removing the FRU, move it in the direction as given by the arrow in the

drawing.

7. To put the new FRU in place, reverse the removal procedure and follow any

notes that pertain to replacement. For information about connecting and

arranging internal cables, see “Locations” on page 161.

8. When replacing a FRU, use the correct screw as shown in the procedures.

DANGER

Before removing any FRU, turn off the computer, unplug all power cords

from electrical outlets, remove the battery pack, and then disconnect any

interconnecting cables.

Attention: After replacing a FRU, do not turn on the computer until you have

made sure that all screws, springs, and other small parts are in place and none are

loose inside the computer. Verify this by shaking the computer gently and listening

for rattling sounds. Metallic parts or metal flakes can cause electrical short circuits.

Attention: The system board is sensitive to, and can be damaged by, electrostatic

discharge. Before touching it, establish personal grounding by touching a ground

point with one hand or by using an electrostatic discharge (ESD) strap (P/N

6405959).

www.battery-adapter.com

Before servicing ThinkPad X200, X200s, X200si, X201, X201i, and

X201s

Removing the SIM card:

Some models of the ThinkPad X200, X200s, X200si, X201, X201i, and X201s you are

servicing might have the SIM card that the customer has been installed.

If the computer you are servicing has the SIM card, remove it before you start the

servicing.

To remove the SIM card, you need to remove the battery pack first. (See “1010

Battery pack” on page 85.)

After you finish the servicing, make sure that you insert the card back into the slot

firmly.

Notice on disconnecting the cable from flip-lock ZIF connector:

Some cables used in the ThinkPad X200, X200s, X200si, X201, X201i, and X201s are

connected to the flip-lock ZIF connectors.

When disconnecting the cable from those connectors, do as shown in this figure.

84 ThinkPad X200, X200s, X200si, X201, X201i, and X201s Hardware Maintenance Manual

www.battery-adapter.com

1010 Battery pack

Important notice for replacing a battery pack:

Lenovo ThinkVantage Toolbox (in Windows 7) and Lenovo System Toolbox (in

Windows Vista and Windows XP) have an automatic battery diagnostic that

determines if the battery pack is defective. A battery pack FRU should not be

replaced unless this diagnostic shows that the battery is defective.

The only exception to this is if the battery pack is physically damaged or a

customer is reporting a possible safety issue.

If ThinkVantage Toolbox or Lenovo System Toolbox is not installed in the

computer, the customer should download this program before a non-physically

damaged battery pack is replaced. Note that a physically damaged battery pack

is non-warranty replacement.

Removing and replacing a FRU 85

www.battery-adapter.com

Table 9. Removal steps of battery pack

DANGER

Use only the battery specified in the parts list for your computer. Any other

battery could ignite or explode.

Unlock the battery release lever 1. Holding the battery release lever in the

unlocked position 2, remove the battery pack in the direction shown by arrow

3.

1 2

When installing: Install the battery pack along the slide rails of the slot. Then

make sure that the battery release lever is in the locked position.

86 ThinkPad X200, X200s, X200si, X201, X201i, and X201s Hardware Maintenance Manual

www.battery-adapter.com

1020 Hard disk drive (HDD) cover, HDD, and HDD rubber rails or solid

state drive (SSD) and storage converter

For access, remove this FRU:

v“1010 Battery pack” on page 85

Table 10. Removal steps of HDD cover, HDD, and HDD drive rubber rails or SSD and

storage converter

Step Screw (quantity) Color Torque

1 Hard disk drive screw, M3 ×3 mm,

wafer-head, nylon-coated (1)

Black 0.392 Nm

(4 kgfcm)

Attention:

vDo not drop the hard disk drive or apply any physical shock to it. The hard

disk drive is sensitive to physical shock. Improper handling can cause damage

and permanent loss of data.

vBefore removing the drive, have the user make a backup copy of all the

information on it if possible.

vNever remove the drive while the system is operating or is in suspend mode.

Removing and replacing a FRU 87

www.battery-adapter.com

Table 10. Removal steps of HDD cover, HDD, and HDD drive rubber rails or SSD and

storage converter (continued)

When installing: Make sure that the HDD connector or SSD connector is

attached firmly.

88 ThinkPad X200, X200s, X200si, X201, X201i, and X201s Hardware Maintenance Manual

www.battery-adapter.com

Table 10. Removal steps of HDD cover, HDD, and HDD drive rubber rails or SSD and

storage converter (continued)

HDD and HDD rubber rails:

When installing: The rubber rails on the hard disk drive must be attached to

the replacement drive. Otherwise the drive cannot be installed properly.

SSD and storage converter:

Removing and replacing a FRU 89

www.battery-adapter.com

Table 10. Removal steps of HDD cover, HDD, and HDD drive rubber rails or SSD and

storage converter (continued)

When installing: When you install the SSD in the storage converter, do as

follows.

90 ThinkPad X200, X200s, X200si, X201, X201i, and X201s Hardware Maintenance Manual

www.battery-adapter.com

1030 DIMM

For access, remove this FRU in order:

v“1010 Battery pack” on page 85

Table 11. Removal steps of dimm

Remove the DIMM slot cover as shown in this figure.

Note: Loosen the screws 1, but do not remove them.

Removing and replacing a FRU 91

www.battery-adapter.com

Table 11. Removal steps of dimm (continued)

Note: For ThinkPad X200, X200s, and X200si, if only one DIMM is used on the

computer you are servicing, the card must be installed in SLOT-0 (a), but not

in SLOT-1 (b).

For ThinkPad X200, X200s, and X200si:

a b

92 ThinkPad X200, X200s, X200si, X201, X201i, and X201s Hardware Maintenance Manual

www.battery-adapter.com

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Computadora portátil de Lenovo

Lenovo

Lenovo THINKPAD L420 Guía de solución de problemas

Lenovo

Lenovo ThinkPad Edge E420s Manual de usuario

Lenovo

Lenovo 80N5003FFR Manual de usuario

Lenovo

Lenovo IdeaPad U160 Manual de usuario

Lenovo

Lenovo Y27q-30 Manual de usuario

Lenovo

Lenovo ThinkPad X130e Manual de usuario

Lenovo

Lenovo ThinkPad R61e Manual de usuario

Lenovo

Lenovo ThinkPad X200 Tablet 7453 Guía

Lenovo

Lenovo ThinkPad T530 Manual de usuario

Lenovo

Lenovo G5 ABP Manual de usuario

Lenovo

Lenovo ThinkPad T430 Manual de usuario

Lenovo

Lenovo IdeaPad Slim 9i Manual de usuario

Lenovo

Lenovo V330-14ARR Manual de usuario

Lenovo

Lenovo YOGA SLIM 7-14APU Manual del propietario

Lenovo

Lenovo ThinkPad i Series 1157 Manual de usuario

Lenovo

Lenovo THINKPAD X40 Manual de usuario

Lenovo

Lenovo ThinkPad Edge E320 Manual de usuario

Lenovo

Lenovo THINKPAD X100E Cómo utilizar

Lenovo

Lenovo ThinkPad L412 4403 Manual de usuario

Lenovo

Lenovo V15 Gen1 i Manual del propietario

Lenovo

Lenovo 019626U Manual del propietario

Lenovo

Lenovo 1866 - ThinkPad X41 Tablet Manual de servicio

Lenovo

Lenovo ThinkPad T420s Manual de usuario

Lenovo

Lenovo ThinkPad R50p Guía de inicio rápido

Manuales populares de Computadora portátil de otras marcas

HP ze2401xt - Pavilion Notebook PC Manual de usuario

Velocity

Velocity NoteMagix M10 Manual de usuario

Dell

Dell Alienware 17 R2 Manual de usuario

Toshiba

Toshiba A105-S2236 Manual de usuario

HP ENVY 17 Manual

Winbook

Winbook LM Manual de usuario

Dell

Dell Inspiron 1464 Manual de usuario

Dell

Dell Inspiron 15R 5537 Manual de usuario

HP PROBOOK 4520S Manual

Dell

Dell Latitude ATG D620 Manual de usuario

Sony

Sony VAIO PCG-FX270 Manual de usuario

Dell

Dell Latitude 7310 Manual de usuario

Dell

Dell Precision GU806 Manual de usuario

Sony

Sony VAIO PCG-R505JLK Manual de usuario

HP Compaq tc4200 Guía de inicio rápido

Toshiba

Toshiba mini NB300 Manual de usuario

Sony

Sony VGN-T240P VAIO Manual de usuario

Compaq

Compaq Armada E700 Series Manual de usuario