King-Griller 3008 Manual de usuario
OM3008 B.3 ™ & © Char-Griller / A&J Mfg.
Stealth Griller Model # 3008
!
OWNER’S MANUAL
LP Gas Grill
WARNING
For Outdoor Use Only
(outside any enclosure)
DANGER:
DO NOT use gas grill for indoor cook-
ing or heating. TOXIC fumes can accu-
mulate and cause asphyxiation. Do
not use in or on boats or recreational
vehicles.
PROP 65 WARNING:
Chemicals known to the state of Cali-
fornia to cause cancer, birth defects
or other reproductive harm are creat-
ed by the combustion of propane.
SAVE THESE INSTRUCTIONS FOR FU-
TURE REFERENCE. IF YOU ARE ASSEM-
BLING THIS UNIT FOR SOMEONE ELSE,
GIVE THIS MANUAL TO HIM OR HER TO
SAVE FOR FUTURE REFERENCE.
FOR CUSTOMER SERVICE, CALL 912-
638-4724
WARNING:
Improper installation, adjustment, al-
teration, service or maintenance could
cause injury or property damage Read
the installation, operation and mainte-
nance instructions thoroughly before
assembling or servicing this equip-
ment.
A propane gas cylinder is required for
operation. This gas grill is not intended
for commercial use. Keep your receipt with this manual
OM3008 B.3 ™ & © Char-Griller / A&J Mfg. 2
! Danger
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open Lid.
4. If odor continues, keep away from the appliance and
immediately call your gas supplier or your fire depart-
ment.
! Warning
Do not store or use gasoline or other flammable liquids or va-
pors in the vicinity of this or any other appliance.
An LP cylinder not connected for use shall not be stored in the
vicinity of this or any other appliance.
For Your Safety
Stop! Call us first! Do Not return product to store. This grill has
been made to high quality standards. If you have any questions
not addressed in this manual or if you need parts please call our
customer service department at 1-912-638-4724 (USA), Mon-
day-Friday 8:30am-5pm (EST).
Have your grills serial number (located on the back of the grill
body or on the leg) when calling.
OM3008 B.3 ™ & © Char-Griller / A&J Mfg. 3
Important Safety Information .…………………page 4 - 5
Illustrated Parts List ……………………………..…page 6 – 7
Tools, Assembly Tips and Hardware List ….page 8
Assembly Instructions ……………………………..page 9 – 18
Operating Grill
Connecting Gas Cylinder…………………………..page 20
Cleaning and Care……………………………………page 21-22
Checking for Leaks………………………………..…page 23
Lighting Grill…...…………………………………….....page 24-26
Trouble Shooting……………………………………....page 27-28
Grill Preparation………………………………………..page 29
Recipes……………………………………………..…...…page 30 - 31
Accessories……………………………………………….page 32 - 33
Table of Contents
OM3008 B.3 ™ & © Char-Griller / A&J Mfg. 4
WARNING
FOR YOUR SAFETY
1.DO NOT store or use gasoline or any other flammable vapors and liquids within 25 feet
(8m) of this or any other appliance.
2. When cooking with oil/grease, do not allow the oil/grease to exceed 350°F (177°C).
Do not store or use extra cooking oil in the vicinity of this or any other appliance.
3. An LP Cylinder not connected for use should be stored a minimum of 10 feet (3m)
away from this or any other appliance. Never fill the cylinder beyond 80 percent
full. If the above information not followed exactly, a fire causing death or serious
injury may occur.
4. If you smell gas:
- Shut Off gas to the grill.
- Extinguish any open flame.
- Open Lid
For Your Safety
Stop! Call us first! Do Not return product to store. This grill has been made to high
quality standards. If you have any questions not addressed in this manual or if you
need parts please call our customer service department at 1-912-638-4724
(USA), Monday-Friday 9am-5pm (EST).
NOTE: The use and installation of this product must conform to local codes. In absence
of local codes, use the National Fuel Gas Code, ANSI Z223.1/NFPA54.
IMPORTANT NOTICE: read all instructions prior to assembly and use.
Read and understand all warnings and precautions prior to operating your grill.
CAUTION
1.This grill is for use with propane gas only (propane gas cylinder not included).
2.Never attempt to attach this grill to the self-contained propane system of a camper
trailer, motor home or house.
3.Never use charcoal or lighter fluid with the gas grill.
4. Do not use gasoline, kerosene or alcohol for lighting. The LP-gas supply cylinder must
be constructed and marked in accordance with the specifications for propane gas
cylinders of the U.S. Department of Transportation (DOT) CFR 49. This grill is not
intended to be used in or installed on recreation vehicles and/or boats.
5.Do not attempt to move the grill while it is lit.
6.Do not use the grill unless it is completely assembled and all parts are securely fas-
tened and tightened.
7.Keep all combustible items and surfaces at least 36 inches (91.4cm) away from grill
at all times.
8. DO NOT use this grill or any gas product near unprotected combustible constructions.
9. Do not use in an explosive atmosphere. Keep grill area clear and free from combus-
tible materials, gasoline and other flammable vapors and liquids.
OM3008 B.3 ™ & © Char-Griller / A&J Mfg. 5
10. Do not touch metal parts of grill until it has completely cooled (about 45 minutes) to
avoid burns, unless you are wearing protective gear (BBQ mittens, pot holders, etc.)
11. Do not alter this grill in any manner
12. Clean and inspect the hose before each use. If there is evidence of abrasion, wear,
cuts, or leaks, the hose must be replaced prior to operating the appliance. The re-
placement hose assembly will be that which is specified by the manufacturer.
13. Move gas hoses as far away as possible from hot surfaces and dripping hot grease.
14. Never Keep a filled container in a hot car or car trunk. Heat will cause the gas pres-
sure to increase, which may open the relief valve and allow gas to escape.
15. Keep the grill’s valve compartment, burners and circulating air passages clean. In-
spect the grill before each use.
WARNING
1. This grill is for outside use only, and should not be used in a building, garage or any
other enclosed area.
2. The use of alcohol, prescription or non-prescription drugs may impair the operator’s
ability to properly assemble or safely operate the grill.
3. Always open grill lid slowly and carefully as heat and steam trapped within the grill
can burn you severely.
4. Always place your grill on a hard, level surface far away from combustibles. An as-
phalt or blacktop surface may not be acceptable for this purpose.
5. Do not leave a lit grill unattended. Keep children and pets away form the grill at all
times.
6. Do not place this grill on any type of tabletop surface.
7. Do not use the grill in high winds.
8. Disconnect the propane tank (LP tank) by first turning off valve on top of propane
tank, turn off burner valves, then disconnect regulator from valve on propane tank
by turning plastic connector counter clockwise. Unscrew wing-bolt in bottom shelf to
release the tank for removal.
DANGER
Liquid propane (LP) gas is flammable and hazardous if handled improperly. Know its
characteristics before using any propane product.
1. Propane Characteristics; Flammable, explosive under pressure, heavier that air and
settles in pools and low areas
2. In its natural state, propane has no odor. For your safety, an odorant has been add-
ed.
3. Contact with propane can cause freeze burns to skin.
4. This grill is shipped from the factory for propane gas use only.
5. Never use a propane cylinder with a damaged body, valve, collar or footing.
6. Dented or rusted propane cylinders may be hazardous and should be checked by
your propane gas supplier.
OM3008 B.3 ™ & © Char-Griller / A&J Mfg. 6
1
2
3
4
5
6 7
8
9
12
10
14
15
16
17
18
18
19
20
21
22
23
25
24 26
27
11
13
28
29
OM3008 B.3 ™ & © Char-Griller / A&J Mfg. 7
LINE ITEM QTY PART NAME PART NUMBER
1 1 HOOD 30-0001
2 1 GRILL BODY 30-0002
3 1 THERMOMETER 55-0001
4 1 HOOD HANDLE 55-0002
5 1 WARMING RACK 20-0001
6 2 BURNER (short wire) 80-0001
7 1 BURNER (long wire) 80-0002
8 1 BASE 20-0002
9 3 FLARE-UP SHIELD 10-0001
10 1 FRONT SHORT LEG 20-0020
11 1 BACK SHORT LEG 20-0021
12 1 FRONT LONG LEG 20-0022
13 1 BACK LONG LEG 20-0023
14 1 BEZEL 10-0004
15 2 LEG CROSS BAR 10-0005
16 3 COOKING GRATE 10-0006
17 2 WHEEL 55-0003
18 2 LEG BRACE 10-0007
19 1 AXLE 10-0008
20 1 LOWER FRONT PANEL 10-0009
21 1 UPPER FRONT PANEL 10-0010
22 1 SIDE BURNER/ CONTROL PANEL 80-0012
23 3 UTENSIL HOOK 50-0001
24 1 GREASE TRAY 10-0011
25 1 CATCH PAN 20-0003
26 1 SIDE SHELF 20-0004
27 1 POT STAND 20-0005
28 1 HEAT SHIELD 10-0015
29 2 HUB CAP 55-0007
OM3008 B.3 ™ & © Char-Griller / A&J Mfg. 8
¼-20 x 1 ½” BOLT……4 PCS
¼-20 x 1/2” BOLT….... 40 PCS
2/5” FLAT WASHER….2 PCS
¼” FLAT WASHER….8 PCS
¼-20 HEX NUT……..6 PCS
¼” LOCK WASHER…40 PCS
HINGE PINS………..2 PCS
LARGE HAIR COTTER PIN….2 PCS
SMALL HAIR COTTER PIN….5 PCS
Assembly: Requires 2 people. Get another person to help.
Tools Needed: Pliers, Phillips Head Screwdriver and a 7/16” Nut Driver.
NOTE: Do Not tighten any bolts unless instructed to do so. Tightening too soon may
prohibit parts from fitting together. All Hex Nuts should be on the inside of the grill
unless stated otherwise. Unpack all contents in a well cleared and padded area.
STOP! Do Not Return to Store. If you are missing parts or need assistance please
you are missing parts.
Hardware:
OM3008 B.3 ™ & © Char-Griller / A&J Mfg. 9
Step 2
attach the leg assemblies from step 1 to the BASE, with (4) lock washers and (4)
1/2” Hex Bolts, see below.
Assembly Instructions
Step 1: Assemble SHORT BACK LEG, LONG BACK LEG, and LEG CROSS BAR togeth-
er. Then assemble SHORT FRONT LEG, LONG FRONT LEG, and LEG CROSS BAR to-
gether, see below.
Leg Cross Bars
Long Back Leg
Long Front Leg
Short Back Leg
Short Front Leg
Front Leg
Assembly
Back Leg
Assembly
Base
Bolts Lock Washers
OM3008 B.3 ™ & © Char-Griller / A&J Mfg. 10
Step 3
Install the two (2) LEG BRACES to the LEGS using (8) LOCK WASHERS and (8) ½”
BOLTS as shown.
Step 4
Install one WASHER, COTTER PIN and HUB CAP onto the AXLE then slide the AXLE
through WHEELS then insert the AXLE through the SHORT LEG, through the BASE,
and through the LONG LEG. Finish by attaching 2nd WASHER, COTTER PIN and HUB
CAP.
Axle
Wheel
Washer
Black Cotter Pin
Hub Cap
Short Leg
Lock Washers
Bolts
Leg Brace
Lock Washer Bolts
Leg Brace
Lock Washer
Tabla de contenidos
Otros manuales de Parrilla de King-Griller
King-Griller
King-Griller 5252 Manual de usuario
King-Griller
King-Griller 5252 Manual de usuario
King-Griller
King-Griller 16619 Manual de usuario
King-Griller
King-Griller 6620 Manual de usuario
King-Griller
King-Griller JR. AKORN Kamado Kooker 06614 Manual de usuario
King-Griller
King-Griller GAMBLER E1416 Manual de usuario
