Hitachi RAC-35WPC Manual de usuario

SPECIFICATIONS AND PARTS ARE SUBJECT TO CHANGE FOR IMPROVEMENT

ROOM AIR CONDITIONER

OUTDOOR UNIT

SERVICE MANUAL

REFER TO THE FOUNDATION MANUAL

TECHNICAL INFORMATION

FOR SERVICE PERSONNEL ONLY

SPECIFICATIONS

CONTENTS

SPECIFICATIONS ------------------------------------------------------------------- 6

CONSTRUCTION AND DIMENSIONAL DIAGRAM ---------------------- 9

MAIN PARTS COMPONENT --------------------------------------------------- 11

WIRING DIAGRAM ---------------------------------------------------------------- 13

After installation

BLOCK DIAGRAM ----------------------------------------------------------------- 16

REFRIGERATING CYCLE DIAGRAM --------------------------------------- 17

DESCRIPTION OF MAIN CIRCUIT OPERATION ----------------------- 20

SERVICE CALL Q & A ---------------------------------------------------------- 37

TROUBLE SHOOTING ------------------------------------------------------------41

HHAW

RAC-35WPC

RAC-50WPC

OUTDOOR UNIT

OUTDOOR UNIT OUTDOOR UNIT

RAC-35W RAC-50W

(KW)

(B.T.U./h)

(KW)

(B.T.U./h)

W750(+65) 792(+85)

H548 600

D288(+27.5) 299(+47)

MODEL

POWER SOURCE

TOTAL INPUT (W

TOTAL AMPERES (A)

CAPACITY

COOLING

HEATING

TOTAL INPUT (W

TOTAL AMPERES (A)

CAPACITY

1,090 (250 1,460)

DIMENSIONS

(mm)

1,560 (500 2,100)

NET WEIGHT (Kg)

TYPE DC INVERTER

1 PHASE,50Hz ,220-230V

4.87-4.66

1,100 (250 1,700)

5.51-5.27

14,330 (3,070 17,060)

7.30-6.98

3.50 (0.90 4.00) 5.00 (1.90 5.20)

11,940 (3,070 13,650) 17,060 (6,480 17,740)

20,470 (7,510 24,910)

7.93-7.59

1,660 (500 2,750)

4.20 (0.90 5.00) 6.00 (2.20 7.30)

Hitachi Household Appliances(Wuhu) Co., Ltd.

PC PC

RAC-50WPC

RAC-35WPC

1 PHASE,50Hz ,220-230V

NO.0097E

PROCEDURE FOR DISASSEMBLY AND REASSEMBLY-------------19

PARTS LIST AND DIAGRAM --------------------------------------------------56

 ,QRUGHUWRGLVDVVHPEOHDQGUHSDLUWKH

XQLWLQTXHVWLRQEHVXUHWRGLVFRQQHFWWKH

SRZHUFRUGSOXJIURPWKHSRZHURXWOHW

EHIRUHVWDUWLQJWKHZRUN

 ,ILWLVQHFHVVDU\WRUHSODFHDQ\SDUWVWKH\VKRXOGEHUHSODFHGZLWKUHVSHFWLYHJHQXLQHSDUWVIRUWKHXQLW

DQGWKHUHSODFHPHQWPXVWEHHIIHFWHGLQFRUUHFWPDQQHUDFFRUGLQJWRWKHLQVWUXFWLRQVLQWKH6HUYLFH

DQXDORIWKHXQLW

 $IWHUFRPSOHWLRQRIUHSDLUVWKHLQLWLDOVWDWHVKRXOGEH

UHVWRUHG

 /HDGZLUHVVKRXOGEHFRQQHFWHGDQGODLGDVLQWKH

LQLWLDOVWDWH

 RGLILFDWLRQRIWKHXQLWE\WKHXVHUKLPVHOIVKRXOG

DEVROXWHO\EHSURKLELWHG

 7RROVDQGPHDVXULQJLQVWUXPHQWVIRUXVHLQUHSDLUVRULQVSHFWLRQVKRXOGEHDFFXUDWHO\FDOLEUDWHGLQ

DGYDQFH

 ,QLQVWDOOLQJWKHXQLWKDYLQJEHHQUHSDLUHGEHFDUHIXOWRSUHYHQWWKHRFFXUUHQFHRIDQ\DFFLGHQWVXFKDV

HOHFWULFDOVKRFNOHDNRIFXUUHQWRUERGLO\LQMXU\GXHWRWKHGURSRIDQ\SDUW

 7RFKHFNWKHLQVXODWLRQRIWKHXQLWPHDVXUHWKHLQVXODWLRQUHVLVWDQFHEHWZHHQWKHSRZHUFRUGSOXJDQG

JURXQGLQJWHUPLQDORIWKHXQLW

7KHLQVXODWLRQUHVLVWDQFHVKRXOGEH 1RUPRUHDVPHDVXUHGE\D9'&PHJJHU

 7KHLQLWLDOORFDWLRQRILQVWDOODWLRQVXFKDVZLQGRZIORRURUWKHRWKHUVKRXOGEHFKHFNHGIRUEHLQJVDIH

HQRXJKWRVXSSRUWWKHUHSDLUHGXQLWDJDLQ

,ILWLVIRXQGQRWVRVWURQJDQGVDIHWKHXQLWVKRXOGEHLQVWDOOHGDWWKHLQLWLDOORFDWLRQDIWHUUHLQIRUFHGRU

DWDQHZORFDWLRQ

 $Q\LQIODPPDEOHREMHFWPXVWQRWEHSODFHG

DERXWWKHORFDWLRQRILQVWDOODWLRQ

 &KHFNWKHJURXQGLQJWRVHHZKHWKHULWLV

SURSHURUQRWDQGLILWLVIRXQGLPSURSHU

FRQQHFWWKHJURXQGLQJWHUPLQDOWRWKHHDUWK

6SUD\

JDVROLQH

JDVERPEH

WKLQQHU

6$)(7<'85,1*5(3$,5:25.

,IWKH FRQWDFWVRIHOHFWULFDO

SDUWVDUHGHIHFWLYHUHSODFH

WKHHOHFWULFDOSDUWVZLWKRXW

WU\LQJWRUHSDLUWKHP











DANGER

WORKING STANDARDS FOR PREVENTING BREAKAGE OF SEMICONDUCTORS

1. Scope

The standards provide for items to be generally observed in carrying and handling semiconductors in

relative manufactures during maintenance and handling thereof. (They apply the same to handling of

abnormal goods such as rejected goods being returned.)

2. Object parts

(1) Microcomputer

(2) Integrated circuits (I.C.)

(3) Field effective transistor (F.E.T.)

(4) P.C. boards or the like to which the parts mentioned in (1) and (2) of this paragraph are equipped.

3. Items to be observed in handling

(1) Use a conductive container for carrying and storing of parts. (Even rejected goods should be handled in

the same way.)

(2) When any part is handled uncovered (in counting, packing and the like), the handling person must

always use himself as a body earth. (Make yourself a body earth by passing one M ohm earth

resistance through a ring or bracelet.)

(3) Be careful not to touch the parts with your clothing when you hold a part even if a body earth is

being taken.

(4) Be sure to place a part on a metal plate with grounding.

(5) Be careful not to fail to turn off power when you repair the printed circuit board. At the same time,

try to repair the printed circuit board on a grounded metal plate.

HITACH I IC401TH 1 ,188UV

Fig. 1 Conductive container

A conductive polyvinyl bag

Conductive sponge

Fig. 2 Body earth

Body earth (Elimik conductive band)

Clip for connection with

a grounding wire

1MΩ

(6) Use a three wire type soldering iron including a grounding wire.

Fig.4 Grounding a solder iron

Use a high insulation mode (100V, 10MΩor higher) when ordinary iron is to be used.

(7) In checking circuits for maintenance, inspection, or some others, be careful not to have the test probes

of the measuring instrument short circuit a load circuit or the like.

Bare copper wire (for body earth)

Metal plate (of Al. stainless steel, etc.)

Working table

Resistor 1MΩ(1/2W)

Earth wire

Staple

Fig.3 Grounding of the working table

soldering iron

Grounding wire

Screw stop at the screwed

part using a rag plate

In quiet or stop operation, slight flowing noise of refrigerant in the refrigerating cycle is heard occasionally,

but this noise is not abnormal for the operation.

2. When it thunders near by, it is recommend to stop the operation and turn off the circuit breaker for safety.

3. In the event of power failure,the room air conditioner will restare automatically in the previously

mode once the power is restored. In the event of power failure during TIMER operation, the room air comditioner

will not start automatically. Re-press ON/OFF button after 3 minutes from when the unit off or power recovery.

4. If the room air conditioner is stopped by adjusting thermostat, or missoperation, and re-start in a moment,

there is occasion that the cooling and heating operation does not start for 3 minutes, it is not abnormal and

this is the result of the operation of IC delay circuit. This IC delay circuit ensures that there is no danger of

blowing fuse or damaging parts even if operation is restarted accidentally.

5. This room air conditioner should not be used at the cooling operation when the outside temperature is

below -10°C (14°F).

6. This room air conditioner (the reverse cycle) should not be used when the outside temperature is below

–15°C (5°F).

If the reverse cycle is used under this condition, the outside heat exchanger is frosted and efficiency falls.

7. When the outside heat exchanger is frosted, the frost is melted by operating the hot gas system, it is not

trouble that at this time fan stops and the vapour may rise from the outside heat exchanger.

CAUTION

selected

SPECIFICATIONS

MODEL

FAN MOTOR

FAN MOTOR CAPACITOR

FAN MOTOR PROTECTOR

COMPRESSOR

COMPRESSOR MOTOR CAPACITOR

OVERLOAD PROTECTOR

OVERHEAT PROTECTOR

FUSE (for MICROPROCESSOR)

POWER RELAY

POWER SWITCH

TEMPORARY SWITCH

SERVICE SWITCH

TRANSFORMER

VARISTOR

NOISE SUPPRESSOR

THERMOSTAT

REMOTE CONTROL SWITCH (LIQUID

CRYSTAL)

YES(INTERNAL)

YES

G4A-1A

YES

YES(IC)

WITHOUT REFRIGERANT BECAUSE

COUPLING IS FLARE TYPE.

UNIT

PIPES

(MAX. 20m)

REFRIGERANT CHARGING

VOLUME

(Refrigerant 410A)

RAC-35 PC

1050g 1250g

(MIN. 3m)

47W (DC120~380V)

RAC- P50W

15A, 2A, 3A, 3.15A 25A, 2A, 3A, 3.15A

YES

450NR, ERZVA431

ASD102SKQ A6 JK6 ATD141RDNA8JT

Figure showing the installation of Outdoor unit

MODEL RAC-35WPC

The refrigerating machine oil is

easily affected by moisture. Use

caution to prevent water from

entering the cycle.

The difference in height between

the indoor and outdoor unit

should be kept below 10m.

The connecting pipe, no matter

big or small, should all be

insulated with insulation pipe and

then wrapped with vinyl tape.

(The insulator will deteriorate if

it is not wrapped with tape).

The connection of insulated drain

hose.

Inner diameter 16mm

Please use insulated drain hose for

the indoor piping (commercial

product)

above 100mm

above 300mm

above 50mm

give clearance

as wide as

possible

above

200mm

above 50 mm when

installed on the

ceiling of balcony

above 200mm

Maximum pipe length 20m

Minimum pipe length m3

Figure showing the installation of Outdoor unit

MODEL RAC-50WPC

The refrigerating machine oil is

easily affected by moisture. Use

caution to prevent water from

entering the cycle.

The difference in height between

the indoor and outdoor unit

should be kept below 10m.

The connecting pipe, no matter

big or small, should all be

insulated with insulation pipe and

then wrapped with vinyl tape.

(The insulator will deteriorate if

it is not wrapped with tape).

The connection of insulated drain

hose.

Inner diameter 16mm

Please use insulated drain hose for

the indoor piping (commercial

product)

above 100mm

above 00mm

above 50mm

give clearance

as wide as

possible

above

200mm

above 50 mm when

installed on the

ceiling of balcony

above 200mm

Maximum pipe length 20m

Minimum pipe length m3

CONSTRUCTION AND DIMENSIONAL DIAGRAM

OUTDOOR UNIT

Handle

Air Suction grill

Air outlet

Handle

Rear side

Holes for anchor bolt

(2 – ø12 x 6 slots for ø8.0 bolt)

(for 2 – ø8.0 bolt)

Notch for anchor bolt

Fixing hole

Drain hole

than

More than

100

More than

200

than

300

Service space

than

200

NOTE:

1.For outdoor unit installation , allow at least 2 sides of space around the unit ensure ventilation flue.

2.The connecting pipe , should all the insulated with insulation pipe.

3.Piping length is within 20m.

4.Height d fferent of the piping between the indoor unit and outdoor unit s ould be within 10m.ih

MODEL RAC-35WPC

Unit : mm

CONSTRUCTION AND DIMENSIONAL DIAGRAM

OUTDOOR UNIT

NOTE:

1.For outdoor unit installation , allow at least 2 sides of space around the unit ensure ventilation flue.

2.The connecting pipe , should all the insulated with insulation pipe.

3.Piping length is within 20m.

4.Height d fferent of the piping between the indoor unit and outdoor unit s ould be within 10m.ih

MODEL RAC-50WPC

than

200

More than

300

600

345

299

202

163.5

589

792

877

190

147

(11)

Drain hole

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Acondicionador de aire de Hitachi

Hitachi

Hitachi RAS-S10H2 Manual de usuario

Hitachi

Hitachi RHUE-3AVHN1 Manual de instalación y funcionamiento

Hitachi

Hitachi air Core 700 Manual de instrucciones

Hitachi

Hitachi UTOPIA ES RAS-3HVRNS3 Manual de usuario

Hitachi

Hitachi RPK-0.4FSRM Manual de usuario

Hitachi

Hitachi RAI-25NH4 Manual de usuario

Hitachi

Hitachi RPFC-2.0UNE1NH Manual

Hitachi

Hitachi RPKFSN3M Manual de usuario

Hitachi

Hitachi RAS-70YH7 Manual de usuario

Hitachi

Hitachi RAS-SD13CCT Manual de usuario

Hitachi

Hitachi RAS-25CNH1 Manual de usuario

Hitachi

Hitachi RPK-0.8FSNH2M Manual de usuario

Hitachi

Hitachi RAS-SD10CD Manual de usuario

Hitachi

Hitachi RAI-25NH5 Manual de usuario

Hitachi

Hitachi Set Free mini-HNRQ1 Series Manual de instrucciones

Hitachi

Hitachi RAC-60WPA Manual de usuario

Hitachi

Hitachi RAC-35N5 Manual de usuario

Hitachi

Hitachi RAI-25NH5 Manual de usuario

Hitachi

Hitachi RAS-DX18HDK Manual de usuario

Hitachi

Hitachi RAM-130QH5 Manual de usuario

Hitachi

Hitachi RAC-25FXB Manual de usuario

Hitachi

Hitachi RA-08HF1 Hoja de especificaciones

Hitachi

Hitachi RAF-35RXE Manual de usuario

Hitachi

Hitachi RAS-35FH6 Manual de usuario

Manuales populares de Acondicionador de aire de otras marcas

Spheros

Spheros CC 355 Manual de usuario

Bosch

Bosch Climate 5000 SCI 24 CAS/ OU- OUE Manual de usuario

Panasonic

Panasonic CS-E12HKEW Manual de usuario

nedis

nedis ACMB1WT7 Manual de usuario

Samsung

Samsung AR KV Series Guía

Daikin

Daikin FCFV50A Manual de usuario

Fujitsu

Fujitsu Inverter ASBA30JFC Manual de usuario

Toshiba

Toshiba RAS-M10SMUV-E Manual de usuario

Daikin

Daikin FXLQ20MAVE Manual de usuario

CIAT

CIAT Magister 2 Series Guía

Bestron

Bestron AAC6000 Manual de usuario

Hisense

Hisense 7K Manual técnico

Frigidaire

Frigidaire FFRE0533S1E0 Manual de usuario

Samsung

Samsung AS09HM3N Manual de usuario

Frigidaire

Frigidaire CRA073PU11 Manual del propietario

Soleus Air

Soleus Air GB-PAC-08E4 Manual de usuario

McQuay

McQuay MCK020A Manual de usuario

Webasto

Webasto Frigo Top 25 DS Manual de usuario