Hoshizaki DB-200H Manual de usuario

Hoshizaki

“A Superior Degree

of Reliability”

www.hoshizaki.com

Models

DB-200H

Cubelet Icemaker / Dispenser

Hoshizaki America, Inc.

Issued: 6-5-2001

INSTRUCTION MANUAL

IMPORTANTIMPORTANT

IMPORTANT

Only qualified service technicians should attempt to install, service or maintain this

ice dispenser. No installation, service or maintenance should be undertaken until the

technician has thoroughly read this Instruction Manual. Likewise, the owner/

manager should not proceed to operate the ice dispenser until the installer has

instructed them on its proper operation.

HOSHIZAKI provides this manual primarily to assist qualified service technicians in the

installation, maintenance and service of the ice dispenser.

Should the reader have any questions or concerns which have not been satisfactorily

addressed, please call or write to the HOSHIZAKI Technical Support Department for

assistance.

HOSHIZAKI AMERICA, INC.

618Highway74South

PeachtreeCity,GA 30269

Attn: HOSHIZAKITechnicalSupportDepartment

Phone: 1-800-233-1940TechnicalService

(770)487-2331

Fax: (770)487-3360

NOTE: Toexpediteassistance,allcorrespondence/communicationMUST includethefollowing

information:

• ModelNumber

• SerialNumber

• Completeanddetailedexplanationoftheproblem

• Pleasereview thismanual. Itshouldbe readcarefullybeforetheicedispenseris

installedandoperated.Onlyqualifiedservicetechniciansshouldinstall,serviceand

maintaintheicedispenser. Thismanualshouldbemadeavailabletothetechnician

priortoinstallation,maintenanceorservice.

• Keepthismanualwiththedispenserforlaterreference.

CONTENTSCONTENTS

CONTENTS

PAGE

I. SPECIFICATIONS .................................................................................................... 4

1. NAMEPLATE RATING ........................................................................................... 4

2. DIMENSIONS/CONNECTIONS.............................................................................. 5

II. INSTALLATION AND OPERATING INSTRUCTIONS............................................. 8

1. CHECKS BEFORE INSTALLATION ...................................................................... 8

2. LOCATION.............................................................................................................. 9

3. SET UP ................................................................................................................. 10

4. ELECTRICAL CONNECTION .............................................................................. 12

5. DRAIN CONNECTIONS ....................................................................................... 13

6. FINAL CHECK LIST.............................................................................................. 13

7. START UP ............................................................................................................ 15

8. PREPARING THE ICE DISPENSING BIN FOR LONG STORAGE ..................... 15

III. CLEANING AND MAINTENANCE INSTRUCTIONS............................................ 16

1. CLEANING INSTRUCTIONS ............................................................................... 16

[a] CLEANING PROCEDURE .............................................................................. 16

[b] SANITIZING PROCEDURE............................................................................. 18

2. MAINTENANCE.................................................................................................... 18

We reserve the right to make changes in specifications and design without prior notice.

See NAMEPLATE for electrical specifications. The nameplate

is located on the upper part of the Right Side Panel.

I. SPECIFICATIONSI. SPECIFICATIONS

I. SPECIFICATIONS

1. NAMEPLATE RATING1. NAMEPLATE RATING

1. NAMEPLATE RATING

2. DIMENSIONS/CONNECTIONS2. DIMENSIONS/CONNECTIONS

2. DIMENSIONS/CONNECTIONS

[a] with KM-280M_ or KM-500M_[a] with KM-280M_ or KM-500M_

[a] with KM-280M_ or KM-500M_

[b] with KM-630M[b] with KM-630M

[b] with KM-630M

[c] with KML-250M_, KML-350M_, KML-450M_, or KML-600M_H[c] with KML-250M_, KML-350M_, KML-450M_, or KML-600M_H

[c] with KML-250M_, KML-350M_, KML-450M_, or KML-600M_H

II. INSTALLATION AND OPERATING INSTRUCTIONSII. INSTALLATION AND OPERATING INSTRUCTIONS

II. INSTALLATION AND OPERATING INSTRUCTIONS

1. CHECKS BEFORE INSTALLATION1. CHECKS BEFORE INSTALLATION

1. CHECKS BEFORE INSTALLATION

IMPORTANTIMPORTANT

IMPORTANT

1. Thisicedispensingbinisdesignedandintendedtobeusedincombination

with a HOSHIZAKI Modular Crescent Ice Cuber, Models KM-280M,

KM-500M, KM-630M, KML-250M, KML-350M, KML-450M, or KML-600M.

The use of this ice dispensing bin in combination with any cuber or flaker,

other than a HOSHIZAKI Crescent Ice Cuber cannot be recommended.

2. Removeshippingcarton,tape(s)andpackingtopreventdamagetotheice

dispensing bin.

3.Ensure allcomponents,fastenersandthumbscrewsaresecurelyinplace.

1) Remove the Front panel to prevent damage before installing.

2) Remove the package containing the accessories from the storage bin.

3) Remove the protective plastic film from the Side Panels. If the ice dispensing bin has

been exposed to the sunlight or to direct heat, it should be allowed to cool before

removing the protective film.

4) See NAMEPLATE, located on the upper part of the Left Side Panel. Check that the

voltage supplied corresponds with the voltage specified on the NAMEPLATE.

WARNINGWARNING

WARNING

This ice dispensing bin is not intended for outdoor use. Normal operating

ambient temperature should be within +45°F to +100°F. To the icemaker,

water temperature should be within +45°F to +90°F.

Extended periods of operation at temperatures outside of these limitations

may cause unsatisfactory results.

For best operating results:

•Icedispensingbinshouldnotbe located next to ovens, grills orotherhighheatproducing

equipment.

• Location should provide a firm and level foundation for the equipment.

• Always avoid a site where dripping is not allowed.

• Allow 6" clearance at rear and sides for ease of maintenance and/or service should they

be required. More space is needed especially on the right side of the dispensing bin to

service the drive system.

CAUTIONCAUTION

CAUTION

The icemaker will not work in sub-freezing temperatures. To prevent

damage to the water supply line, always drain the icemaker when air

temperature is 32°F or below.

2. LOCATION2. LOCATION

2. LOCATION

3. SET UP - See Fig. 1.3. SET UP - See Fig. 1.

3. SET UP - See Fig. 1.

CAUTIONCAUTION

CAUTION

It is especially important that the icemaker/ice dispensing bin is leveled

in both left-to-right and front-to-rear directions. If it is not level, the

result could be the production of smaller or irregular shaped cubes or

of overflow into the ice dispensing bin. See the “LOCATION”

instructions on the icemaker.

1)Unpacktheicedispensingbin,andremoveallshippingcartons,tape(s)andpackingbefore

operatingtheunit. Attachfour(4)adjustablelegs[adjustablewithinmax.6-13/32"(188mm.)

to min. 6" (152 mm.)] to the bottom of the ice dispensing bin. Remove the front panel to

prevent damage, and be careful not to damage the other panels when installing the ice

dispensing bin.

Remove the screws, and pull up and toward you to remove the Front Panel.

2)Positiontheicedispensingbininaselectedpermanentsite. Cleanandwipetheinteriorwith

a clean cloth.

3) Unpack the icemaker, and remove all shipping cartons, tape(s) and packaging.

4) See the “SET UP” instructions on the icemaker when installing the icemaker.

5) Attach the icemaker to the top of the ice dispensing bin, and secure the icemaker by using

twoUniversalBracesandfour(4)HexagonHeadbolts(KMaccessory). ThenattachtheTop

Panels onto the ice dispensing bin by using four (4) Bolts and Brackets.

6) Level the icemaker/ice dispensing bin in both the left-to-right and front-to-rear directions.

7) Place exterior panels in position on both the icemaker and the ice dispensing bin. See the

“SET UP” instructions on the icemaker.

Otros manuales para DB-200H

Tabla de contenidos

Otros manuales de Máquina de hielo de Hoshizaki

Hoshizaki

Hoshizaki KMD-460MAJ Manual de usuario

Hoshizaki

Hoshizaki IM-21CNE-HC Manual de usuario

Hoshizaki

Hoshizaki F-450MAJ-C Manual de usuario

Hoshizaki

Hoshizaki DKM-500BAH Manual de usuario

Hoshizaki

Hoshizaki FM-170EE-HC Manual de usuario

Hoshizaki

Hoshizaki KM-201BAH Manual de usuario

Hoshizaki

Hoshizaki KM-1600MRB3 Manual de usuario

Hoshizaki

Hoshizaki DIM-30DE-1 Manual de usuario

Hoshizaki

Hoshizaki MODULAR CUBELET SERENITY SERIES FS-1022MLH-C Manual de usuario

Hoshizaki

Hoshizaki FM-1000ALE Manual de usuario

Hoshizaki

Hoshizaki KM-630MAE Manual de usuario

Hoshizaki

Hoshizaki KMD-901MAH Manual de usuario

Hoshizaki

Hoshizaki KM-250BWF Manual de usuario

Hoshizaki

Hoshizaki FM-300AKE-HC Manual de usuario

Hoshizaki

Hoshizaki F-1001MAF Manual de usuario

Hoshizaki

Hoshizaki KMD-210AB-HC Manual de usuario

Hoshizaki

Hoshizaki AM-50BAE-AD Manual de usuario

Hoshizaki

Hoshizaki KM-150BWF Manual de usuario

Hoshizaki

Hoshizaki DB-200H Manual de usuario

Hoshizaki

Hoshizaki FM-750AKE Manual de usuario

Hoshizaki

Hoshizaki DCM-60KE Manual de usuario

Hoshizaki

Hoshizaki KM-1200MAE Manual de usuario

Hoshizaki

Hoshizaki F-250BAA Manual de usuario

Hoshizaki

Hoshizaki F-300BAF Manual de usuario

Manuales populares de Máquina de hielo de otras marcas

Sub-Zero

Sub-Zero 315I Instrucciones de uso

Unold

Unold 48945 Manual de usuario

Kenmore

Kenmore 2217402A Manual de usuario

Cornelius

Cornelius WM600 Instrucciones de funcionamiento

GE XPIO43SCSS Manual de usuario

Whynter

Whynter FIM-450HA Manual de usuario

U-Line

U-Line UMCR014-SC01A Manual de instalación

Andrew James

Andrew James AJ000522 Manual de usuario

Scotsman

Scotsman CME1356 Manual de usuario

Scotsman

Scotsman ACM 25 Manual de usuario

Kärcher

Kärcher IP 120 Manual de usuario

U-Line

U-Line SS1095 Manual de usuario

Maytag

Maytag MIM1554WRS - Ice Maker Manual de usuario

Princess

Princess Yonanas Manual de usuario

Unold

Unold 48946 Manual de usuario

Electrolux

Electrolux E15IM60GP Manual de usuario

Cornelius

Cornelius UC150 ICE ONLY Manual de usuario

Bunn

Bunn BUNN-O-MATIC ULTRA-1 Manual del propietario