KYE Systems Corp. Genius SP-S120 Manual de usuario

ServiceGuide SP-S120

Version : 1.0 Page 1 of 15

SERVICE GUIDE

KYESYSTEMS CORP.

SP-S120

ServiceGuide SP-S120

Version : 1.0 Page 2 of 15

Version : 1.0

RevisionHistory

Version Date Change

1.0 08/02/2007

ServiceGuide SP-S120

Version : 1.0 Page 3 of 15

Table of Contents

Revision History …………………………………………………………………….2

Table of Contents ……………………………………………………………………3

Getting Started ………………………………………………………………………4

Conventions Used in this Guide ……………………………………….4

Safety Precautions ……………………………………………………..4

Chapter 1. How to Handle Defective Returns……………………………………..5

1.1 Overview …………………………………………………………..5

1.2 Problems …………………………………………………………...6

1.2.1 One or more channels no sound ………………..…7

1.2.2 Power LED (indicator) no light………………....…8

1.2.3 Volume no function...…………………….………..8

Chapter 2. Specifications …………………………………………………………9

Chapter 3. Block Diagram ……………………………………………………….10

Chapter 4. Exploded View …………………………………………………….11-12

Chapter 5. Part List ………………………………………………………………13

Chapter 6. Schematic Diagram …………………………………………………..14

Chapter 7. Important Notes ………………………………………………………15

7.1 Packing Requirement for Sending the PCB Assembly by Post …..15

7.2 Short of Spare Parts while Repairing a Speaker System …………15

ServiceGuide SP-S120

Version : 1.0 Page 4 of 15

Getting Started

Conventions Used in this Guide

Pay Special Attention : Instructions that are important to remember and

may prevent mistakes .

Caution : Information that, if not followed, may result in damage to the

product .

Safety Precautions

The following precautions should be observed in handling the speaker

Described in this guide :

Place the speakers on a flat, level and stable surface.

Do not place the speakers in environments subject to mist, smoke,

vibration, excessive dust, salty or greasy air, or other corrosive gases

and fumes.

Do not drop or jolt the speakers.

Do not allow anything to drop into the subwoofer case through its

ventilator, as it could result in fatal electric shock or fire .

Place the unit far enough from other equipments for good heat

dissipation .

Disconnect the AC power cord from the AC outlet before performing

any maintenance on the speakers .

Do not perform any maintenance with wet hand .

Prevent foreign substances, such as water, other liquids or chemicals ,

From entering the speakers while performing maintenance procedures

on the speakers .

ServiceGuide SP-S120

Version : 1.0 Page 5 of 15

Chapter 1. How to Handle Defective Returns

1.1 Overview

Verifying problems

Proceeding necessary tests

Receiving Defective speakers from

Customers

Analyzing possible malfunction

causes

Deciding & proceeding the

rectification methods

Replace necessary defective parts

Proceeding tests to

Verify if the speaker is

functioning normally

Return the speakers with proper

repackaging to customers

Function NG

Function OK

Function NG

ServiceGuide SP-S120

Version : 1.0 Page 6 of 15

1.2 Problems

Item Problem Description

1.2.1 Oneormorechannelsnosound

1.2.2 PowerLED(indicator)nolight

1.2.3 Volumenofunction

ServiceGuide SP-S120

Version : 1.0 Page 7 of 15

Attention

1.2.1 One or more channels no sound

Problem

Solutions

Please follow the numbered sequence marked within parenthesis given in individual

Flow chat, in that this is the best-recommended sequence to rectify the problems.

One or more channels no sound

Broken or short circuit

Defective IC

Speaker cable dis-connect or

speaker damaged

Check solder points on

PCB

Check and Replace

defective IC

Re-connect speaker cable or

replace defective speaker(s)

Analyzer and

Identify the Causes

ServiceGuide SP-S120

Version : 1.0 Page 8 of 15

1.2.2 Power LED (indicator) no light

Problem

Solutions

1.2.3 Volume no function

Problem

Solutions

Power LED (indicator) no light

Power switch or LED defective

Defective diode,

SW, R15, C14, C15,

Ac cord of transformer

disconnected or defective

Re-solder or replace

defective component(s)

Analyzer and

Identify the Causes

Volume no function

Broken or short circuit

Defective VR1, IC

Check solder points on PCB

Analyzer and

Identify the Causes

Check and Replace defective

components

ServiceGuide SP-S120

Version : 1.0 Page 9 of 15

Chapter 2. Specifications

NO. Description Unit Specifications

1 Out Power at THD 10% W ≧1

2 Sensitivity mV 400 ±50

3 Freq. Response (Ref:-3dB) Hz 40Hz ~ 20KHz

4 Separation dB

≧40

5 S/N ratio dB

≧60

6 Hum & Noise (Vol.: max) mV ≦ 10

ServiceGuide SP-S120

Version : 1.0 Page 10 of 15

Chapter 3. Block Diagram

AUDIO IN

Volume

Increase

Power

Amplifier

R.CH Speaker

AC IN

L.CH Speaker

Volume

Decrease

Power

Conditioner

Tabla de contenidos

Otros manuales de Oradores de KYE Systems Corp.

KYE Systems Corp.

KYE Systems Corp. Genius SP-i175 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SW-Flat2.1 800 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-120 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF1100X Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF360A Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP700 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. SP-HF2020 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF1250K Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SW-i2.1 1100 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-S105 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-i150 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF 2.1 800 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-i170 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF2000X Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF1201A Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-E06S Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-i202u Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-N120 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-i355 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-i300 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-i177 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-J330 Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF1200A Manual de usuario

KYE Systems Corp.

KYE Systems Corp. Genius SP-i205U Manual de usuario

Manuales populares de Oradores de otras marcas

argon audio

argon audio IE20 Manual de usuario

Denon

Denon SC-N7 Manual de usuario

Gemline

Gemline Ace 3952 Manual de usuario

Focal

Focal ON WALL 300 Manual de instrucciones

HEADRUSH

HEADRUSH Maximus HRSP 5024 Manual de usuario

SoundLogic

SoundLogic BCCS-6/6395 Manual de usuario

Peavey

Peavey DTH 218 Manual de usuario

Avantree

Avantree Pluto Air Manual de usuario

Morel

Morel Integra Series INTEGRA OVATION 4 Manual de usuario

Oppo

Oppo SONICA Manual de usuario

Bose

Bose SoundLink Wireless Music System Manual de usuario

Rocksteady

Rocksteady Stadium Manual de usuario

Bowers & Wilkins

Bowers & Wilkins 4 Manual de usuario

Sonance

Sonance SONOS OUTDOOR Series Manual de usuario

Electro-Voice

Electro-Voice EVID FM4.2 Manual de usuario

Pioneer

Pioneer XW-HTD630 Manual de usuario

Onn

Onn BWA16AA002 Manual de usuario

HP GL313AA - USB Speakers PC Multimedia Manual de usuario