KOMPAN ICON Manual de usuario
ICON
power box installation guide
Rev. Draft 0.2
Kompan A/S
Korsvangen 11
DK 5750 Ringe Phone:
(+45) 6362 1250 Telefax:
(+45) 6362 1000 e-mail:
isd@KOMPAN.com
- 2 -
Contents
1.0 About this manual..........................................................................................................................3
2.0 Intended use ...................................................................................................................................3
2.1 European WEEE directive.............................................................................................................3
3.0 Installation and service instructions...............................................................................................4
Server box overview.........................................................................................................................4
Mounting the power box...................................................................................................................5
Installation of the 24V cables from the playground .........................................................................6
Connector overview..........................................................................................................................9
Connection table...............................................................................................................................9
Installation of 110V/230V power cable..........................................................................................10
4.0 Technical specifications...............................................................................................................11
4.3 Maintenance instructions .............................................................................................................14
Kompan A/S
Korsvangen 11
DK 5750 Ringe Phone:
(+45) 6362 1250 Telefax:
(+45) 6362 1000 e-mail:
isd@KOMPAN.com
- 3 -
1.0 About this manual
This manual describes the installation and maintenance of the ICON power box. It also includes
technical specifications and information about certifications.
2.0 Intended use
The ICON solitaire power box is designed for powering up to 2 structures on an ICON playground.
The power box is intended for wall mount, inside or outside. Where a wall is not available the
power box may be mounted inside the standard ICON server box cabinet (available as a spare part
and must be ordered separately).
For two structures, the allowed configurations are shown in the table below:
Structure 1
Srtucture 2 Space Nova Rocky
Space Not allowed! X X
Nova X X X
Rocky X X X
The power box supply utilizes two 24V outputs. The power supply is internally limited to a max.
output current of 4A in total for the two outputs.
The ICON solitaire power box is specially designed and approved for use with ICON equipment
only.
Installation instructions described in this manual must be followed. If the installation, use and
maintenance instructions described in this manual are violated, the protection provided by
the power box may be impaired!
2.1 European WEEE directive
All electronic components of ICON are subject to the European WEEE directive and must at
the lifecycle end be recycled according to the directive. The electronic components are marked
with WEEE recycle mark.
Kompan A/S
Korsvangen 11
DK 5750 Ringe Phone:
(+45) 6362 1250 Telefax:
(+45) 6362 1000 e-mail:
isd@KOMPAN.com
- 4 -
3.0 Installation and service instructions
Server box overview
!
24V power
su
pp
l
y
Main 110/230V circuit breaker
and 4A resettable fuse
Electrical
specifications are
placed inside the
box
Special tool for the triangle
screws is placed inside the
box
Kompan A/S
Korsvangen 11
DK 5750 Ringe Phone:
(+45) 6362 1250 Telefax:
(+45) 6362 1000 e-mail:
isd@KOMPAN.com
- 5 -
Mounting the power box
The power box must be mounted on a wall, inside or outside according to the drawing above, unless
local rules and regulations dictates other mounting requirements. The cable protection must cover
the cables down to the ground level.
Kompan A/S
Korsvangen 11
DK 5750 Ringe Phone:
(+45) 6362 1250 Telefax:
(+45) 6362 1000 e-mail:
isd@KOMPAN.com
- 6 -
OBS! BEFORE ANY WORK WITHIN THE POWER BOX IS DONE,
THE MAIN CIRCUITBREAKER MUST BE SWITCHED OFF!!!
Installation of the 24V cables from the playground
Preparing the cables:
1) Dismantle the cable by app. 70mm 2) Cut off the filler cords
3) Cut off the white and yellow wires 4) Dismantle the inner cords by 5mm
Switch to the
off position!
4A resettable fuse
Kompan A/S
Korsvangen 11
DK 5750 Ringe Phone:
(+45) 6362 1250 Telefax:
(+45) 6362 1000 e-mail:
isd@KOMPAN.com
- 7 -
5) Mount the wire ferrules using a special plier 6) Final result
See specification below!
Wire Ferrules for CAN bus (blue & green wire): Kompan order no: A900648-99
Wire Ferrules for 24V (Orange & Black wire): Kompan order no: A900648-99
Crimping Pliers for End Sleeves (ferrules) Knipex: Kompan order no: A900638-99
Connecting the cables:
1) Put on the screw cap 2) Put cable through the fastener and fasten properly
Twist the shield cords around the cable jacket
3) Open the connector using a screwdriver 4) Mount the wire!
size 2.5 x 75
Kompan A/S
Korsvangen 11
DK 5750 Ringe Phone:
(+45) 6362 1250 Telefax:
(+45) 6362 1000 e-mail:
isd@KOMPAN.com
- 8 -
5) OBS! mount the green wire in the gray connector 6) Check the fastening by pulling the wires!
7) Fasten the cable to the metal rail using the cable 7a) Repeat the procedure for output II if needed
Fastener. Be sure that the shield of the cable is
fixed between the cable and the metal rail and
the cable fastener.
Kompan A/S
Korsvangen 11
DK 5750 Ringe Phone:
(+45) 6362 1250 Telefax:
(+45) 6362 1000 e-mail:
isd@KOMPAN.com
- 9 -
Connector overview
Connection table
Connect
Cable Wire: To output 1
terminal:
To output 2
terminal:
Orange
1 Orange
5 Orange
Black
2 Black
6 Black
Green
3 Gray
7 Gray
Blue
4 Blue
8 Blue
1 Orange +24V
2 Black 0V
3 Gray CAN-H
4 Blue CAN-L
5 Orange +24V
6 Black 0V
7 Gray CAN-H
8 Blue CAN-L
Output 1 Output 2
Kompan A/S
Korsvangen 11
DK 5750 Ringe Phone:
(+45) 6362 1250 Telefax:
(+45) 6362 1000 e-mail:
isd@KOMPAN.com
- 10 -
Installation of 110V/230V power cable
Installation of the 110/230V power cable must be done in compliance to local rules and
regulations for fixed installations.
The installation must be done by an authorised electrician or an equal qualified person.
OBS! Protective earthing is required!
Remove the circuit breaker cover and connect the power cable to the following terminals:
2T1=Phase
4T2=Neutral
6T3=Not connected
Yellow/Green = Protective earthing
Power cable
Otros manuales para ICON
1
Tabla de contenidos
Otros manuales de Juegos y equipos de juegos infantiles de KOMPAN
KOMPAN
KOMPAN FSW21300 Manual de usuario
KOMPAN
KOMPAN Pirate Manual de usuario
KOMPAN
KOMPAN GXY801800-3717 Manual de usuario
KOMPAN
KOMPAN M50503S Manual de usuario
KOMPAN
KOMPAN XY100 Manual de usuario
KOMPAN
KOMPAN XY200 Manual de usuario
KOMPAN
KOMPAN FAZ5010 Series Manual de usuario
KOMPAN
KOMPAN GXY801700-3717 Manual de usuario
KOMPAN
KOMPAN ASTM F3101 Manual de usuario
KOMPAN
KOMPAN XY200 Manual de usuario
KOMPAN
KOMPAN GXY802100-3717 Manual de usuario
KOMPAN
KOMPAN NAT824-0001 Manual de usuario
KOMPAN
KOMPAN Corocord 3144 Manual de usuario
KOMPAN
KOMPAN M87202-3817 Manual de usuario
KOMPAN
KOMPAN Fountain Manual de usuario
KOMPAN
KOMPAN GXY801900-3717 Manual de usuario
KOMPAN
KOMPAN CORE PLATFORM Manual de usuario
KOMPAN
KOMPAN M62405 Manual de usuario
KOMPAN
KOMPAN FAZ203000 Manual de usuario
KOMPAN
KOMPAN AB200085-128 Manual de usuario
Manuales populares de Juegos y equipos de juegos infantiles de otras marcas
Ledon
Ledon 302040 Manual de usuario
FUNormous
FUNormous Disney Junior MICKEY MOUSE Manual de usuario
b4Adventure
b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Manual de usuario
PoolMaster
PoolMaster 72775 Manual de usuario
Palmako
Palmako 4743142009857 Manual del instalador
BOERPLAY
BOERPLAY PSTE000.019 Manual de usuario
