Legacy Stoves SF170 Guía de configuración

INSTALLATION AND

OPERATOR’S MANUAL

READ THIS MANUAL BEFORE INSTALLING OR USING YOUR YOUR LEGACY STOVES BOILER





IMPORTANT: IN ORDER TO ACHIEVE SAFE AND SATISFACTORY

RESULTS FROM YOUR LEGACY STOVES BOILER, READ SAFETY

RULES AND INSTRUCTIONS CAREFULLY BEFORE INSTALLING AND

OPERATING. ALL INSTALLATIONS MUST BE IN ACCORDANCE WITH

STATE AND LOCAL CODES. INSTALLATION IS TO BE PERFORMED BY A

QUALIFIED INSTALLER. SAVE THESE INSTRUCTIONS FOR FUTURE

REFERENCE.

Your Leg cy Stoves Boiler is c p ble of gener ting very hot

temper tures. Boiler temper tures nd fl mes in the ignition box

re re c p ble of c using ignition or explosion of explosive or

fl mm ble products or explosion of the boiler itself if m ximum

s fe w ter temper ture is exceeded. M ximum s fe oper ting

temper ture is 180° F hrenheit. Fl mm ble or explosive

products must never be stored in the s me room or in the vicinity

of boilet.

LEGACY STOVES,

A DIVISION OF:

ALTERNATE HEATING SYSTEMS

2395 LITTLE EGYPT RD

HARRISONVILLE, PA 17228

717-987-0099

WWW.ALTERNATEHEATINGSYSTEMS.COM

EMAIL: SERVICE@LEGACYSTOVES.COM

Record Model a d Serial Number Below:

Model:

Serial Number:

Date of Purchase:

REV-32923

 !"#$%&'(&")*&*&#)$!&+

 "&#),&%# -.#/*&#)+*!." "-/0#&%-&&%

1 "0"#&&)/))&,&")*&*&#)$!&+2

3##)45454

Table of Co te ts
Introduction..............................................................................................................................................................1
Installation................................................................................................................................................................3
General Chimney Introduction............................................................................................................................3
Draft................................................................................................................................................................3
Technical  spects of Chimney Performance..................................................................................................4
Barometric Damper........................................................................................................................................4
Combustion  ir (Make Up  ir)......................................................................................................................4
Masonry Chimneys.........................................................................................................................................5
Prefabricated Chimneys..................................................................................................................................5
Common Chimney Problems..............................................................................................................................6
Proper Chimney Connection...............................................................................................................................7
In case of chimney fire........................................................................................................................................7
In Case of Runaway Fire.....................................................................................................................................7
Stovepipe.............................................................................................................................................................8
Wall Pass-Through: United States..................................................................................................................8
Wall Pass-Through: Canada...........................................................................................................................9
Boiler Location....................................................................................................................................................9
Boiler Room Requirements..........................................................................................................................10
Rigging and Positioning of Boiler.....................................................................................................................10
Clearances.....................................................................................................................................................11
Domestic Hot Water from your Boiler: Domestic Coil Option.........................................................................11
Low Water Cutoff Utilization............................................................................................................................13
Manufacturer's Documentation....................................................................................................................13
Low Water Cutoff Testing............................................................................................................................13
Low Water Cutoff Troubleshooting..............................................................................................................13
Low Water Cutoff Offline Testing................................................................................................................14
Low Water Cutoff Maintenance...................................................................................................................14
Thermostat Connection.....................................................................................................................................14
Boiler Dump Zone  pplications.......................................................................................................................14
Non Powered Dump Zone............................................................................................................................14
Installing the Optional Forced Draft Blower....................................................................................................15
Testing/servicing Electrical components...........................................................................................................15
High Limit Control.......................................................................................................................................15
Operating Limit Control...............................................................................................................................16
Forced Draft Motor/Draft  ctuator..............................................................................................................16
Operation and Maintenance...................................................................................................................................17
FUELS (US )...................................................................................................................................................17
Coal...............................................................................................................................................................17
Wood (Used for Coal Fire Startup)...............................................................................................................17
Fuels (Canada)..................................................................................................................................................17
Coal...............................................................................................................................................................17
 djusting  utomatic Draft Controls............................................................................................................17
 djusting Optional Forced Draft Blower.....................................................................................................18
Firebricks......................................................................................................................................................18
Doors............................................................................................................................................................18
Fuel Capacity................................................................................................................................................18
Cleaning Requirements................................................................................................................................19
Fuel Storage – Wood....................................................................................................................................19
Fuel Storage – Coal......................................................................................................................................19

Starting a Fire....................................................................................................................................................20
......................................................................................................................................................................20
Starting a Wood Fire.....................................................................................................................................20
Starting a Coal Fire.......................................................................................................................................20
Coal types..........................................................................................................................................................21
Maintaining a Coal Fire................................................................................................................................21
Dump zone Control...........................................................................................................................................22
Grates................................................................................................................................................................22
Other general operating guidelines...................................................................................................................22
Operation During a Power Failure...............................................................................................................23
Conditioning of Boiler Water............................................................................................................................23
Ph..................................................................................................................................................................23
Dissolved Oxygen........................................................................................................................................23
Sulfites..........................................................................................................................................................24
Solids (Steam Boilers)..................................................................................................................................24
 lkalinity......................................................................................................................................................24
Phosphates....................................................................................................................................................24
Hardness.......................................................................................................................................................24
Oils...............................................................................................................................................................24
 ppendix  : Wiring Diagrams..............................................................................................................................25
Dump Zone – Parallel to Thermostat...........................................................................................................26
Dump Zone – Using Pump or Zone Valve...................................................................................................27
 ppendix B: Specifications...................................................................................................................................28
 dditional Specifications..................................................................................................................................29
Pressure Drop...............................................................................................................................................29
Explanation of GPM Flow............................................................................................................................29
 ppendix C Boiler Piping Diagrams.....................................................................................................................30
 ppendix D: Parts Listing.....................................................................................................................................32
Electrical Parts..............................................................................................................................................32
Service Parts SF170......................................................................................................................................33
SF170 Bottom Brick Layout........................................................................................................................34
SF170 Bottom Brick and Heat Exchanger Brick.........................................................................................35
Service Parts SF270......................................................................................................................................36
SF270 Base Brick Layout.............................................................................................................................37
SF270 Bottom Brick and Heat Exchanger Brick.........................................................................................38
Service Parts – Low Water Cutoff................................................................................................................39
Warranty Information (2 Pages).............................................................................................................................43
Service and Maintenance Log................................................................................................................................45

I troductio

















!"#$%&

 !



66787

797:6

6762

7;69<

777

6<

7:7;

62

999

2

9

278

6988

7=7





799

2

7

6<



987

2

66

<

7

66<

978

78;8

78=7

>76?

2;67=79

99

72

7<9

62;677

778786

72

6

=72

969

=77

@7

2

;:6

788



=72

9697

:A2B9

7

969

7

6

967

72

- 1 -

- 2 -

I stallatio

'

!()



*



GENERAL CHIMNEY INTRODUCTION

+





,-

#,-

,-

.

/0



7

757

662

Draft

1-2

34





2

- -3

5-

.,,

 





 

6789:5;

- <

2

0

-

31-

4

Poor chim eys with cold walls ca

cause creosote buildup. Sharp

be ds a d horizo tal flues should

also be avoided. The exhaust must

be kept movi g through the

pipi g/flue to preve t creosote or fly

ash buildup. If a horizo tal sectio

must be used, it must rise slightly to

preve t dead air space.

,679

;



-5

=

>(7(?9

(



)3

3-2-10 Rule for Chim eys

- 3 -

Tech ical Aspects of Chim ey

Performa ce







 

)



.

(

(-

6;



(9@5

-(9A

B

Dwyer Ma ometer

'-

3-5

-6

;

C

-

(9A.

-

4

4D

Barometric Damper





 

--

E-

.

,

 

)-(9A



.



F'

.-

-3

4

6

;-

.

-

(9@(9G



Barometric Damper

Combustio Air (Make Up Air)

0



)

 



,

(



4

 

- 4 -

Maso ry Chim eys

.















(



5







)

6 



H

;.4

)

.



(



Prefabricated Chim eys





I

BI

H-



B4(

B!?9>B!4(J7K

*



. 

6 ;

 4 

6&;5?G957G9

&64;

I I

=61;



 &3

46E;

 5465;

 6L;



04

46#;



 &6.;



I

M

"$CN&

6N;

C 4D 6=;

 46!;





0 4

6M; C56%;



 6+;

)

C

Note: Do ot decrease the diameter of chim ey

pipe to less tha that of the flue collar! Chim ey

co ector a d flue must be 8 i ches i diameter

or greater

- 5 -

The airflow through the system a d

out the chim ey mea s that oxyge

is leavi g the home a d will create

a oxyge deficit if this air is ot

replaced.

Otros manuales para SF170

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Caldera de Legacy Stoves

Legacy Stoves

Legacy Stoves SF170 Guía de configuración

Manuales populares de Caldera de otras marcas

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Manual de usuario

Radijator

Radijator BIO max 23.1 Manual de usuario

Brunner

Brunner BSV 20 Manual de usuario

Buderus

Buderus Logamax GB062-24 KDE H V2 Manual de usuario

Potterton

Potterton 50e Hoja de datos

UTICA BOILERS

UTICA BOILERS TriFire Manual de usuario

Joannes

Joannes LADY Series Manual

ECR International

ECR International UB90-125 Manual de instrucciones

Froling

Froling FHG Turbo 3000 Manual de usuario

Froling

Froling P4 Pellet 8 - 105 Manual de usuario

U.S. Boiler Company

U.S. Boiler Company K2 Manual de usuario

Henrad

Henrad C95 FF Manual de usuario

NeOvo

NeOvo EcoNox EF 36 Manual de usuario

Potterton

Potterton PROMAX SL 12 Manual de usuario

Eco Hometec

Eco Hometec EC 25 COMPACT Manual de usuario

Viessmann

Viessmann VITODENS 200 Guía

Baxi

Baxi Prime 1.24 Manual de usuario

REXNOVA

REXNOVA ISA 20 BITHERMAL Manual de usuario