IEI Technology JUKI- 740E Manual de usuario

JUKI- 740E

User Manual

Version 4.0

Pentium®with LCD/CRT & Ethernet

PCISA Bus Single Board Computer

February 10, 2004

The information in this document is subject to change without prior notice in

order to improve reliability, design and function and does not represent a

commitment on the part of the manufacturer.

In no event will the manufacturer be liable for direct, indirect, special, incidental,

or consequential damages arising out of the use or inability to use the product or

documentation, even if advised of the possibility of such damages.

This document contains proprietary information protected by copyright. All rights

are reserved. No part of this manual may be reproduced by any mechanical,

electronic, or other means in any form without prior written permission of the

manufacturer.

Trademarks

JUKI-740E is a registered trademarks of ICP Electronics Inc. IBM PC is a

registered trademark of International Business Machines Corporation. Intel is a

registered trademark of Intel Corporation. AMI is registered trademarks of

American Megatrends, Inc. Other product names mentioned herein are used for

identification purposes only and may be trademarks and/or registered trademarks

of their respective companies.

TABLE OF CONTENTS

CHAPTER 1. INTRODUCTION....................................................... 4

1.1 SPECIFICATIONS ............................................................................5

1.2 PACKAGE CONTENTS ........................................................................6

CHAPTER 2. INSTALLATION ........................................................7

2.1 JUKI-740E LAYOUT .......................................................................7

2.2 CPU SETTINGS OF JUKI-740E ............................................................8

2.3 WATCH-DOG TIMER........................................................................ 10

2.4 DISKONCHIP™ FLASH DISK ............................................................. 10

2.5 LCD VOLTAGE SETTING ................................................................... 11

2.6 CLEAR CMOS SETUP ...................................................................... 11

2.7 BATTERY BACKUP FOR CMOS SETUP .................................................... 11

2.8 BIOS FLASH CHIP WRITE VOLTAGE SETTING .......................................... 11

2.9 ON BOARD LAN SETUP .................................................................... 12

CHAPTER 3. CONNECTION......................................................... 13

3.1 FLOPPY DISK DRIVE CONNECTOR......................................................... 13

3.2 PCI E-IDE DISK DRIVE CONNECTOR ................................................... 14

3.3 PARALLEL PORT ............................................................................. 14

3.4 SERIAL PORTS .............................................................................. 15

3.5 KEYBOARD / MOUSE CONNECTOR ........................................................ 15

3.6 EXTERNAL SWITCHES AND INDICATORS.................................................. 16

3.7 EXTERNAL BATTERY CONNECTOR ......................................................... 16

3.8 LCD/CRT CONNECTOR.................................................................... 17

3.9 LAN RJ45 CONNECTOR ................................................................... 17

CHAPTER 4. AMI BIOS SETUP ...................................................19

4.1 GETTING START ............................................................................. 19

4.2 STANDARD CMOS SETUP.................................................................. 19

4.3 ADVANCED CMOS SETUP.................................................................. 19

4.4 ADVANCED CHIPSET SETUP ................................................................ 20

4.5 PERIPHERAL SETUP.......................................................................... 20

4.6 POWER MANAGEMENT SETUP .............................................................. 21

APPENDIX A. WATCH-DOG TIMER ..........................................................22

APPENDIX B. FP24-01 FLAT PANEL CONNECTION MODULE ...................23

Chapter 1. Introduction

Thank you for choosing JUKI-740E Pentium® with HiQPro™ LCD/CRT and

Ethernet Single Board Computer. The JUKI-740E board is an PCISA form factor

board, which comes equipped with high performance Pentium® CPU and

advanced high performance multi-mode I/O, designed for the system

manufacturers, integrators, or VARs that want to provide all the performance,

reliability, and quality at a reasonable price.

This board has in it a built-in DiskOnChip™ (DOC) Flash Disk for embedded

application. DOC Flash Disk is 100% compatible to hard disks. This fact allow user

to use any kind of DOS commands without having to install any extra software

utility. DOC currently is available from 2MB to 72MB.

The on board RTL8139 network chipset provides 10Mbps or 100Mbps Ethernet

with auto-sensing function..

In addition, the JUKI-740E has a built-in C&T 69000 LCD/CRT Chipset. LCD

interface can support up to 1280x1024 with 256 colors in resolution. It also

support various type of flat panels such as Mono, Color STN, TFT, EL and so on.

The board also supports either 3.3V or 5V version.

1.1 Specifications

The JUKI-740E Pentium® with HiQPro™ LCD/CRT & Ethernet Single Board

Computer provides the following specification:

 CPU : Pentium® MMX up to 233Mhz, AMD K6 processor up to 300MHz, Cyrix

6x86MX and IDE C6 processor

 PCISA Bus : ISA bus and PCI 32-bit local bus, PCI 2.1 standard

 Chipset : ALI M1531/M1543

 LCD/CRT Interface : :C&T 69000 Chipset

 CRT Resolution : 1280x1024,256 colors

1024x768, 64K colors

800x600, 16M colors

 36-bit LCD Interface Resolution :

1280x1024,256 colors

1024x768, 64K colors

800x600, 16M colors

For more information please refer to website: www.chips.com

 Ethernet : RTL 8100B Chipset

 IEEE 802.3u 100BASE-TX standard

 Auto-sensing interface to 10Mbps or 100Mbps networks

 Full duplex capability

For more information please refer to website: www.realtek.com.tw

 Real-time clock/calendar : In ALI 4+ chipset, backup by industrial Li-

battery,3V/850mAH.

 RAM memory : Support up to 128MB EDO RAM

 Second Cache memory : 512KB Pipelined Burst SRAM on board

 Ultra DMA/33 IDE Interface : Support up to four PCI Enhance IDE hard drives.

The Ultra DMA/33 IDE can handle data transfer up to 33MB/s. Best of all is that this

new technology is compatible with existing ATA-2 IDE specifications so there is no

need to change any of users’ current accessories.

 Floppy disk drive interface : Provides two 2.88 MB, 1.44MB, 1.2MB, 720KB, or

360KB floppy disk drives.

 Two high speed Series ports : NS16C550 compatible UARTs

 Bi-directional Parallel Port

 Watch-dog timer : Can be set to 1,2,10,20,110 or 220 seconds per interval. A

system reset or NMI was generated when CPU did not periodically trigger the timer.

The system program use hex 043 and 443 to control the watch-dog and generate a

system reset.

 Flash Disk - DiskOnChip™ : The Flash Disk provide 100% compatible with hard

disk. The built-in TrueFFS Transparent Flash Block Management and Space

Reclamation will allow users to use Flash Disk with DOS command, therefore, no

need to install any extra software utility.

 Keyboard connector

 Mouse : PS/2 Mouse Port on-board.

 Power Consumption :

 +5V @ 5A

 ( MMX-233,32MB EDO RAM)

 +12V @ 170mA , -12V@20mA

 Operating Temperature : 0°~ 55°C ( CPU needs Cooler)

1.2 Package Contents

In addition to this User's Manual, the JUKI-740E package includes the following

items:

 JUKI-740E Pentium® with HiQPro™ LCD/CRT & Ethernet Single Board

Computer

 RS-232/Printer Cable

 FDD/HDD Cable

 6-pin Mini-Din to 5-pin Din Keyboard and Mouse Adapter Cable

If any of these items is missing or damaged, contact the dealer from whom you

purchased the product. Save the shipping materials and carton in case you want

to ship or store the product in the future.

Chapter 2. Installation

This chapter describes how to install the JUKI-740E. First, the layout of JUKI-

740E is shown, and then the unpacking information that you should pay attention

to is described. Other information such as jumper and switch settings for the

JUKI-740E's configuration, such as CPU type selection, system clock setting, and

watch dog timer, are also included.

2.1 JUKI-740E Layout

2.2 CPU Settings of JUKI-740E

 CPU Clock Setting :

CPU Speed/Clock JP1

1-2

JP1

9-10

JP1

11-12

55MHz SHORT SHORT OPEN

60MHz SHORT OPEN OPEN

66MHz OPEN OPEN OPEN

 CPU to Bus Multiple :

Multiplier JP1

3-4

JP1

5-6

JP1

7-8

1.5 x OPEN OPEN OPEN

2x SHORT OPEN OPEN

2.5x SHORT SHORT OPEN

3 x OPEN SHORT OPEN

3.5 x OPEN OPEN OPEN

4 x SHORT OPEN SHORT

4.5x SHORT SHORT SHORT

5x OPEN SHORT SHORT

5.5x OPEN OPEN SHORT

CPU Frequency = CPU Clock x Multiplier for example

Pentium® 200MHz = 66MHz CPU Clock x 3

 CPU Core Voltage Selection :

Please check CPU Core Voltage before you install the CPU. Currently, the

new Intel MMX CPU utilizes dual voltages for core and I/O, that is, I/O is

3.3V but core is 2.8V. This kind of CPU design will enhance low power

consumption capability. As for general Pentium CPUs, it utilizes only one

voltage for both I/O and Core - 3.3V,3.4V,or 3.5V.

 JP1 CPU Core Voltage Setting :

(JP1 is in the power module)

CPU Core

Voltage

JP1

1-2

JP1

3-4

JP1

5-6

JP1

7-8

3.5V(P54C/CS)

VRE SHORT SHORT SHORT SHORT

3.4V(P54C/CS)

STD OPEN SHORT SHORT SHORT

3.3V SHORT OPEN SHORT SHORT

3.2V OPEN OPEN SHORT SHORT

3.1V SHORT SHORT OPEN SHORT

3.0V OPEN SHORT OPEN SHORT

2.9V SHORT OPEN OPEN SHORT

2.8V OPEN OPEN OPEN SHORT

2.7V SHORT SHORT SHORT OPEN

2.6V OPEN SHORT SHORT OPEN

2.5V SHORT OPEN SHORT OPEN

2.4V OPEN OPEN SHORT OPEN

2.3V SHORT SHORT OPEN OPEN

2.2V OPEN SHORT OPEN OPEN

2.1V SHORT OPEN OPEN OPEN

2.0V OPEN OPEN OPEN OPEN

 Dual / Single CPU Voltage setting :

Vcore & VIO JP34

1-2

JP34

3-4

JP35

1-2

JP35

3-4

Pentium®

(P54C)

IDT C6

SHORT SHORT OPEN OPEN

Pentium®

MMX

AMD K6

Cyrix 6x86MX

Dual Voltage

OPEN OPEN SHORT SHORT

 Cyrix 6x86MX PR Rating Table

( Vcore : 2.9V,dual voltage )

PR Rating Bus MHz CPU Core

MHz

Clock

Multiplier

6x86MX-PR133 50 100 2x

6x86MX-PR133* 55 110 2x

6x86MX-PR150 60 120 2x

6x86MX-PR150 50 125 2.5x

6x86MX-PR166 66 133 2x

6x86MX-PR166 55 138 2.5x

6x86MX-PR166 50 150 3x

6x86MX-PR166 60 150 2.5x

6x86MX-PR200 55 165 3x

6x86MX-PR200 66 166 2.5x

6x86MX-PR200 60 180 3x

6x86MX-PR233 66 200 3x

6x86MX-PR266 66 233 3.5x

 AMD K6 MMX Rating Table, dual voltage

Product Name Core

Freq Vcore Bus MHz

Multiplier

K6-233 model 6 233MHz

3.2V 66 3.5x

K6-200 model 6 200MHz

2.9V 66 3x

K6-166 model 6 166MHz

2.9V 66 2.5x

K6-300 model 7 300MHz

2.2V 66 4.5x

K6-266 model 7 266MHz

2.2V 66 4x

K6-233 model 7 233MHz

2.2V 66 3.5x

2.3 Watch-Dog Timer

The Watch-Dog Timer is enabled by reading port 443H. It should be triggered

before the time-out period ends, otherwise it will assume system operation is

abnormal and will issue a reset signal to start again, or activate NMI to CPU. The

Watch-Dog Timer is disable by reading port 843H.

 JP7 : Watch-Dog Active Type Setting

JP7 DESCRIPTION

2-3 RESET WHEN WDT TIME-OUT

1-2 ACTIVATE NMI TO CPU WHEN WDT TIME-OUT

OPEN DISABLE WDT

 JP8: WDT Time-Out Period

PERIOD 1-2 3-4 5-6 7-8

1 sec. OPEN OPEN SHORT OPEN

2 sec. OPEN OPEN SHORT SHORT

10 sec. OPEN SHORT OPEN OPEN

20 sec. OPEN SHORT OPEN SHORT

110 sec. SHORT OPEN OPEN OPEN

220 sec. SHORT OPEN OPEN SHORT

2.4 DiskOnChip™ Flash Disk

The DiskOnChip™ Flash Disk Chip(DOC) is produced by M-Systems. Since DOC is

100% compatible to hard disk and DOS, users don’t need to install any extra

software utility. Its “plug and play” function is easy and reliable. Please note that

it will share 8KB of window’s memory.

 JP36 : DiskOnChip Memory Address Setting

ADDRESS JP36

CE000 1-2

D6000 3-4

DE000 5-6

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de De oficina de IEI Technology

IEI Technology

IEI Technology PPC-5xxx-9455 Manual de usuario

IEI Technology

IEI Technology PPC-51xxA-H61 Manual de usuario

IEI Technology

IEI Technology AFOLUX AFL-315AW/B Manual de usuario

IEI Technology

IEI Technology PCIE-Q370 Manual de usuario

IEI Technology

IEI Technology DRPC-330-A7K Series Manual de usuario

IEI Technology

IEI Technology TANK-700-QM67W-MRAY Manual de usuario

IEI Technology

IEI Technology ECN-360A-HM65 Manual de usuario

IEI Technology

IEI Technology TANK-760 Manual de usuario

IEI Technology

IEI Technology TANK-820-H61 Series Manual de usuario

IEI Technology

IEI Technology AFL2-12A-HM65 Series Manual de usuario

IEI Technology

IEI Technology AFLLX Series Manual de usuario

IEI Technology

IEI Technology ECW-281B-BTi Manual de usuario

IEI Technology

IEI Technology Afolux LX Series Manual de usuario

IEI Technology

IEI Technology ECK-1000 Series Manual de usuario

IEI Technology

IEI Technology ITCS-100-H81 Manual de usuario

IEI Technology

IEI Technology ECN-581A-QM57 Manual de usuario

IEI Technology

IEI Technology TANK-610-BW Manual de usuario

IEI Technology

IEI Technology NANO-8522 Manual de usuario

IEI Technology

IEI Technology PPC-5150GS Manual de usuario

IEI Technology

IEI Technology DRPC-120-BTi Manual de usuario

IEI Technology

IEI Technology AFL-F08A-N270 Manual de usuario

IEI Technology

IEI Technology TANK-6000-C226i-E3/4G-R10 Manual de usuario

IEI Technology

IEI Technology AFOLUX CX Series Manual de usuario

IEI Technology

IEI Technology SAILORPC-12A Manual de usuario

Manuales populares de De oficina de otras marcas

HP m9060n - Pavilion - Elite Hoja de especificaciones

Asus

Asus E210 Series Manual de usuario

Dell

Dell Inspiron 600m Manual de usuario

Dell

Dell Inspiron 3662 Manual de usuario

TotalFlow

TotalFlow uFLO Manual de usuario

HP Presario SV7000 - Desktop PC Manual de usuario

HP ProDesk 400 G5 Manual

Logitech

Logitech MK320 Manual de usuario

Dell

Dell XPS 730 H2C Manual de usuario

Sony

Sony Vaio Series Manual de usuario

Sony

Sony VGC-LT32E - Vaio All-in-one Desktop Computer Manual de usuario

Alto

Alto MD 250 Manual de usuario

Lenovo

Lenovo ThinkCentre Edge 72 Manual

Lenovo

Lenovo ThinkStation D20 Manual

Arbor Technology

Arbor Technology FPC-7800 Series Manual de usuario

Sony

Sony VAIO VGX-TP1 Series Manual de usuario

Asus

Asus Eee Box B204 Manual de usuario

Dell

Dell Optiplex 9010 All In One Manual de usuario