dangerous operating conditions from leaking exhaust gases, fuel leakage, oil leakage, etc.
• On electric start models, disconnect the POSITIVE (+) battery cable from the engine starter or the NEGATIVE (-) battery cable
from the battery terminal, whichever is easier, before transporting the generator.
NOTE:
The generator muffler is equipped with a spark arrestor, which must be maintained in effective working order by the owner/
operator.
EXHAUST & LOCATION HAZARDS
• Never operate in an enclosed area or indoors! NEVER use in in partly enclosed areas such
as garages, even if doors and windows are open! ONLY use outdoors and far from open
windows, doors, vents, and in an area that will not accumulate deadly exhaust.
• The engine exhaust fumes contain carbon monoxide, which you cannot see or smell. This
poisonous gas, if breathed in sufficient concentrations, can cause unconsciousness or even
death.
• Adequate, unobstructed flow of cooling and ventilating air is critical to correct generator
operation. Do not alter the installation or permit even partial blockage of ventilation
provisions, as this can seriously affect safe operation of the generator. The generator MUST be operated outdoors.
• This exhaust system must be properly maintained. Do nothing that might render the exhaust system unsafe or in
noncompliance with any local codes and/or standards.
• Always use a battery operated carbon monoxide alarm indoors, installed according to the manufacturer instructions.
• If you start to feel sick, dizzy, or weak after the generator has been running, move to fresh air IMMEDIATELY. See a doctor, as
you could have carbon monoxide poisoning.
ELECTRICAL HAZARDS
• The generator produces dangerously high voltage when in operation. Avoid contact with bare wires, terminals, etc., while
the unit is running, even on equipment connected to the generator.
• Never handle any kind of electrical cord or device while standing in water, while barefoot or hands or feet are wet.
DANGEROUS ELECTRICAL SHOCK MAY RESULT.
• The National Electric Code (NEC) requires the frame and external electrically conductive parts of the generator be properly
connected to an approved earth ground. Consult with a local electrician for grounding requirements in the area.
• Use a ground fault circuit interrupter in any damp or highly conductive area (such as metal decking or steel work).
• Do not use worn, bare, frayed or damaged electrical cord sets with the generator.
• Before performing any maintenance on the generator, disconnect the engine starting battery to prevent accidental start up.
Disconnect the cable from the battery post indicated by a NEGATIVE, NEG or (–) first. Reconnect that cable last.
• In case of accident caused by electric shock, immediately shut down the source of electrical power. If this is not possible,
attempt to free the victim from the live conductor. AVOID DIRECT CONTACT WITH THE VICTIM. Use a non-conducting
implement, such as a rope or board, to free the victim from the live conductor. If the victim is unconscious, apply first aid and
get immediate medical help.
FIRE HAZARDS
• Gasoline is highly flammable and its vapor is explosive. Do not permit open flames, sparks or heat nearby while handling
gasoline.
• Never add fuel while unit is running or hot. Allow engine to cool completely before adding fuel.
• Never fill fuel tank indoors. Comply with all laws regulating storage and handling of gasoline.
• Do not overfill the fuel tank. Always allow room for fuel expansion. If tank is over-filled, fuel can overflow onto a hot engine
and cause FIRE or an EXPLOSION. Never store generator with fuel in tank where gasoline vapors might reach an open flame,
spark or pilot light (as on a furnace, water heater or clothes dryer). FIRE or EXPLOSION may result. Allow unit to cool entirely
before storage.
• Wipe up any fuel or oil spills immediately. Ensure that no combustible materials left on or near the generator. Keep the area
surrounding the generator clean and free from debris and keep a clearance of five (5) feet on all side to allow for proper
ventilation of the generator.
• Do not insert objects through unit’s cooling slots.
• Do not operate the generator if connected electrical devices overheat, if electrical output is lost, if engine or generator
sparks or if flames or smoke are observed while unit is running.
• Keep a fire extinguisher near the generator at all times.
1.1 UNPACKING
