JL Audio C2-400x Manual de usuario

OWNER’S MANUAL

Thank you for choosing a JL Audio Evolution™ C2 Coaxial Speaker System

for your automotive sound system.

These Evolution™ Speakers have been designed and manufactured to

exacting standards in order to ensure years of musical enjoyment in your

vehicle. For maximum performance, we highly recommend that you have

your new speakers installed by an authorized JL Audio dealer. Your

authorized dealer has the training, expertise and installation equipment

to ensure optimum performance from this product. Should you

decide to install the speakers yourself, please take the time

to read this manual thoroughly so as to familiarize yourself

with its installation requirements and setup procedures.

If you have any questions regarding the instructions in this

manual or any aspect of your amplifier’s operation, please contact your

authorized JL Audio dealer for assistance. If you need further assistance,

please call the JL Audio Technical Support Department

at (954) 443-1100 during business hours.

4.00-inch (100 mm) Coaxial Loudspeakers

2 | JL Audio - C2-400x Owner’s Manual

Due to ongoing product development, all specifications are subject to change without notice.

Woofer Physical Dimensions

Frame Outer Diameter (A) 4.02 in. / 102.0 mm

Grille Tray Outer Diameter (B) 5.20 in. / 132.2 mm

Magnet Outer Diameter (C) 2.36 in. / 60.0 mm w/o cover

Frontal Tweeter Protrusion (D) 0.56 in. / 14.3 mm

Frontal Grille Protrusion (E) 0.66 in / 16.7 mm

Mounting Hole Diameter (F) 3.81 in. / 96.8 mm

Mounting Depth (G) 1.81 in. / 46.0 mm w/o cover

2 | JL Audio - C2-400x Owner’s Manual

C2-400x SPECIFICATIONS:

Woofer: Injection-molded, Mica-filled, Polypropylene Cone,

Butyl Rubber Surround, 1 in. Voice Coil on Kapton® Former,

Flat, Symmetrical Roll Spider, Ferrite Magnet

Tweeter: 0.75 in. (19 mm) Silk Dome, Ferrofluid Cooling /

Damping, Neodymium Magnet

Crossover: Natural Roll-Off Low-Pass, 1st Order High-Pass

Filter with Electrolytic Capacitor

Continuous Power Handling: 35 Watts

Recommended Amp Power: 10-50 Watts per channel (RMS)

Efficiency: 84.5 dB @ 1W/1m | 90.5 dB @ 1W/0.5m

Sensitivity: 87.5 dB @ 2.83V/1m

Nominal Impedance: 4 ohm

Frequency Response: 71 Hz - 22 KHz ± 3 dB

Included Components and Parts:

• Two C2-400x 4.0-inch (100mm) Coaxial loudspeakers

• Two Grille Assemblies

• Eight #8 x 1-inch (25mm) sheet metal screws

• Eight Mounting Clips

• Two 4x6-inch (100 x 150 mm) Adaptor Plates

• Two 5.2 mm female crimpable connectors

• Two 2.8 mm female crimpable connectors

• Four #8 x 0.315-inch (8 mm) sheet metal screws

• Two self-adhesive JL Audio logo name badges

GETTING STARTED

•Turnofftheaudiosystem.Itisalso

advisabletodisconnectthenegative(–)

terminalofyourvehicle’sbatterywhenever

performinginstallationwork.

•Beforecutting,drillingorinsertinganyscrew,

checkclearancesonbothsidesoftheplanned

mountingsurface.Alsocheckforanypotential

obstacles,suchaswindowtracksandmotors,

wiringharnesses,etc.Checkbothsidesofthe

vehicle,manyvehiclesarenotsymmetrical!

•Alwayswearprotectiveeyewear.

SPEAKER PLACEMENT CONSIDERATIONS

Inmostcases,yourspeakerswillbeplacedinto

factoryspeakerlocations.Ifyouhavesomespeaker

mountingflexibility,keepthefollowinginmind:

Lowermountinglocations,suchasthelowerfront

cornerofadoororakick-panelprovidethegreatest

pathlengthdistancesforthesoundemittedbythe

speakers.Forthisreason,theyaregenerallymore

desirablethanhighermountinglocations.Higher

mountinglocationswillusuallyresultinextreme

near-sidesoundstagebiaswhichcompromisesthe

stereolisteningexperience.

4 | JL Audio - C2-400x Owner’s Manual

Itisabsolutelyvitalthatthespeakerframe

fitsintothemountingholecleanly.Thismustbe

checkedpriortotighteningthescrews.Donot

forcetheframeintoaholethatistoosmall.Do

nottightenthespeakerontoanunevensurface.

Thiswilldamageyourspeakers.Thespeaker

shouldalsofitsothatairdoesnotleakaround

themountingflange.Airleakswillcauseasevere

degradationinsoundquality.Sealanyairleaks

withanautomotive-gradesealantmaterial.

InstallasshowninDiagramA(page5).Usethe

suppliedmountingclipsunlessthefactoryholes

alreadyfeaturethreadedinserts.Hand-tightenthe

screwsevenlytoavoidbendingthespeakerframe!

Custom Location:Runspeakerwiretothe

desiredmountinglocation.Ifyouarerunning

wiresintoadoor,useexistingfactorywiringboots

wheneverpossible.Ifyouaredrillingnewholes,file

theiredgesandinstallrubbergrommetsintoeach

hole.Then,coverthewireswithaprotectivePVC

sleeveandrunthemthroughthedoorjamb.Make

surethatthewireswillcleardoorhingesandother

structuresinthedoor.Ifyouareunsureaboutany

partofthisprocess,pleasecontactyourJLAUDIO

dealerforinstallationhelp.

WARNING



Double check the clearance for both speakers

before proceeding. Many cars are different from

one side to the other!

Selectanevensurface.Tighteningaspeakeronto

anunevensurfacecandamageit.Usethesupplied

templatetomarkthedesiredmountinglocation.Mark

thecenterandtheoutlineofthemountingholeas

wellasthemountingscrewpositions.Beforedrilling

orcuttingonyourinteriorpanels,useautilityknife

tocutanyfabric,vinylorleatherfromholelocations.

Thesematerialscaneasilybesnaggedbyadrillor

asaw,causingdamagetothepanelandpossible

bodilyinjury.Drillfour1/8-inch(3mm)holesforthe

speaker’smountingscrewsatthepositionsyouhave

marked.Alsodrillapilotholeinthecenterofthe

speakermountingholeatthistime.

SPEAKER INSTALLATION

Thespeakershouldbeinstalledinoneofthe

followingwaysdependingonlocation:

Factory Location:Ifyouwillbeusingthefactory

speakerwires,itmaybenecessarytochangethe

terminations.Thismaybeaccomplishedbyusingan

adaptorplugorsimplybycuttingthefactoryconnector

offandusingthesuppliedcrimpconnectorsto

terminatethespeakerwires.Thelargeconnectorisfor

thepositiveterminalandthesmallconnectorisforthe

negativeterminalofeachC2-400x.

Youmayalsochoosetorunnewspeakerwires...

Runspeakerwiretothedesiredmounting

locations.Ifyouarerunningwiresintoadoor,use

existingfactorywiringbootswheneverpossible.If

youaredrillingnewholes,filetheiredgesandinstall

rubbergrommetsintoeachhole.Wiresshouldthen

becoveredwithaprotective,flexiblePVCsleeveand

thenrunthroughthedoorjamb.Makesurethatthe

wireswillcleardoorhingesandotherstructuresin

thedoor.Ifyouareunsureaboutanypartofthis

process,pleasecontactyourJLAudiodealerfor

installationhelp.

WARNING



Double check the clearance for both speakers

before proceeding. Many cars are different from

one side to the other!

Yournewspeakershavebeendesignedtoinstall,

withoutmodifications,intomostvehiclesthataccept

a4.0-inch(100mm)speakeror4x6-inchoval

speaker(adaptorplatesaresuppliedforthelatter).

Mostfactory4.0-inchspeakersusefourmounting

screwswhichwilllineupwiththemountingholes

onyourC2-400xspeakers.Insomevehicles,only

twomountingholesareusedandthereisinsufficient

clearanceforthetwoextramountingtabs.Ifthis

isthecase,bendtheredundanttabsbackandforth

untiltheybreakoff(allfourtabsontheC2-400xare

perforatedforthispurpose).Afterbreakingoffthe

unwantedtabs,pleasehandlethespeakercarefully,

asthebrokenedgesmaybesharp.

4 | JL Audio - C2-400x Owner’s Manual

Then,usingasabersaw,makethecircularcutoutfor

thespeaker.Fileanyroughedges.Insertthemounting

clipswiththeflatsidetowardsthespeakerasshownin

DiagramB(below).

Itisabsolutelyvitalthatthespeakerframefitsinto

themountingholecleanly.Thismustbecheckedprior

totighteningthescrews.Donotforcetheframeintoa

holethatistoosmall.Donottightenthespeakeronto

anunevensurface.Thiswilldamageyourspeakers.

Thespeakershouldalsofitsothatairdoesnotleak

aroundthemountingflange.Airleakswillcausea

severedegradationinsoundquality.Sealanyairleaks

withanautomotive-gradesealantmaterial.

Diagram A:

Factory Location Woofer Installation

WARNING

Hand-tighten the screws evenly in a criss-cross

pattern to avoid bending the speaker frame or

stripping the mounting clips.

Connectthespeakerwires,observingcorrect

polarity,andinstallthespeakerandgrilleassembly

asshowninDiagramB(below).Hand-tightenthe

screwsevenlytoavoidbendingthespeakerframe!

TheincludedJLAudiologonamebadgesshould

beaffixedtothecircularindentedareainthelower

partofeachgrilleassembly.Ifthegrilleassemblyis

notused,theJLAudiologobadgescanbeaffixed

elsewhereascreativeadditionstoyourinstallation.

Diagram B:

Custom Location Woofer Installation

6 | JL Audio - C2-400x Owner’s Manual

NOTES

6 | JL Audio - C2-400x Owner’s Manual

NOTES

LIMITED WARRANTY  AUTOMOTIVE SPEAKER SYSTEMS USA

JLAUDIOwarrantsthesespeakers(andcrossovernetworks,whereapplicable)tobefreeofdefectsin

materialsandworkmanshipforaperiodofone (1) year.

Thiswarrantyisnottransferableandappliesonlytotheoriginalpurchaserfromanauthorized

JLAUDIOdealer.Shouldservicebenecessaryunderthiswarrantyforanyreasonduetomanufacturing

defectormalfunction,JLAUDIOwill(atitsdiscretion),repairorreplacethedefectiveproductwithnewor

remanufacturedproductatnocharge.Damagecausedbythefollowingisnotcoveredunderwarranty:accident,

misuse,abuse,productmodificationorneglect,failuretofollowinstallationinstructions,unauthorizedrepair

attempts,misrepresentationsbytheseller.Thiswarrantydoesnotcoverincidentalorconsequentialdamages

anddoesnotcoverthecostofremovingorreinstallingtheunit(s).Cosmeticdamageduetoaccidentornormal

wearandtearisnotcoveredunderwarranty.

Anyapplicableimpliedwarrantiesarelimitedindurationtotheperiodoftheexpresswarrantyasprovided

hereinbeginningwiththedateoftheoriginalpurchaseatretail,andnowarranties,whetherexpressorimplied,

shallapplytothisproductthereafter.Somestatesdonotallowlimitationsonimpliedwarranties,therefore

theseexclusionsmaynotapplytoyou.Thiswarrantygivesyouspecificlegalrights,andyoumayalsohaveother

rightswhichvaryfromstatetostate.



If you need service on your JL AUDIO product:

AllwarrantyreturnsshouldbesenttoJLAUDIOfreightprepaidthroughanauthorizedJLAUDIO

dealerandmustbeaccompaniedbyproofofpurchase(acopyoftheoriginalsalesreceipt.)Direct

returnsfromconsumersornon-authorizeddealerswillberefusedunlessspecificallyauthorizedby

JLAUDIOwithavalidreturnauthorizationnumber.Warrantyexpirationonproductsreturned

withoutproofofpurchasewillbedeterminedfromthemanufacturingdatecode.Coveragemaybe

invalidatedasthisdateisprevioustopurchasedate.Returnonlydefectivecomponents.Ifonespeaker

failsinasystem,returnonlythatspeakercomponent,nottheentiresystem.Non-defectiveitems

receivedwillbereturnedfreight-collect.Customerisresponsibleforshippingchargesandinsurance

insendingtheproducttoJLAUDIO.Freightdamageonreturnsisnotcoveredunderwarranty.

For Service Information in the U.S.A. please call

JL Audio Customer Service: (954) 443-1100

9:00 AM – 5:30 PM (Eastern Time Zone)

JL Audio, Inc

10369 North Commerce Pkwy.

Miramar, FL 33025

International Warranties:

Products purchased outside the United States of America are covered only

by that country’s distributor and not by JL Audio, Inc.

C2-400x-06112008

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Altavoces para coche de JL Audio

JL Audio

JL Audio Evolution C5-650 Manual de usuario

JL Audio

JL Audio C2-690tx Manual de usuario

JL Audio

JL Audio MX650-CCX Manual de usuario

JL Audio

JL Audio C5-570X Manual de usuario

JL Audio

JL Audio SB-F-SUPRCNSL/10W3v2 Manual de usuario

JL Audio

JL Audio stealthbox SB-J-WRUD/10TW1 Manual de usuario

JL Audio

JL Audio XR525-CXi Manual de usuario

JL Audio

JL Audio ZR525-CSi Manual de usuario

JL Audio

JL Audio 94607 Manual de usuario

JL Audio

JL Audio C2-690tx Manual de usuario

JL Audio

JL Audio Stealthbox SB-F-SUPRCNSL/10W3v3 Manual de usuario

JL Audio

JL Audio XR570-CXi Manual de usuario

JL Audio

JL Audio XR653-CS Manual de usuario

JL Audio

JL Audio Evolution C5-570x Manual de usuario

JL Audio

JL Audio C5-650x Manual de usuario

JL Audio

JL Audio Evolution C5-650 Manual de usuario

JL Audio

JL Audio ZR570-CSi Manual de usuario

JL Audio

JL Audio C2-600x Manual de usuario

JL Audio

JL Audio C2-650x Manual de usuario

JL Audio

JL Audio XR650-CSi Manual de usuario

JL Audio

JL Audio C2-650x Manual de usuario

JL Audio

JL Audio TR600-CXi Manual de usuario

JL Audio

JL Audio Stealthbox SB-POL-RZG2SPKR/MX650 Manual de usuario

JL Audio

JL Audio C3-100ct Manual de usuario

Manuales populares de Altavoces para coche de otras marcas

Blaupunkt

Blaupunkt GTt 300 Hoja de especificaciones

Boston Acoustics

Boston Acoustics SX55 Manual de usuario

Kenwood

Kenwood KFC-W212 Manual de usuario

VR3

VR3 Elite VRS653 Manual de usuario

Premier

Premier TS-W3001D4 Manual de usuario

Infinity

Infinity 6530cx Manual de usuario

Focal

Focal K2 Power 165 KRX3 Manual de usuario

Precision Power

Precision Power PPI4.2 Manual de usuario

Mopar

Mopar 2011-UP Manual de usuario

Jensen

Jensen XS Series Manual de usuario

Blaupunkt

Blaupunkt GTx Series Manual de usuario

AudioBahn

AudioBahn AT60 Manual de usuario

Focal

Focal BombA 27 V1 Manual de usuario

Blueant

Blueant S1 Manual de usuario

Naxa

Naxa NCS-768 Manual de usuario

Focal

Focal Polyglass 130 VRS Manual de usuario

Boston Mobile Audio

Boston Mobile Audio SR80 Manual de usuario

Blaupunkt

Blaupunkt GTx 352 DE Manual de usuario