Hitachi RAM-71QH5 Manual de usuario

NO. 0459E

SPECIFICATIONS AND PARTS ARE SUBJECT TO CHANGE FOR IMPROVEMENT

ROOM AIR CONDITIONER

INDOOR UNIT + OUTDOOR UNIT

SEPTEMBER 2009

Refrigeration & Air-Conditioning Division

SERVICE MANUAL

REFER TO THE FOUNDATION MANUAL

TECHNICAL INFORMATION

FOR SERVICE PERSONNEL ONLY

CONTENTS

SPECIFICATIONS ------------------------------------------------------------------- 5

FEATURES -------------------------------------------------------------------------- 17

HOW TO USE ---------------------------------------------------------------------- 21

INSTALLATION --------------------------------------------------------------------- 45

CONSTRUCTION AND DIMENSIONAL DIAGRAM --------------------- 49

MAIN PARTS COMPONENT --------------------------------------------------- 55

WIRING DIAGRAM ---------------------------------------------------------------- 61

CIRCUIT DIAGRAM --------------------------------------------------------------- 67

BLOCK DIAGRAM ----------------------------------------------------------------- 81

BASIC MODE ----------------------------------------------------------------------- 85

REFRIGERATING CYCLE DIAGRAM -------------------------------------- 109

DESCRIPTION OF MAIN CIRCUIT OPERATION ---------------------- 113

TROUBLE SHOOTING ---------------------------------------------------------- 136

SERVICE CALL Q & A --------------------------------------------------------- 185

DISASSEMBLY AND REASSEMBLY --------------------------------------- 201

PARTS LIST AND DIAGRAM ------------------------------------------------- 210

After installation

(W)

(A)

COOLING CAPACITY

DC INVERTER DUAL SYSTEM MULTI

TYPE

MODEL

POWER SOURCE

TOTAL INPUT

TOTAL AMPERES

SPECIFICATIONS

RAM-71QH5

HEATING CAPACITY

DIMENSIONS (mm)

NET WEIGHT

1ø, 220 - 240V, 50Hz

(kg)

(kW)

(B.T.U.)

REFER TO THE SPECIFICATIONS PAGE

OUTDOOR UNIT

RAM-71QH5

850

800

298

All manuals and user guides at all-guides.com

all-guides.com

SAFETY DURING REPAIR WORK

1. In order to disassemble and repair

the unit in question, be sure to

disconnect the power cord plug

from the power outlet before starting

the work.

2. If it is necessary to replace any parts, they should be replaced with respective genuine parts for the unit, and

the replacement must be effected in correct manner according to the instructions in the Service Manual of

the unit.

If the contacts of electrical parts

are defective, replace the

electrical parts without trying to

repair them.

3. After completion of repairs, the initial state

should be restored.

4. Lead wires should be connected and laid as

in the initial state.

5. Modification of the unit by user himself should

absolutely be prohibited.

6. Tools and measuring instruments for use in repairs or inspection should be accurately calibrated in advance.

7. In installing the unit having been repaired, be careful to prevent the occurence of any accident such as

electrical shock, leak of current, or bodily injury due to the drop of any part.

8. To check the insulation of the unit, measure the insulation resistance between the power cord plug and

grounding terminal of the unit. The insulation resistance should be 1M or more as measured by a 500V

DC megger.

9. The initial location of installation such as window, floor or the other should be checked for being and safe

enough to support the repaired unit again.

If it is found not so strong and safe, the unit should be installed at the initial location reinforced or at a new

location.

10. Any inflammable thing should never

be placed about the location of

installation.

11. Check the grounding to see whether

it is proper or not, and if it is found

improper, connect the grounding

terminal to the earth.

DANGER

First, I must disconnect

the power cord plug

from the power outlet.

– 1 –

All manuals and user guides at all-guides.com

– 2 –

WORKING STANDARDS FOR PREVENTING BREAKAGE OF SEMICONDUCTORS

1. Scope

The standards provide for items to be generally observed in carrying and handling semiconductors in relative

manufacturers during maintenance and handling thereof. (They apply the same to handling of abnormal goods

such as rejected goods being returned).

2. Object parts

(1) Micro computer

(2) Integrated circuits (IC)

(3) Field-effect transistors (FET)

(4) P.C. boards or the like on which the parts mentioned in (1) and (2) of this paragraph are equipped.

3. Items to be observed in handling

(1) Use a conductive container for carrying and storing of parts. (Even rejected goods should be handled in

the same way).

Fig. 1. Conductive Container

(2) When any part is handled uncovered (in counting, packing and the like), the handling person must always

use himself as a body earth. (Make yourself a body earth by passing one M ohm earth resistance through

a ring or bracelet).

(3) Be careful not to touch the parts with your clothing when you hold a part even if a body earth is being

taken.

(4) Be sure to place a part on a metal plate with grounding.

(5) Be careful not to fail to turn off power when you repair the printed circuit board. At the same time, try

to repair the printed circuit board on a grounded metal plate.

Fig. 2. Body Earth

Body earth

(Elimik conductive band)

Clip for connection with a

grounding wire

A conductive polyvinyl bag IC

Conductive sponge

All manuals and user guides at all-guides.com

– 3 –

(6) Use a three wire type soldering iron including a grounding wire.

Bare copper wire (for body earth)

Working

table

Resistor of 1 M (1/2W)

Earth wire

Fig. 3. Grounding of the working table

Screw stop at the screwed

part using a rag plate

Soldering iron

Grounding

wire

Fig. 4. Grounding a soldering iron

Use a high insulation mode (100V, 10M or higher) when ordinary iron is to be used.

(7) In checking circuits for maintenance, inspection or some others, be careful not to have the test probes of the

measuring instrument shortcircuit a load circuit or the like.

Metal plate (of aluminium, stainless steel, etc.)

Staple

All manuals and user guides at all-guides.com

– 4 –

1. In quiet operation or stopping the operation, slight flowing noise of refrigerant in the refrigerating cycle is

heard occasionally, but this noise is not abnormal for the operation.

2. When it thunders near by, it is recommend to stop the operation and to disconnect the power cord plug

from the power outlet for safety.

3. The room air conditioner does not start automatically after recovery of the electric power failure for

preventing fuse blowing. Re-press START/STOP button after 3 minutes from when unit stopped.

4. If the room air conditioner is stopped by setting the temperature, or missoperation, and re-start in a moment,

there is occasion that the cooling and heating operation does not start for 3 minutes, it is not abnormal

and this is the result of the operation of IC delay circuit. This IC delay circuit ensures that there is no

danger of blowing fuse or damaging parts even if operation is restarted accidentally.

5. This room air conditioner should not be used at the cooling operation when the outside temperature is

below –10°C (14°F).

6. This room air conditioner (the reverse cycle) should not be used when the outside temperature is below

–15°C (5°F).

If the reverse cycle is used under this condition, the outside heat exchanger will be frosted and its

efficiency falls.

7. When the outside heat exchanger is frosted, the frost is melted by operating the hot gas system, it is not

trouble that at this time fan stops and the vapour may rise from the outside heat exchanger.

CAUTION

All manuals and user guides at all-guides.com

– 5 –

SPECIFICATIONS

MODEL

FAN MOTOR

FAN MOTOR CAPACITOR

FAN MOTOR PROTECTOR

COMPRESSOR

COMPRESSOR MOTOR CAPACITOR

OVERLOAD PROTECTOR

OVERHEAT PROTECTOR

FUSE (for MICROPROCESSOR)

POWER RELAY

POWER SWITCH

TEMPORARY SWITCH

SERVICE SWITCH

TRANSFORMER

VARISTOR

NOISE SUPPRESSOR

THERMOSTAT

REMOTE CONTROL SWITCH (LIQUID CRYSTAL)

80 W

YES

5.0A

G4A

YES

450NR

YES

YES(IC)

2300g

WITHOUT REFRIGERANT BECAUSE

COUPLING IS FLARE TYPE.

UNIT

PIPES

REFRIGERANT CHARGING

VOLUME

(Refrigerant 410A)

RAM-71QH5

JU1015D2

MAX. 60m

In case the pipe length is more than 30m, add refrigerant R410 at 20gram per every meter exceeds.

All manuals and user guides at all-guides.com

all-guides.com

– 6 –

SPECIFICATIONS FOR INDOOR UNITS COMBINATION

OPERATION SCOPE

TYPE

DC INVERTER QUADRUPLE SYSTEM MULTI COOLING AND HEATING

MODEL OUTDOOR UNIT

PHESE/VOLTAGE/FREQUENCY

CIRCUIT AMPERES TO CONNECT (A)

COOLING

(FOUR UNITS)

CAPACITY (kW)

(B.T.U./h)

TOTAL INPUT (W)

EER (B.T.U./hW)

TOTAL AMPERES (A)

POWER FACTOR (%)

HEATING

(FOUR UNITS)

CAPACITY (kW)

(B.T.U./h)

TOTAL INPUT (W)

EER (B.T.U./hW)

TOTAL AMPERES (A)

POWER FACTOR (%)

MAXIMUM LENGTH OF PIPING

STANDARD

RAM-71QH5

1ø, 220 - 240V, 50Hz

7.10 (2.40 - 8.80)

24,240 (8,190 - 30,030)

2,140 (460 - 3,200)

11.33

9.8 - 9.0

8.50 (2.80 - 9.50)

29,000 (9,560 - 32,420)

2,110 (480 - 3,120)

13.74

9.70 - 8.90

MAX. 60m (FOUR UNIT TOTAL)

CE (EMC&LVD)

RAM-71QH5

MODEL

PACKING

(mm)

cu.ft.

1,008

848

394

11.89

GROSS WEIGHT (kg)

6.35DX4/9.52DX3/12.70X1

FLARENUTSIZE (SMALL/LARGE)

INDOOR SUCTION

TEMPERATURE (˚C)

COOLING OPERATION SCOPE

OUTDOOR SUCTION

TEMPERATURE (˚C)

INDOOR SUCTION

HUMIDITY (%)

DEHUMIDIFYING

OPERATION

HEATING OPERATION

SCOPE

16 - 32 22 - 41 BELOW 80

16 - 32 22 - 42 BELOW 80

BELOW 27 –15 - 23 —

All manuals and user guides at all-guides.com

– 7 –

4 ROOM MULTI-SPLIT INVERTER TYPE RAC: RAM-71QH5

POSSIBLE COMBINATION TO OPERATE (SAME TIME OPERATION)

All manuals and user guides at all-guides.com

– 8 –

All manuals and user guides at all-guides.com

– 9 –

QUADRUPLE SYSTEM MULTI R.A.C.

RAM-71QH5

INDOOR UNITS COMBINATIONS TO BE ABLE TO INSTALL

Two, three or four indoor units can be installed with one outdoor unit.

And total nominal cooling capacity should not be more than 11.0kW

Be sure to connect two or three indoor units to this outdoor unit. If not, condensed water may drop, resulting in

trouble.

All manuals and user guides at all-guides.com

Otros manuales para RAM-71QH5

Tabla de contenidos

Otros manuales de Acondicionador de aire de Hitachi

Hitachi

Hitachi RAS-50YH4 Manual de usuario

Hitachi

Hitachi RAS-E10CZ Manual de usuario

Hitachi

Hitachi RAK-SJ24HNV Manual de usuario

Hitachi

Hitachi R32/R410A Series Manual de usuario

Hitachi

Hitachi airHome100 RAK-BH10PCAST Manual de usuario

Hitachi

Hitachi RAS-R10C-1 Manual de usuario

Hitachi

Hitachi RAC-35FXA Manual de usuario

Hitachi

Hitachi RAS-S18CXK Manual de usuario

Hitachi

Hitachi RAK-25QXA Manual de usuario

Hitachi

Hitachi RAK-25QH8W Manual de usuario

Hitachi

Hitachi RAC-L24GHZ Manual de usuario

Hitachi

Hitachi RASC-HNPE CENTRIFUGAL VRF Series Manual de usuario

Hitachi

Hitachi YUTAKI M RASM-3VNE Manual de usuario

Hitachi

Hitachi RCI-1.0FSKDN1Q Manual de usuario

Hitachi

Hitachi RAS-18LH1 Manual de usuario

Hitachi

Hitachi RAC-P25YHAB Manual de usuario

Hitachi

Hitachi airHome 400 Manual de usuario

Hitachi

Hitachi RAK-70NHA1 Manual de usuario

Hitachi

Hitachi RAK-35NH6 Manual de usuario

Hitachi

Hitachi RAS-E10CBT Manual de usuario

Hitachi

Hitachi RAS-S10C Manual de usuario

Hitachi

Hitachi RAS-VX13CET Manual de usuario

Hitachi

Hitachi RAD-70PPD Manual de usuario

Hitachi

Hitachi airHome 500 GH Series Manual de usuario

Manuales populares de Acondicionador de aire de otras marcas

Spheros

Spheros CC 355 Manual de usuario

Bosch

Bosch Climate 5000 SCI 24 CAS/ OU- OUE Manual de usuario

Panasonic

Panasonic CS-E12HKEW Manual de usuario

nedis

nedis ACMB1WT7 Manual de usuario

Samsung

Samsung AR KV Series Guía

Daikin

Daikin FCFV50A Manual de usuario

Fujitsu

Fujitsu Inverter ASBA30JFC Manual de usuario

Toshiba

Toshiba RAS-M10SMUV-E Manual de usuario

Daikin

Daikin FXLQ20MAVE Manual de usuario

CIAT

CIAT Magister 2 Series Guía

Bestron

Bestron AAC6000 Manual de usuario

Hisense

Hisense 7K Manual técnico

Frigidaire

Frigidaire FFRE0533S1E0 Manual de usuario

Samsung

Samsung AS09HM3N Manual de usuario

Frigidaire

Frigidaire CRA073PU11 Manual del propietario

Soleus Air

Soleus Air GB-PAC-08E4 Manual de usuario

McQuay

McQuay MCK020A Manual de usuario

Webasto

Webasto Frigo Top 25 DS Manual de usuario