Hisun HS294-2 Manual del propietario

Introduction HS 294-2

1-1

INTRODUCTION

Congratulations on your purchase of the HS294-2. This Owner’s / Operator’s

manual will provide you information regarding safe operation, operational

instructions, maintenance and care. Fully understanding this manual and following

all of the instructions herein will provide the knowledge needed to have safe and

enjoyable vehicle operation.

If you have any questions regarding the operation or maintenance of your

UTV, please

call Monkija Trail Park Oy at 0086-23-61020546 or go to Pajalantie 6a 37550,

Lempaala,

Finland.

IMPORTANT SAFETY MESSAGES

●READ THIS MANUAL CAREFULLY AND COMPLETELY BEFORE OPERATING YOUR

UTV.

MAKE SURE YOU UNDERSTAND ALL INSTRUCTIONS.

●PAY CLOSE ATTENTION TO THE WARNING AND CAUTION LABELS ON THE UTV.

●NEVER OPERATE THE UTV WITHOUT PROPER TRAINING OR INSTRUCTION.

●THIS UTV SHOULD NOT BE RIDDEN BY ANYONE UNDER

16 YEARS OF AGE.

Introduction HS 294-2

1-2

IMPORTANT MANUAL INFORMATION

FAILURE TO FOLLOW THE WARNINGS CONTAINED IN THIS MANUAL CAN RESULT IN

SERIOUS INJURY OR DEATH. Particularly important information is distinguished in

this manual by the following notations:

The Safety Alert Symbol means ATTENTION!

YOUR SAFETY IS INVOLVED!

Introduction HS 294-2

1-3

Failure to follow WARNING instructions could result in severe injury or

death to

the machine operator, bystander or a person inspecting or repairing the

machine.

A CAUTION indicates special precautions that must be taken to avoid

damage

to the machine.

NOTE: A NOTE provides key information to make procedures

easier clearer.

Introduction HS 294-2

1-4

IMPORTANT NOTICE

This vehicle is designed and manufactured for ON - ROAD use only.

This vehicle complies with all applicable ON - ROAD noise level and spark arrester laws and

regulations in effect at the time of manufacture.

Please check your local riding laws and regulations before operating this vehicle.

When the temperature is below -4°F (-20°C), park the vehicle in a place where the temperature

is higher

than -4°F (-20°C). Start the vehicle after the vehicle has warmed up. Please see page 7-3 on

the warming up process.

Follow the proper parking procedures when the temperature is higher than 100°F (38°C): turn

off the

engine; make sure the radiator fan is on for 3 minutes before turning off the power switch.

Starting the UTV for the first time will take longer because the fuel will need reach the fuel

injectors. To

start the UTV the first time, hold the ignition key on at 5-second intervals. Allow the starter to

rest 15

Introduction HS 294-2

1-5

seconds between each start attempt.

Introduction HS 294-2

1-6

NIVERSAL SYMBOLS

As a guide to the operation of your vehicle, various universal symbols have been

utilized on the instruments and controls. The symbols are shown below with an

indication of their meaning.

Safety Alert Symbol

Lift Cylinder-Retract

Diesel Fuel

Lift Cylinder-Extend

Engine coolant-Temperature

Lift Cylinder-Float

Parking Brake

Hazard Warning Lights

Battery Charging Condition

Master Lighting Switch

Engine Oil-Pressure

Audible Warning Device

Turn Signal/Hazard

Fault indicator light of EPS system

Differential Lock

2WD/ 4WD

Position light bulb

Introduction HS 294-2

1-7

Introduction HS 294-2

1-8

Table of Contents

Subject

Page

Introduction

1-1

Important manual information

1-2

Important notice

1-3

Universal symbols

1-4

Location of parts

1-7

Illustrated contents

1-8

Safe operation

2-1

Safety instructions

2-1

Operation

2-2

Children safety instructions

2-2

Driving on a slope

2-3

Driving in harsh conditions

2-3

Driving at high speed

2-3

Instructions for carrier

2-3

Parking

2-4

Transportation

2-4

Maintenance

2-4

Warning and caution labels

3-1

Servicing of vehicle

4-1

Specifications table

5-1

Vehicle limitations

5-3

Pre-operation

6-1

Operating the engine

7-1

Starting the engine

7-1

Cold starting

7-2

Stopping the engine

7-2

Warming up

7-2

Warm-up transmission oil in the

low temperature range

7-2

Operating the vehicle

8-1

Operating new vehicle

8-1

Do not operate the vehicle at full

speed for the first 50 hours

8-1

Changing lubricating oil for new

vehicles

8-1

Subject

Page

Starting

8-1

Seat belt

8-1

Head light switch

8-2

Emergency light switch

8-2

Turn signal light switch

8-2

Brake pedal

8-3

Range gear shift lever

8-3

4WD lever

8-4

Accelerator pedal

8-4

Introduction HS 294-2

1-9

Stopping

8-5

Fuel gauge

8-5

Winch mount plate

9-1

Transporting vehicle

9-1

Service intervals

9-2

Periodic service

10-1

How to open the front hood and

seat

10-1

Front hood cover

10-1

Operator’s sea

10-1

Moving the seat forward and

backward

10-1

Adjustment of the steering wheel

10-2

How to raise the cargo bed

10-2

Raising and lowering the cargo

bed

10-2

Front and rear shock adjustment

Spring preload

10-3

Rebound damping force

10-4

Compression damping force

10-4

Jack-up point

10-5

Front end

10-5

Rear end

10-5

Daily check

10-5

Walk around inspection

10-5

Checking and Refueling

10-6

Checking coolant level

10-6

Cleaning radiator screen

10-7

Checking brake fluid level

10-7

Checking brake pedal

10-8

Checking parking brake

10-8

Checking gauges meter and easy

checker lamps

10-8

Checking head light turn signal

light etc

10-8

Checking seat belt and ROPS

10-8

Checking joint boot

10-8

Checking tire inflation pressure

10-9

Every 50 hours

10-9

Greasing

10-9

Checking engine start system

10-10

Checking wheel bolt torque

10-10

Cleaning air cleaner primary

element

10-11

Checking battery condition

10-12

Adjusting toe-in

10-13

Cleaning muffler

10-14

Every 200 hour

10-14

Changing engine oil

10-14

Introduction HS 294-2

1-10

Replacing engine oil filter

10-15

Replacing transmission oil

10-15

Checking brake pedal

10-16

Checking brake hose and pipe

10-16

Checking brake light switch

10-16

Checking radiator hose and clamp

10-17

Checking intake air line

10-17

Every 300 hours

10-17

Checking tire

10-17

Every 400 hours

10-18

Changing transmission fluid

10-18

Changing front and rear axle case

oil

10-18

Every 500 hours

10-19

Replacing fuel filter

10-19

Every 600 hours

10-19

Adjusting engine valve clearance

10-19

Every 1500 hours

10-19

Checking injection and fuel pump

10-19

Every 1 year

10-19

Replacing air cleaner primary

element and secondary element

10-19

Every 2 years

10-19

Changing brake fluid

10-19

Flushing Cooling system and

changing coolant

10-19

Anti-freeze

10-20

Replacing radiator hose (water

pipes)

10-21

Replacing fuel hose

10-21

Replacing brake master cylinder

(inner parts)

10-21

Replacing front brake seal

10-21

Replacing rear brake cylinder seal

10-21

Replacing intake air line

10-21

Every 4 years

10-21

Replacing brake hose

10-21

Replacing mini fuses

10-22

Storage

10-22

Vehicle storage

10-22

Removing the vehicle from storage

10-23

Electric Power Steering System

11-1

Hitch coupling device

12-1

Troubleshooting

13-1

Engine troubleshooting

13-1

Diagnostic trouble code table

13-2

Battery troubleshooting

13-4

Machine troubleshooting

13-5

Tabla de contenidos

Otros manuales de Vehículo utilitario de Hisun

Hisun

Hisun STRIKE 800 Manual de usuario

Hisun

Hisun HS1P65MM Manual de usuario

Hisun

Hisun HS164-4 Manual de usuario

Hisun

Hisun Strike 250 Manual de usuario

Hisun

Hisun HS500UTV Manual de usuario

Hisun

Hisun HS394-2 Manual del propietario

Hisun

Hisun HS700UTV-4 Manual

Hisun

Hisun HS250UTV Manual del propietario

Hisun

Hisun HS500UTV Manual de usuario

Hisun

Hisun SECTOR 1000 Manual de usuario

Hisun

Hisun HS 500 Manual de usuario

Hisun

Hisun HS800 Manual de usuario

Manuales populares de Vehículo utilitario de otras marcas

Polaris

Polaris ACE 900 SP Manual de usuario

TrailMax

TrailMax T-12-UR Manual de usuario

Floe

Floe Cargo Max 9.5-73 Manual de usuario

Toro

Toro 07277 Workman 2110 Manual de usuario

Taylor-Dunn

Taylor-Dunn B0-050-00 Manual

Toro

Toro 133-7128 Manual de usuario

Taylor-Dunn

Taylor-Dunn ET 3000 Manual de usuario

Kayo

Kayo S70 Manual de usuario

Range Road

Range Road RR608 Manual de usuario

Landoll

Landoll 900D Series Manual de usuario

pronovost

pronovost PUMA-10000 Manual de usuario

SSI SCHAEFER

SSI SCHAEFER WEASEL LITE Manual de usuario

Club Car

Club Car TURF 272 2005 Manual

Toro

Toro 07059TC Manual de usuario

Cushman

Cushman Turf Truckster 84069 Manual de usuario

BERG

BERG Large Trailer Manual de usuario

Cub Cadet

Cub Cadet Big Country 641 Manual de usuario

Westward

Westward Go-4 XTR Manual de usuario