Lawn-Boy 11002 Manual de usuario

Operator’s Manual

IMPORTANT: Read this manual carefully. It contains information about your

safety and the safety of others. Also become familiar with the controls and

their proper use before you operate the product.

FORM NO. 3321–180 GB

COMMERCIAL

Walk-Behind

Power Mower

Model No. 11002 – 8900001 & Up

Model No. 11003 – 8900001 & Up

Lawn-Boy Inc. – 1998

Introduction

Thank you for purchasing a Lawn-Boy product.

All of us at Lawn-Boy want you to be completely

satisfied with your new product, so feel free to

contact your local Authorized Service Dealer for help

with service, genuine Lawn-Boy parts, or other

information you may require.

Whenever you contact your Authorized Service

Dealer or the factory, always know the model and

serial numbers of your product. These numbers will

help the Service Dealer or Service Representative

provide exact information about your specific

product. You will find the model and serial number

decal located in a unique place on the product as

shown below

1064 1149





1. Model

and Serial Number Decal (Model 1

1002)

Model and Serial Number Decal (Model 1

1003)

For your convenience, write the product model and

serial numbers in the space below.

Model No:

Serial No.

Read this manual carefully to learn how to operate

and maintain your product correctly. Reading this

manual will help you and others avoid personal injury

and damage to the product. Although Lawn-Boy

designs, produces and markets safe, state-of-the-art

products, you are responsible for using the product

properly and safely. You are also responsible for

training persons who you allow to use the product

about safe operation.

The Lawn-Boy warning system in this manual

identifies potential hazards and has special safety

messages that help you and others avoid personal

injury, even death. DANGER, W

ARNING and

CAUTION are signal words used to identify the level

of hazard. However, regardless of the hazard, be

extremely careful.

DANGER signals an extreme hazard that will cause

serious injury or death if the recommended

precautions are not followed.

WARNING signals a hazard that may cause serious

injury or death if the recommended precautions are

not followed.

CAUTION signals a hazard that may cause minor or

moderate injury if the recommended precautions are

not followed.

Two other words are also used to highlight

information. “Important” calls attention to special

mechanical information and “Note” emphasizes

general information worthy of special attention.

The left and right side of the machine is determined

by standing behind the handle in the normal

operator’s position.

GB–1

Contents

Page

Safety 2.

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Symbol Glossary

. . . . . . . . . . . . . . . . . . . .

Assembly 7

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Handle 7

. . . . . . . . . . . . . . . . . . . . . . . . . . . .

Fuel Tank 7

. . . . . . . . . . . . . . . . . . . . . . . . . .

Cover Plate and Guard Plate 8

. . . . . . . . . . .

Before Starting 10

. . . . . . . . . . . . . . . . . . . . . . . . . .

Oil Mix Ratio 10

. . . . . . . . . . . . . . . . . . . . . . .

Mixing Gasoline And Oil 11

. . . . . . . . . . . . . .

Lawn Preparation And Mowing 12

. . . . . . . . .

Operation 13

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Starting Engine 13

. . . . . . . . . . . . . . . . . . . . . .

Stopping Engine 14

. . . . . . . . . . . . . . . . . . . . .

Self-propelled Drive 14

. . . . . . . . . . . . . . . . . .

Adjusting Cutting Height 15

. . . . . . . . . . . . . .

Mulching Tips 15

. . . . . . . . . . . . . . . . . . . . . .

Page

Maintenance 17

. . . . . . . . . . . . . . . . . . . . . . . . . . . .

Recommended Maintenance Schedule

. . .

Air Filter 18

. . . . . . . . . . . . . . . . . . . . . . . . . . .

Spark Plug 19

. . . . . . . . . . . . . . . . . . . . . . . . .

Clean Mower Housing

. . . . . . . . . . . . . . . .

Blade 20

. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Lubrication 22

. . . . . . . . . . . . . . . . . . . . . . . . .

Exhaust Ports 23

. . . . . . . . . . . . . . . . . . . . . . .

Self–propelled Cable 24

. . . . . . . . . . . . . . . . .

Troubleshooting 25

. . . . . . . . . . . . . . . . . . . . . . . . .

Accessories 27

. . . . . . . . . . . . . . . . . . . . . . . . . . . .

Rear Grass Catcher

. . . . . . . . . . . . . . . . . . .

Mulch Plate

. . . . . . . . . . . . . . . . . . . . . . . .

Storage 31

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Fuel 31

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Engine 31

. . . . . . . . . . . . . . . . . . . . . . . . . . . .

Removing From Storage 31

. . . . . . . . . . . . . .

GB–2

Safety

Training

1. Read the instructions carefully. Be familiar with

the controls and the proper use of the equipment.

2. Never allow children or people unfamiliar with

these instructions to use the lawnmower. Local

regulations may restrict the age of the operator.

3. Never mow while people, especially children, or

pets are nearby.

4. Keep in mind that the operator or user is

responsible for accidents or hazards occurring to

other people or their property.

Preparation

1. While mowing, always wear substantial

footwear and long trousers. Do not operate the

equipment when barefoot or wearing open

sandals.

2. Thoroughly inspect the area where the

equipment is to be used and remove all objects

which may be thrown by the machine.

3. WARNING – Petrol is highly flammable.

•Store fuel in containers specifically

designed for this purpose.

•Refuel outdoors only and do not smoke

while refuelling.

•Add fuel before starting the engine. Never

remove the cap of the fuel tank or add

petrol while the engine is running or when

the engine is hot.

•If petrol is spilled, do not attempt to start

the engine but move the machine away

from the area of spillage and avoid creating

any source of ignition until petrol vapors

have dissipated.

•Replace all fuel tanks and container caps

securely.

4. Replace faulty silencers.

5. Before using, always visually inspect to see that

the blades, blade bolts and cutter assembly are

not worn or damaged. Replace worn or damaged

blades and bolts in sets to preserve balance.

6. On multi–bladed machines, take care as rotating

one blade can cause other blades to rotate.

Operation

1. Do not operate the engine in a confined space

where dangerous carbon monoxide fumes can

collect.

2. Mow only in daylight or in good artificial light.

3. Avoid operating the equipment in wet grass,

where feasible.

4. Always be sure of your footing on slopes.

5. Walk, never run.

6. For wheeled rotary machines, mow across the

face of slopes, never up and down.

7. Exercise extreme caution when changing

direction on slopes.

Do not mow excessively steep slopes.

9. Use extreme caution when reversing or pulling

the lawnmower towards you.

10. Stop the blade(s) if the lawnmower has to be

tilted for transportation when crossing surfaces

other than grass, and when transporting the

lawnmower to and from the area to be mowed.

11. Never operate the lawnmower with defective

guards or shields, or without safety devices, for

example deflectors and/or grass catchers, in

place.

Safety

GB–3

12. Do not change the engine governor settings or

overspeed the engine.

13. Disengage all blade and drive clutches before

starting the engine.

14. Start the engine or switch on the motor carefully

according to instructions and with feet well away

from the blade(s).

15. Do not tilt the lawnmower when starting the

engine or switching on the motor, except if the

lawnmower has to be tilted for starting. In this

case, do not tilt it more than absolutely necessary

and lift only the part which is away from the

operator.

16. Do not start the engine when standing in front of

the discharge chute.

17. Do not put hands or feet near or under rotating

parts. Keep clear of the discharge opening at all

times.

18. Never pick up or carry a lawnmower while the

engine is running.

19. Stop the engine and disconnect the spark plug

wire

•before clearing blockages or unclogging

chute;

•before checking, cleaning or working on the

lawnmower;

•after striking a foreign object. Inspect the

lawnmower for damage and make repairs

before restarting and operating the

lawnmower;

•if lawnmower starts to vibrate abnormally

(check immediately).

20. Stop the engine

•whenever you leave the lawnmower;

•before refuelling.

21. Reduce the throttle setting during engine shut

down and, if the engine is provided with a

shut-off valve, turn the fuel off at the conclusion

of mowing.

22. Go slow when using a trailing seat.

Maintenance and storage

1. Keep all nuts, bolts and screws tight to be sure

the equipment is in safe working condition.

2. Never store the equipment with petrol in the tank

inside a building where fumes may reach an

open flame or spark.

3. Allow the engine to cool before storing in any

enclosure.

4. To reduce the fire hazard, keep the engine,

silencer, battery compartment and petrol storage

area free of grass, leaves, or excessive grease.

5. Check the grass catcher frequently for wear or

deterioration.

6. Replace worn or damaged parts for safety.

7. If the fuel tank has to be drained, this should be

done outdoors.

Sound Pressure Level

This unit has an equivalent continuous A-weighted

sound pressure at the operator ear of: 87 dB(A), based

on measurements of identical machines per ANSI

B71.5-1984 procedures.

Sound Power Level

This unit has a sound power level of: 105 dB(A)/1

pW, based on measurements of identical machines per

Directive 84/538/EEC and amendments.

Vibration Level

This unit has a maximum hand-arm vibration level of

10.65 m/s@, based on measurement of identical

machines per ISO 5349.

Safety

GB–4

Symbol

Glossary

Safety

alert triangle —

symbol within triangle

indicates a hazard.

Do not open or

remove safety shields

while engine is

running.

Safety alert symbol

Rotating blade can cut

off toes or fingers.

Stay clear of mower

blade as long as

engine is running.

Read operator

’s

manual.

To avoid blade failure

when mulching, use

blade stiffener when

mower is equipped

with mulching plug.

Consult technical

manual for proper

service procedures.

Transmission

Stay a safe distance

from the machine.

Oil

Stay a safe distance

from the mower

.On/Run

Thrown or flying

objects — Whole body

exposure Engage

Thrown or flying

objects — Rotary

side-mounted mower

Keep deflector shield

in place.

Disengage

Safety

GB–5

Stop engine before

leaving operator

position.

Battery charging

condition

Hourmeter/elapsed

operating hours Fuel

Fast Neutral

Slow

First gear

Decreasing/Increasing

Second gear

Grease lubrication

point

Third gear

Engine start

Cutting element —

basic symbol

Engine stop

Cutting element —

height adjustment

Choke

Pull rope.

Safety

GB–6

Primer (start aid)

Wheel

Push primer three

times.

Wheel traction

Properly dispose of

batteries.

Lower control bar

Insert key into ignition

switch.

Raise control bar

Turn key in ignition

switch.

Raise/lower control

bar.

Move control.

Raise/lower control

bar.

Move control forward.

Raise control bar

Move control

rearward.

Raise control bar

Lower control bar

GB–7

Assembly

Handle

Assembly

1. Lift top handle half in an arc until handle

sections nest together and holes line up.

Note: Use care to prevent pinching or

stretching of cables.

2. Using hardware shown in Figure 1, secure

handle halves together.

1180

Figure 1

3. Squeeze lower handle section together and place

over pins on handle brackets (Fig. 2/3).

M–3897

Figure 2

(Model 1

1002)

1. High

setting

Medium setting

Low setting

Mower housing

124

5M–2506

Figure

(Model 1

1003)

1. High

setting

Medium setting

Low setting

Mower housing

5. T

raction cable bracket

6. T

raction cable spring

Actuator bracket

4. Hook traction cable spring into actuator bracket

as shown in Figure 3 (model 11003 only).

5. Match three (3) holes in traction cable bracket to

three (3) holes in left side of mower housing

(model 11003 only) (Fig. 3).

Handle Height

Handle may be placed in three (3) height positions:

high, medium or low (Fig. 2/3). Select a handle

height position that is most comfortable for you.

1. Align holes in lower handle section with holes in

mower housing. Using hardware shown in

Figure 2 or 3, secure handle to mower housing.

Assembly

GB–8

Fuel

ank

1. Locate fuel hose attached to the carburetor

(Fig. 4). Remove and discard cap on free end of

hose.

2. Push hose onto fuel shut off valve in fuel tank,

completely covering all ridges of fitting (Fig. 4).

m–3886

Figure 4

1. Fuel

hose

Fuel shut of

f valve

3. Place fuel tank onto mounting bracket with tabs

through openings in mounting bracket.

m–3888

Figure 5

1. Tabs 2. Mounting

bracket

4. Slide clips through tabs of tank under mounting

bracket until they snap into locked position.

m–3889

Figure 6

1. Clip

Cover

Plate and Guard Plate

Your mower was shipped with a cover plate and

guard plate. For side discharge operation the cover

plate must be installed in the deck opening and the

guard plate over the side discharge opening.

POTENTIAL HAZARD

•An uncovered discharge opening will allow

objects to be thrown in operator’

s or

bystander’s direction. Also, contact with

blade could occur.

WHAT CAN HAPPEN

•Thrown objects or blade contact can cause

serious injury

HOW TO AV

OID THE HAZARD

•Never operate mower unless cover plate,

guard plate, mulch plate or grass chute and

catcher are installed.

1. Stop engine and disconnect spark plug wire

(Fig. 7) before installing or removing cover

plate.

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Cortacésped de Lawn-Boy

Lawn-Boy

Lawn-Boy GoldPro Series Manual de usuario

Lawn-Boy

Lawn-Boy 10605 Manual de usuario

Lawn-Boy

Lawn-Boy Precision Z340 HLX Manual de usuario

Lawn-Boy

Lawn-Boy Insight 10684 Manual de usuario

Lawn-Boy

Lawn-Boy M Series Manual de usuario

Lawn-Boy

Lawn-Boy Euro Series Manual de usuario

Lawn-Boy

Lawn-Boy 10738 Manual de usuario

Lawn-Boy

Lawn-Boy Insight 10684C Manual de usuario

Lawn-Boy

Lawn-Boy 22270 Manual de usuario

Lawn-Boy

Lawn-Boy Insight 10997 Manual de usuario

Lawn-Boy

Lawn-Boy 22242 Manual de usuario

Lawn-Boy

Lawn-Boy 10662 Manual de usuario

Lawn-Boy

Lawn-Boy 17750 Manual de usuario

Lawn-Boy

Lawn-Boy Silver Series 10270 Manual de usuario

Lawn-Boy

Lawn-Boy V-Engine Manual de usuario

Lawn-Boy

Lawn-Boy Insight 10780 Manual de usuario

Lawn-Boy

Lawn-Boy Insight Gold 10696 Manual de usuario

Lawn-Boy

Lawn-Boy Insight 10695 Manual de usuario

Lawn-Boy

Lawn-Boy 10928 Manual de usuario

Lawn-Boy

Lawn-Boy Gold Series Manual de usuario

Lawn-Boy

Lawn-Boy Insight Platinum 10765 Manual de usuario

Lawn-Boy

Lawn-Boy 22242 Manual de usuario

Lawn-Boy

Lawn-Boy 10666C Manual de usuario

Lawn-Boy

Lawn-Boy 10607 Manual de usuario

Manuales populares de Cortacésped de otras marcas

RHINO

RHINO 1958 Manual de usuario

Wolf Garten

Wolf Garten Compact plus 40 B Manual de usuario

Cub Cadet

Cub Cadet LTX 1045 Manual de usuario

Craftsman

Craftsman 917.378461 Manual de usuario

GGP ITALY SPA

GGP ITALY SPA CR/CS 434 SERIES Manual de usuario

Challenge

Challenge CH18V2 Instrucciones de operación

TALEN TOOLS

TALEN TOOLS AVR HGM30 Manual de usuario

DEWEZE

DEWEZE ATM-725 Manual de operación

Weed Eater

Weed Eater 180083 Manual de usuario

Husqvarna

Husqvarna Poulan Pro PP185A42 Manual de usuario

Better Outdoor Products

Better Outdoor Products Quick Series Manual de usuario

Cub Cadet

Cub Cadet 23HP Z-Force 60 Manual de funcionamiento

MTD

MTD 795, 792, 791, 790 Manual de usuario

Toro

Toro Groundsmaster 3505-D Manual de usuario

Dennis

Dennis FT 610 Manual de usuario

AIRFORCE

AIRFORCE F-15 Gen 3 Manual de usuario

MTD

MTD 126-220-000 Manual de usuario

Toro

Toro 74806 Manual de usuario