Hussmann EcoVision II Plus Door Upgrade Suplemento

Installation &

Service Manual

P/N 0530690_B

November 2013

Spanish 0538854

French 0538855

IMPORTANT

Keep in store

for future reference!

EcoVision II Plus Door Upgrade

for Tyler N6D Multi-deck Merchandisers

BEFORE YOU BEGIN

Read these instructions completely and carefully.

PERSONAL PROTECTION EQUIPMENT (PPE)

Personal Protection Equipment (PPE) is required whenever servicing this equipment. Always

wear safety glasses, gloves, protective boots or shoes, long pants, and a long-sleeve shirt when

handling glass.

PREPARATION

Revision History .............................iv

ANSI Definitions ............................iv

Installation Tool List .........................iv

Shipping Damage ............................ 1

General .................................... 1

Unpacking EcoVision II Plus Door Kit(s) ......... 1

Removing Canopy Fascia, Racks, Pans ........... 2

Pre-assemble EcoVision II Plus Canopy Support ... 2

INSTALLATION

Installing EcoVision II Plus Canopy Support ...... 3

Installing Bottom Rail and Extrusion ............ 3

Pre-assemble Light Channel .................... 4

Installing Mullions ........................... 4

Installing Bottom Gasket Retainers .............. 6

Installing Light Channel ....................... 6

Installing Wipers ............................. 7

Installing Split Rail Hinge Plate Assembly ........ 8

Installing Doors .............................. 8

Tightening Torsion Rods ...................... 9

Secure Hold Open Cam ....................... 9

Increasing Decreasing Door Tension ............ 10

Replace Canopy Fascia ....................... 11

Checking Door Opening and Closing ........... 11

Start Up / Stocking .......................... 12

Technical Guideline for Case

and Refrigeration System Adjustments ........... 13

Table of Contents

IMPORTANT

KEEP IN STORE FOR FUTURE REFERENCE

Quality that sets industry standards!

12999 St. Charles Rock Road • Bridgeton, MO 63044-2483

U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900

www.hussmann.com

EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B

HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A. iii

P/N 0530690_B

U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com

REVISION HISTORY

REVISION A

1. Original issue

ECOVISION II PLUS Door Installation Tool

List

Level, 4 ft suggested

Ratchet

1/4in. Socket

7/16 in. Socket

3/8in. Socket

1/2in. Open End Wrench

Battery Drill/Screw Gun

Rubber Mallet

Hammer

Putty Knife

Pop Rivet Gun (for end fillers)

4ft Ladder

* * * * * * * * * * * * * * * * * * * * * * * * * *

ANSI Z535.5 DEFINITIONS

• DANGER – Indicate[s] a hazardous

situation which, if not avoided, will

result in death or serious injury.

• WARNING –Indicate[s] a hazard-

ous situation which, if not avoided,

could result in death or serious injury.

• CAUTION –Indicate[s] a hazard-

ous situation which, if not avoided,

could result in minor or moderate

injury.

• NOTICE – Not related to personal injury –

Indicates[s] situations, which if not avoided,

could result in damage to equipment.

Caution: Tipping Hazard

Case tipping may occur if cases are not

properly leveled and secured.

HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A. 1

EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B

SHIPPING DAMAGE

All equipment should be thoroughly examined

for shipping damage before and during unload-

ing.

This equipment has been carefully inspected at

our factory. Any claim for loss or damage must

be made to the carrier. The carrier will provide

any necessary inspection reports and/or claim

forms.

GENERAL

Verify the merchandiser model(s) to be outfitted

with the EcoVision II Plus door kit(s) by locat-

ing the merchandiser’s serial plate.

This instruction details the installation of

EcoVision II Plus doors N6D Tyler Multi-deck

Merchandisers.

EcoVision II Plus doors may be installed

without the need to remove product from the

merchandisers. Check with the store manager,

and let them know how long a door lineup will

take to complete. The average time to install

each door is about 20 minutes.

Water Misters and Light raiLs may not be used with

glass doors. Remove any mist equipment from case

before installing doors.

1Installing EcoVision II Plus Doors

requires at least two installers!

A. Carefully unpack EcoVision II Plus Door

upgrade kit(s), and examine parts. Do not

carry doors by the handle.

Do NOT lean glass doors against the

merchandiser lineup. Leave them packed in

their protective packaging until they are

ready to be directly installed in the lineup.

Accidental glass breakage can be dangerous.

Always wear protective glasses and gloves

when handling glass.

Do NOT stand or walk on top of

merchandiser. Do not store items or

flammable materials atop the unit.

Note

Read these instructions carefully

and completely before attempting

to install EcoVision II Plus doors.

Use caution handling glass parts. Always

wear safety glasses, long pants, gloves and

arm guards when handling glass doors.

Do not lean doors against case.

Doors should remain in packing crate

until it is time to install on to case.

P/N 0530690_B

U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com

LOCATION

EcoVision II Plus doors are designed for merchan-

disers that display products in air conditioned stores

where temperature is maintained at or below

75°F (24°C) and relative humidity is maintained

below 55%. Fogging and/or moisture may occur

on the doors if merchandisers are operated out-

side these conditions.

Placing refrigerated merchandisers in direct

sunlight, near hot tables or near other heat

sources could impair their efficiency, which

may cause the doors to fog. Refrigerated

merchandisers are sensitive to air disturbances.

Air currents passing around merchandisers

will seriously impair their operation. Do NOT

allow air conditioning, electric fans, open doors

or windows, etc. to create air currents around

the merchandisers. Product should always be

maintained at proper temperature. This means

that from the time the product is received,

through storage, preparation and display, the tem-

perature of the product must be controlled to

maximize the life of the product.

CASE LEVELING

Merchandisers must be installed level to ensure

proper operation of the refrigeration system,

and to ensure proper drainage of defrost water.

Glass alignment is also affected with improp-

er leveling of the merchandisers. All steps of

settting, joining and case leveling attention to

the glass position is critical. Do not attempt to

make glass adjustments prior to case leveling.

2Remove Canopy Fascia, Racks and

Display Pans

A. Remove canopy fascia. Canopy fascia will

be replaced later.

B. Loosen any screws or rods between canopy

fascias of joined cases.

3Remove existing Top Rail. New

EcoVision II Plus top rail will be installed

later.

A. Loosen any screws or rods between canopy

fascias of joined cases.

B. Remove canopy screws at top of case. Set

canopy safely on top of case. Canopy we be

reinstalled later.

Figure 2-1 — Canopy Fascia Removed

HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.

EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B

Screw

(¼ × ¾ in.

Thread Cutting)

Thread Cutting

Self-Tapping

(¼- in.)

#10

Hex Washer

Head

Hex

Head Screw

(black/gray)

#8-32

Shoulder Screw

TORX Head

#8-32 x ½

Hex Head

Type F

Wiper - Door

Vertical

Mullion

Bottom Plastic

Streamline Shown

Black/Gray

contour available

(pre-assembled

part)

Vertical Glass

Door Wiper

Mullion

End - black/gray

2-per-case

3 per 6 ft case

Mullion

Center - black/gray

1- 8ft case

2-12 ft case

Hinge

Plate Asm

Bottom

(Right Side

Swing)

black/gray

Plate - LH

Door Hold Open Cam

Plate - RH

Door Hold Open Cam

Wiper Horizontal

22½- in. (6 ft)

to door retainer

45 in. - 4, 6, 8, 12 ft Door Retainer

Plastic - 44 in. 4, 6, 8, 12 ft

22½ in. (6 ft)

Door Handle

black/gray

Rail - Bottom

Alignment Plate

(for joining cases)

Door asembly

(right door)

includes rod

assembly

Door Asm

(left door)

includes rod

assembly

2-4ft

4-6, 8ft

6-12ft

Canopy

Gusset

Canopy

Support

gray/black

left/right

Adjustment Casting

and Adjustment Bolt

EcoVision Door — Parts Identification

P/N 0530690_B

U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com

4Pre-assemble the EcoVision Canopy

Support

A. Fasten canopy support bracket to canopy

support.

B. Fasten left and right gussets to canopy support.

Figure 4-1 — Canopy Support Bracket

Figure 4-3 — Right Gusset

Figure 4-2 — Left Gusset

HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.

EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B

5Installing EcoVision II Plus Canopy

Support

A. Center the canopy support inside the channel

at the top of the case. Fasten the first screw at

the center of the canopy support. The canopy

support may need to be adjusted later (after the

mullions are installed). Do not tighten canopy

support at this time.

6Installing Bottom Rail Support and

Bottom Rail Extrusion

A. Rail supports are installed in 4ft lengths.

Place rail supports on top of existing rail.

Figure 5-1 Installing Canopy Support

Fasten

at Center

Canopy

Canopy Support has sharp metal edges.

Wear safety glasses, long sleeve shirt, long

pants, arm guards and gloves. Use caution

when working at eye level or over head.

Figure 6-1 Bottom Rail Support

Figure 6-2 Bottom Rail Extrusion

P/N 0530690_B

U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com

7Pre-assemble Light Channel - (Power

Supply and LEDs)

A. Attach power supplies to the EcoVision II

Plus light channel.

B. Attach LEDs to the light channel.

8Installing Mullions

A. Attach the end mullions first.

LED Power

Supply

Figure 7-1 Attach Power Supplies

Figure 7-2 Attach LEDs

to Light Channel

Figure 8-1 End

Mullion Lip

Figure 8-2

End Mullion

Lip

Inside

Case

NOTE: End mullions may be used on the left,

or the right side of merchandiser.

Tabla de contenidos

Otros manuales de Comerciante de Hussmann

Hussmann

Hussmann JVMRS Manual de usuario

Hussmann

Hussmann SMG Manual de usuario

Hussmann

Hussmann Impact Excel M1X-E Manual de instrucciones

Hussmann

Hussmann Impact C2-E Manual de instrucciones

Hussmann

Hussmann SHM Series Manual de usuario

Hussmann

Hussmann FML Manual de usuario

Hussmann

Hussmann RCA Manual de usuario

Hussmann

Hussmann P4EP Manual de usuario

Hussmann

Hussmann impact Excel C5X-LE Manual de instrucciones

Hussmann

Hussmann NEBCH Manual de usuario

Hussmann

Hussmann FWEG Manual de instrucciones

Hussmann

Hussmann Impact C1CWCEI Manual de instrucciones

Hussmann

Hussmann PHRO Manual de usuario

Hussmann

Hussmann M1X-XGEC Manual de instrucciones

Hussmann

Hussmann IMPACT CW2-GE Manual de usuario

Hussmann

Hussmann Impact C2-LEP Manual de instrucciones

Hussmann

Hussmann Impact Excel M5EP Manual de usuario

Hussmann

Hussmann Excel Series Manual de usuario

Hussmann

Hussmann SHVS Instrucciones de funcionamiento

Hussmann

Hussmann C2XEC-XE Manual de instrucciones

Hussmann

Hussmann Impact Excel B3XC-LEP Manual de instrucciones

Hussmann

Hussmann FHM Manual de usuario

Hussmann

Hussmann Impact C2EC-XLGE Manual de instrucciones

Hussmann

Hussmann RMID Instrucciones de funcionamiento

Manuales populares de Comerciante de otras marcas

FRIGOGLASS

FRIGOGLASS Flex 20 HC Manual de usuario

EPTA

EPTA COSTAN RHINO MULTI Manual de usuario

CASCO

CASCO Nano Cube Manual de usuario

True

True GDIM-26 Manual de usuario

Structural Concepts

Structural Concepts Oasis Mobile Series Instrucciones de instalación

Haussmann

Haussmann RL Manual de usuario

Howard McCray

Howard McCray R-CDS32E-4 Manual de usuario

EPTA

EPTA iarp Cool Emotions Delight Lite Manual de usuario

VALERA

VALERA BC 85 Manual de usuario

HL Display

HL Display 3eBin Manual de usuario

Dixie Narco

Dixie Narco DNCB 501E Manual de usuario

APW Wyott

APW Wyott Racer DMXD-30H Manual de usuario

Hoshizaki

Hoshizaki KD-90C Manual de usuario

Summit

Summit SCR1006 Manual de usuario

Delfield

Delfield Shelleyspeed SPM-28E Manual de usuario

EPTA

EPTA iarp Cool Emotions GLEE 40 Manual de usuario

Kysor/Warren

Kysor/Warren GranBering KW Guía

Crane

Crane BevMAX Refresh 6 Media Manual de usuario