JL Audio Stealthbox SB-D-CLBR/10W1v2 Manual de usuario

INSTALLATION GUIDE

for the

SB-D-CLBR/10W1v2

2007 - Up

Dodge Caliber

Thank you for choosing a JL Audio Stealthbox®for your automotive sound system. With proper

installation, your new vehicle-specific enclosed subwoofer system will deliver years of listening pleasure.

We strongly recommend that you have your new Stealthbox®installed by your authorized JL Audio

dealer. The installation professionals employed by your dealer have the necessary tools and experience

to disassemble and reassemble your vehicle properly. Also, keep in mind that your warranty coverage

extends to 1 year if your system is installed or approved by your authorized JL Audio dealer. If you

prefer to perform your own installation, please read this installation guide completely

before beginning the process.

If you choose to perform the installation yourself, it is absolutely vital that

the Stealthbox®be properly mounted to the vehicle according to these

instructions. Failure to mount the enclosure properly presents two problems:

1) The sub-bass performance will suffer due to the movement of the enclosure

caused by the force exerted by the woofer(s).

2) A loose enclosure presents a serious safety hazard in the event of a collision

or sudden deceleration.

STEP 1

Remove all contents from the cargo area.

Continued on Next Page

STEP 2

Remove the right side rear hold down cleat.

STEP 3

Pull the plastic flooring and rear sill plate out.

SB-D-CLBR/10W1v2_INSTR_SKU#011236

INSTALLATION

DIFFICULTY:

OUT

ESTIMATED TIME:

1 HOUR

STEALTHBOX WALL THREADED INSERT

VEHICLE SHEET METAL

LOCK WASHER

FLAT WASHER HEX HEAD BOLT

FENDER WASHER

Continued on Next Page

SB-D-CLBR/10W1v2_INSTR_SKU#011236

STEP 7

Position the Stealthbox® into place.

This mounting area is a tight fit. The Stealthbox® needs to

angle into the mounting area. Start by sliding the rear of

the Stealthbox ® into the mounting area. Then turn the

Stealthbox® clockwise.

STEP 6

Fully thread the supplied hex bolt into the bottom of the

Stealthbox®.

STEP 5

Place the supplied wax square into position, as in the picture.

STEP 4

Remove the right side rear cargo panel out of the car.

Page 2 • JL Audio, Inc 2007

STEP 9

Note: Before drilling, make sure that you are not

going to be drilling into any gas lines, brake lines,

transmission lines, electrical wiring, transfer case

(4x4 vehicles) or anything else that might cause

a reduction in your weekly pay. Always wear eye

protection when drilling!

With a drill and a 1/2-inch drill bit, drill through the

impression made in the wax square. Remove the wax square.

STEP 11

Place the supplied lock washer, flat washers and then fender

washer onto the hex bolt.

From under the car place the hex bolt assembly up through

the floor and into the threaded insert on the bottom of the

Stealthbox®.

Secure the bolt assembly.

Note: For added protection, it is recommended that

you apply a bead of silicone between the vehicle and

the fender washer. After the bolt assembly is tightly

secured, it is also recommended that vehicle under-

coating material is applied to the exposed assembly.

STEP 10

Run speaker wire from the amplifier location to the

Stealthbox® location and check for proper operation of

the woofer.

Back out the hex bolt that was installed in Step 6.

Place the Stealthbox® back into the mounting area.

STEP 8

Press down on to the Stealthbox® firmly.

Remove the Stealthbox® carefully, leaving the wax square in

place. The hex bolt will leave an impression onto the wax.

SB-D-CLBR/10W1v2_INSTR_SKU#011236

CONGRATULATIONS

You have completed the installation for this model!

Please refer to the Power Recommendation section for an

amplifier recommendation and basic set-up help.

STEP 14

Place the plastic flooring and rear sill plate back into place,

from STEP 3.

Mount the right side rear hold down cleat back into place,

from STEP 2.

STEP 13

Place a supplied washer onto each supplied screw.

Place the supplied grille into the location of the door that

was removed in STEP 12.

From the back side cargo panel, pass each screw assembly

through a factory hole. As seen in the picture.

Secure the grille to the side cargo panel.

Place the side cargo panel back into the car, from STEP 4.

STEP 12

Remove the door that is located on the front of the side

cargo panel.

Grind off the plastic weld tabs that secure the pocket to the

back of the side cargo panel.

Page 3 • JL Audio, Inc 2007

All specifications are subject to change without notice. “JL Audio®” and the JL Audio logo, “Stealthbox” and the Stealthbox logo are registered

trademarks of JL Audio, Inc.“Ahead of the Curve” and its respective logo is a trademark of JL Audio, Inc.

JLA-SKU#011236 -08-21-200

#6,243,479 #6,294,959 #6,501,844 #6,496,590 #6,441,685 #5,687,247 #6,219,431 #6,625,292 #D472,891 #D480,709 Other U.S. & Foreign

patents pending. For more detailed information please visit us online at www.jlaudio.com.

(954) 443-1100

www.jlaudio.com

10369 NORTH COMMERCE PARKWAY • MIRAMAR, FLORIDA • 33025 • USA

INCLUDED HARDWARE

(1)

3/8-inch x 1-1/2-inch Fender Washer

(1)

3-inch x 3-inch Wax Square

(1)

3/8-inch -16 x 2-1/2-inch Hex Tap Bolt

(1)

3/8-inch Split lock Washer

(1)

3/8-inch Flat Washer

SPECIFICATIONS

Enclosure Type:

Acoustic Suspension (sealed)

Driver Type:

10W1v2

Nominal Impedance:

4 ohms mono

Continuous Power Handling:

150 Watts

150 Wat ts

POWER RECOMMENDATION

JL Audio recommends using a high quality amplifier such as the JL Audio A2150.

The diagram below shows the recommended crossover, infrasonic filter and equalizer settings for the A2150 when

being used to power your Stealthbox®.

The JL Audio A2150 is a very versatile audio component. Please consult the owner’s manual for even more

detailed information about installing and tuning this amplifier.

MID/HIGH FREQUENCY DRIVER FITMENT

A variety of JL Audio coaxial and component systems will fit in the factory speaker locations of you vehicle.

Front Speaker Size / Location:

6-inch x 9-inch / Front Doors

Fits JL Audio Models:

TR690-TXi & VR690-CXi

Rear Speaker Size / Location:

6-inch x 9-inch

/ Rear Doors

Fits JL Audio Models:

TR525-CXi, VR525-CXi & XR525-CXi

Otros manuales de Sistema estéreo para automóvil de JL Audio

JL Audio

JL Audio Stealthbox SB-GM-S10STD/8W1 Manual de usuario

$JL Audio Stealthbox SB-B-3SER/CPE/SDN(E90\92) Manual de usuario$

JL Audio

JL Audio Stealthbox SB-B-3SER/CPE/SDN(E90\92) Manual de usuario

JL Audio

JL Audio Stealthbox SB-F-FCSZX/10W3v3 Manual de usuario

JL Audio

JL Audio Stealthbox SB-GM-CAM6G/12W6v3 Manual de usuario

JL Audio

JL Audio Stealthbox SB-D-TRKEXT/10W1 Manual de usuario

JL Audio

JL Audio Stealthbox SB-B-7SER/10W6v2 Manual de usuario

JL Audio

JL Audio Stealthbox SB-GM-C7CP1 Manual de usuario

JL Audio

JL Audio SB-CAN-MVX3/10TW3 Manual de usuario

JL Audio

JL Audio Stealthbox SB-D-5GRAMCCR/10TW3 Manual de usuario

JL Audio

JL Audio Stealthbox SB-H-PIO5/10TW3 Manual de usuario

JL Audio

JL Audio Stealthbox SB-F-150-SCDBL/12TW3 Manual de usuario

JL Audio

JL Audio Stealthbox SB-D-DAKCC/10W3v3 Manual de usuario

JL Audio

JL Audio Stealthbox SB-F-ESCP/10W1v2 Manual de usuario

JL Audio

JL Audio Stealthbox SB-GM-C6CONV/8W3v3 Manual de usuario

JL Audio

JL Audio SB-F-MUCONV2/13W6V2 Manual de usuario

JL Audio

JL Audio stealthbox SB-POL-ACE/10TW1 Manual de usuario

JL Audio

JL Audio Stealthbox SB-B-5SER/12W6v2 Manual de usuario

JL Audio

JL Audio ZR650-CSi Manual de usuario

JL Audio

JL Audio Stealthbox SB-F-RTRKCTR/12W3v2 Manual de usuario

$JL Audio Stealthbox SB-B-3SER/CPE/SDN(E90\92) Manual de usuario$

JL Audio

JL Audio Stealthbox SB-B-3SER/CPE/SDN(E90\92) Manual de usuario

JL Audio

JL Audio Stealthbox SB-H-XTOUR/10W3v3 Manual de usuario

JL Audio

JL Audio Stealthbox SB-D-TRKCTR/12W3v2 Manual de usuario

JL Audio

JL Audio Stealthbox SB-K-SORNTO/10TW3 Manual de usuario

JL Audio

JL Audio Stealthbox SB-F-MU94+/10W3 Manual de usuario

Manuales populares de Sistema estéreo para automóvil de otras marcas

Clarion

Clarion PU-9836A Manual de usuario

Sony

Sony MEX-BT5750U Manual de usuario

Mitsubishi Electric

Mitsubishi Electric AR0M Manual de usuario

Sony

Sony RM-X7BT Manual de usuario

Insignia

Insignia NS-HD5113 Manual de usuario

Clarion

Clarion BTD3341 Manual de usuario

USA SPECS

USA SPECS PA11-VW6 Manual de usuario

Sony

Sony MEX-N4380BT Manual de usuario

Kenwood

Kenwood KCD-BT6544U/UY Manual de usuario

JVC

JVC KD-DB912BT Manual de usuario

Philips

Philips CSQ405/98 Manual de usuario

Alpine

Alpine TDM-7544 Manual de usuario

Autotek

Autotek TransAm TA 1400 Manual de usuario

Clarion

Clarion PN-3124N-A Manual de usuario

Denso TEN

Denso TEN FT0108A Manual de usuario

Pyle

Pyle PLD57MU Manual de usuario

Harman

Harman Chrysler Radio Navigation System RB4 Manual de usuario

Clarion

Clarion VS735 Manual de usuario