Lance 650 Instrucciones de funcionamiento e instalación

Technical Service Information #53

3/11/2022

. Affected units 2022 Lance campers and trailers with the Truma Aquago water heater option

. Campers: 650, 825, 865, 1062, 1172

. Trailers: 1685, 1985, 1995, 2185, 2445

PROBLEM:It has been found during production that the Data cable has been routed from the back side

of the water heater creating an incorrect installation and generating a possible safety risk.

CORRECTION: Unplug the Data cable from the water heater control board, pull it back out of the back

side of the water heater and route the data cable through the gas line opening. Replace the grommet

for the gas line and cover the cold water inlet opening with a rubber plug shown below.

CAUTION: Propane is highly Flammable!!

1) Turn the propane off at both tank valves. Burn off excess propane by lighting a

burner on the stove. Close burner valve after all propane has been burnt off.

2) Remove the access door of the tankless water heater.

3) Disconnect the gas hose using a ¾” wrench with a backer wrench, remove the gas

line from the connection and pull it out of the inlet ((make sure you use the right

tool to avoid any damage on the valve).

4) Remove the panel on the back of the tankless water heater from the interior of

the trailer.

5) Disconnect the cable from the control panel.

6) Pull out the cable from the cold water heater inlet where it was installed.

7) Install the grommet inside the gas inlet and make sure it seals the inlet where the

gas hose was removed.

control panel

di i

8) Install the rubber cap to cover the cold water inlet on the back of the water heater

where the data cable was removed.

9) Route the cable around the tankless water heater and insert it along with the gas

hose into the outlet thru the grommet on the side of the tankless water heater.

Grommet

i id th itl t

Pass the gas hose and

cable together thru the

grommet.

10) Re-connect the Data cable to the control panel cable where it was disconnected

and reconnect the L.P. hose using the ¾” wrench with a backer wrench to tighten

11) Turn propane valve back on and apply liquid propane leak solution on L.P. hose

connection to check for leaks. If there is a leak, you need to inspect and repair as

needed.

12) Fasten the gas hose and cable together with a “Plastic Tie Strap”.

Make sure it is

adjusted correctly.

13)Close the compartment door of the tankless water heater and install the

protection panel on the back.

Process warranty Claim using: Flat rate code #1708-00 @ 1.0 hour.

See Connection diagram on next page.

1. Connection diagrams.

Este manual sirve para los siguientes modelos

9

Tabla de contenidos

Otros manuales de Autocaravana de Lance

Lance

Lance 2005 Max Series Manual de usuario

Lance

Lance 1130 Manual de usuario

Lance

Lance 1999 Lite Camper Manual de usuario

Lance

Lance Lance Slideout 2005 Series Manual de usuario

Lance

Lance Truck Camper Manual de usuario

Lance

Lance 2001 model Manual de usuario

Lance

Lance Lance 2002 Manual de usuario

Lance

Lance Legend Manual de usuario

Lance

Lance Lance Slideout 2005 Series Manual de usuario

Manuales populares de Autocaravana de otras marcas

Possl

Possl D-Line 2011 Manual de usuario

Itasca

Itasca spirit Manual de usuario

carado

carado BANFF 2018 Manual de usuario

Airstream

Airstream 1980 Argosy Manual de usuario

GBM

GBM 1994 Pursuit Manual de usuario

Itasca

Itasca Meridian 2005 Manual de usuario

Jayco

Jayco Kiwi Travel Trailer 2003 Manual de usuario

Fleetwood

Fleetwood 1999 Discovery Guía de inicio rápido

Bush Palace

Bush Palace STARCRAFT TOO Manual de usuario

Fleetwood

Fleetwood Jamboree Searcher 1993 Manual de usuario

Winnebago

Winnebago Journey Manual de usuario

Tiffin Motorhomes

Tiffin Motorhomes 2017 Allegro Breeze Manual de usuario

Winnebago

Winnebago 2009 Spirit Manual de usuario

Lunar Caravans

Lunar Caravans Venus Manual de usuario

Triple E

Triple E Free Spirit 2012 Manual de usuario

Winnebago

Winnebago 2014 Adventurer Manual de usuario

NewMar

NewMar Dutch Star 1999 Manual de usuario

Winnebago

Winnebago 1996 Brave Manual de usuario