Keofitt STEAM BOILER Manual de usuario

DON’T GAMBLE WITH YOUR SAMPLE™

STEAM BOILER

User ManUal

DOCUMENT VERSION LOG

The table below lists previous versions of this User Manual and states the major changes between

versions.

This version list is introduced in December 2016.

Version # Version date Major changes from previous versions

1 1th December 2016 Complete revision and new layout.

INTRODUCTION:

MANUFACTURER: KeottA/S

Kullinggade 31

  5700Svendborg,Denmark

TYPE: SteamBoiler

YEAR OF INTRODUCTION: 2016

YEAR OF REVISED DESIGN: 2016

LAST UPDATED: 2016

TheEnglishversionofthisManualisthegoverningversionanditistheonlyauthorizedversion.Consequently,KEOFITT

cannot be held liable for other versions including translations of this Manual.

CONTENTS

1. PORTABLE STEAM CLEANING UNIT FOR CLEANING SAMPLE VALVES....................................... 5

2. PORTABLE MICRO BURNER .........................................................................................................6

3. HOW TO USE .................................................................................................................................7

KEOFITT USER MANUAL PAGE 5

1. PORTABLE STEAM CLEANING UNIT FOR CLEANING SAMPLE VALVES

TheKEOFITTSteamBoilerisasimpleandrugged,portabledevicedesignedtoprovidesteamathand

insamplinglocationswhereaxedsteamsupplyisnotavailable.

TheSteamBoilerisusedforsteamingsamplingvalvesasameansofcleaninganddisinfectingthe

samplingvalvepriortoextractingthesample.Thisensuresthesampletakenisfreeofanycriticallevel

ofmicroorganisms(seeIMPORTANTbelow)andisrepresentativeofthegreatercontentsoftheproduct

being sampled.

IMPORTANT

•Microorganismshavedifferentlethalitydependingontemperatureandexposuretime

•ThesteamproducedintheSteamBoilerisnotpressurized,sothesteamtemperatureis

onlyaround100°C(212°F)

•Makesurethatthetypeandlevelofcriticalmicroorganismsinyourapplicationaresuchthat

steamat100°C(212°F)willsufce.Partofthecleaninganddisinfectionisobtainedthroughthe

ushingeffectoftheowofsteam,whichremovesthemicroorganismbutnotnecessarilykillsit.

Theunitisgasredandholds400mlofwater.

WaterCapacity:   approx.400ml

Dimensions:   approx.150mmDia.x200mmH

Weight:   approx.2.5kg

Materialsofconstruction: allwettedpartsofstainlesssteel,PTFEandaluminum

KEOFITT USER MANUAL PAGE 6

2. PORTABLE MICRO BURNER

The lab burner is designed with safety in mind.Thestable,

tip-resistantburnerprovidessafe,stableoperation.Thelever-

action igniter and ame adjustment knob ensure you get

thecontrollableamesizeyouneedwithinseconds.Itrells

quicklyandeasilyusingthellvalvebuiltintotheburnerbase

andastandardmulti-llbutanefuelcartridge.

This portable butane micro lab burner holds 30 grams of

butanewhenfullyrefueled,whichburnsfor35-60minutes,

depending on ame intensity. The output of this laboratory

burnerreaches2500BTUhouranditboilsa250mlbeakerof

waterinaboutveminutes.Itgeneratesaametemperature

ofupto2200For1200C.

•Fuel:butane

•Fuelcapacity:30grams/50ml

•Maximumburnrate:upto0.9grams/minute

•Burntime:about35minutesatmaximumburn,60minutesathalf-burn

•Maximumheatoutput:about2500Btu/hour(0.75kW)

•Maximumtemperature:about1200°C/2200°F

•Ignition:Push-buttonPiezo

•Unitsize:125mm(L)x80mm(W)x75mm(H);;4.9”(L)x3.1”(W)x3”(H)

•Unitweight(empty):400grams

•CEcertied

KEOFITT USER MANUAL PAGE 7

3. HOW TO USE

FILL FUEL

Placetheuniteitheronitssideorupsidedown,makingnotetoseeifanywaterisinside,asthiswill

drainoutiftheoutletissubmerged.Useasuitablebutanecartridgetoll,followingtheinstructionsfor

lling.Afterllingitisbesttowaitforanyexcessfumestodissipatethatcanoccurduringlling.

FILL THE VESSEL WITH WATER

Opentheplugontop,andllwithapproximately100to400mlwater,andreplacetheplug.

LIGHT THE BURNER

Turnthegascontrolknobon,andlistenforthegas,presstheopposingignitionswitchtolightthe

burner,adjusttheameheightandintensitytoboil.Bringthewatertoaboil,takingcaretokeepthe

endofthehoseawayfromanythingthesteam/condensatecouldharm.Aftersteamhasbeenstarted,

youcanturntheunitoffwiththeburnergascontrolknobandtaketoyoursamplepoint.

STEAMING THE VALVE

Hookthehandleoverthevalveandconnectthehosetothetopportofthevalve.ConsulttheKEOFITT

SamplingValveManualforfullinstructionsonsteamingandsampling.Starttheburnerandbringthe

waterbackuptosteam,whichshouldonlytakeafewmomentsdependingonthetimesincethetank

washeated.Steamthevalveoneminuteanddisconnecthosewithquick-coupling.

SAMPLING

Placeasanitizedrubberorstainlessplugoverthetopportandthecollectionvessel/bagtothebottom

portandoperatethevalveaccordingtothemanualtotakethesample.Aftersampling,thevalveshould

beushed,lledwithadisinfectantandcappedtokeepthevalveinacleanandsealedcondition

protectedfromtheenvironmentuntilthenextsampleprocedure.

CAUTION

ASAGASHEATINGDEVICEITISIMPERATIVETOOPERATEINASUFFICIENTLYVENTILATEDAREA,USING

GLOVES,PROTECTIVEGLASSESANDPROPERATTIRE.TAKINGALLNECESSARYPRECAUTIONS.

Seeillustrationsonnextpage.

KEOFITT USER MANUAL PAGE 8

CAUTION

• ASAGASHEATINGDEVICEITISIMPERATIVETOOPERATEINASUFFICIENTLYVENTILATED

AREA,USINGGLOVES,PROTECTIVEGLASSESANDPROPERATTIRE.TAKINGALLNECESSARY

PRECAUTIONS.

1. FILLBUTANEINTOBURNERPORT.

2. REMOVETOPFILLPLUG.FILLWATERINTOSTEAMERFILL

PORT–100TO400mL.

REPLACEPLUG.

3. TURNGASCONTROLON,USETOTURNBURNERONAND

OFFANDCONTROLFLAMEHEIGHTANDINTENSITY

4. PRESSIGNITERLEVERTOLIGHTBURNERPRELIMINARY

KEOFITTA/S

Kullinggade 31

DK-5700Svendborg

Denmark

Phone+4563167080

Fax+4563167081

info@keott.dk

www.keott.dk

Keottreservestherighttochangetechnicaldatawithoutnotice!

ForcompletesetofupdateddatasheetsandmanualsforKeottproductspleaserefertoourwebpagewww.keott.dk

Otros manuales de Caldera de Keofitt

Keofitt

Keofitt 550000 Manual de usuario

Manuales populares de Caldera de otras marcas

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Manual de usuario

Radijator

Radijator BIO max 23.1 Manual de usuario

Brunner

Brunner BSV 20 Manual de usuario

Buderus

Buderus Logamax GB062-24 KDE H V2 Manual de usuario

Potterton

Potterton 50e Hoja de datos

UTICA BOILERS

UTICA BOILERS TriFire Manual de usuario

Joannes

Joannes LADY Series Manual

ECR International

ECR International UB90-125 Manual de instrucciones

Froling

Froling FHG Turbo 3000 Manual de usuario

Froling

Froling P4 Pellet 8 - 105 Manual de usuario

U.S. Boiler Company

U.S. Boiler Company K2 Manual de usuario

Henrad

Henrad C95 FF Manual de usuario

NeOvo

NeOvo EcoNox EF 36 Manual de usuario

Potterton

Potterton PROMAX SL 12 Manual de usuario

Eco Hometec

Eco Hometec EC 25 COMPACT Manual de usuario

Viessmann

Viessmann VITODENS 200 Guía

Baxi

Baxi Prime 1.24 Manual de usuario

REXNOVA

REXNOVA ISA 20 BITHERMAL Manual de usuario