HARMSCO BC4 Series Manual de usuario

BC4, MANUAL

HARMSCO®

Filtration Products

BC4 Series

INSTALLATION AND OPERATION MANUAL

Model BC4-1 Model BC4-2 Model BC4-3

BC4, MANUAL Page 2 of 20

HARMSCO® Filtration Products

BC4 Series INSTALLATION AND OPERATION MANUAL

Safety Precautions:

Before using and installing the parts of this product,

please read this entire manual. Failure to do so could result

in serious personal injury or damage to the equipment or

assembled components.

This product, and all of its components, MUST NOT be

installed or used in any manner other than that which is

specified in this manual.

! WARNINGS !

1. Do not install the unit in direct sunlight or near a heat source.

2. Do not install the unit where a temperature of 35° F, or lower, can

occur. Damage caused by freezing shall void all warranties.

3. The unit is to be properly grounded utilizing a grounding lug

located on one of the legs.

4. Seek qualified assistance for installation.

5. Do not backwash.

This product is manufactured under one or more of the following patents: U.S. NO. 4,187,179;

3,720,322; CANADA NO. 977,693; GT. BRIT. NO. 1,372,014; W. GERMANY NO. 2,261,817;

FRANCE NO. 7,246,864; EUROPEAN NO. 0,191,844, Other patents pending

BC4, MANUAL Page 3 of 20

CONTENTS

Safety Precautions & Warnings Pg. 2

Table of Contents Pg. 3

Recommendations Pg. 3

Installation/Set-up Pg.4

Installation Block Diagram Pg. 5

Installation Diagrams (BC4-1, BC4-2, BC4-3) Pgs. 6, 7, & 8

Parts Diagram Pg. 9

Operation Pg. 10

Description Pgs.10&11

Cartridge Replacement Instructions Pgs. 12—15

Data Specification Sheet Pg. 16

Flow Curves Pgs. 17 & 18

Filter Cartridge Maintenance Instruction Sheet Pg. 19

Warranty Information Pg. 20

RECOMMENDATIONS

Installation:

Include a by-pass line for inlet and outlet with valves to isolate unit

while servicing. Plumb drains with appropriate valves to reduce service time and

use stainless steel fittings.

Cartridge:

Replace cartridges when necessary based on water quality, or every

six months, whichever comes first.

HARMSCO® Filtration Products

BC4 Series INSTALLATION AND OPERATION MANUAL

BC4, MANUAL Page 4 of 20

INSTALLATION

The following diagrams show the Harmsco BC4 Housings with typical plumbing

hook-up requirements.

Note: Do not install the unit in direct sunlight.

Do not install near a heat source.

1. Install incoming water supply to 2” FNPT coupling marked "Inlet".

2. Install outlet line to 2" FNPT coupling marked "Outlet", use stainless steel fit-

ting.

3. Install valves in drain lines and connect to 1/2" FNPT couplings located at

the bottom center and side of housing. Use stainless steel fittings.

Note: It is recommended to plumb a by-pass line to

supply unfiltered water while servicing if necessary.

4. Mount and secure housing using the three slots at the bottom of the legs.

See Installation Diagrams.

5. A qualified technician should make all connections.

6. Ground the filter housing utilizing the grounding lug on the leg.

7. Make sure housing’s cartridges,

lid and clamp-band are properly

positioned, see the Filter Car-

tridge Maintenance Instructions.

8. Start the flow of water and allow

the housing to completely fill.

The Harmsco BC4 Water Filter is

now operational.

HARMSCO® Filtration Products

BC4 Series INSTALLATION AND OPERATION MANUAL

Grounding Lug,

Can be positioned

between any pair of

legs.

BC4, MANUAL Page 5 of 20

HARMSCO® Filtration Products

BC4 Series INSTALLATION AND OPERATION MANUAL

BC4, MANUAL Page 6 of 20

HARMSCO® Filtration Products

BC4 Series INSTALLATION AND OPERATION MANUAL

BC4, MANUAL Page 7 of 20

HARMSCO® Filtration Products

BC4 Series INSTALLATION AND OPERATION MANUAL

BC4, MANUAL Page 8 of 20

HARMSCO® Filtration Products

BC4 Series INSTALLATION AND OPERATION MANUAL

BC4, MANUAL Page 9 of 20

HARMSCO® Filtration Products

BC4 Series INSTALLATION AND OPERATION MANUAL

#1601-C, LID

#1625-B, O-RING 10”

#1615, CLAMP BAND

#1635-B, KNOB

#1645, TOP PLATE

ASSY, CONSISTS OF;

#1633, SNAP RING,

#1654-P , BUSHING,

1643, TOP PLATE

WELDMENT

PARTS DIAGRAM

Unless specified, parts are common to all units.

TANK ASSY

BC4-1,

BC4-2 (shown), or

BC4-3

#801 CARTRIDGE,

SOLD SEPARATELY,

CONSULT SALES FOR

PART #.

QTY 4 FOR BC4-1,

QTY 8 FOR BC4-2 (as

shown), &

QTY 12 FOR BC4-3.

NOTE: #921 CAR-

TRIDGE MAY BE SUB-

STITUED FOR QTY 2

OF #801, &

#931 CARTRIDGE

MAY BE SUBSTITUED

FOR QTY 3 #801’S

FOR THE BC4-3

HOUSING.

LIFTER

#1648 FOR BC4-1,

#1649 FOR BC4-2, &

#1650 FOR BC4-3.

BC4, MANUAL Page 10 of 20

HARMSCO® Filtration Products

BC4 Series INSTALLATION AND OPERATION MANUAL

OPERATION

Description:

The BC4 series filters come in three sizes, BC4-1, -2 & -3,

which represent the number of levels of #801 cartridges, and consists of

a housing, lid, lifter rods (qty 4), top plate assembly, and a clamp band &

O-ring housing seal. Each level will contain four cartridges that are inter-

nally supported by the lifter rod and are sealed to the housing by the top

plate assembly to prevent by-pass. The housing is divided into two

chambers; an upper, “inlet”, chamber, which Is where the cartridge filters

are, and lower, “outlet”, chamber. All metallic components are made of

300 series stainless steel.

The cartridges (filter cartridges) are sold separately and avail-

able in a wide variety of materials and functional pore sizes. Please con-

sult with your Sales/Application Engineer to properly select the correct

filter that will achieve your desired requirements.

Cross sectional view including

the inlet and outlet.

Outlet

2” FNPT

Housing

BC6-2

Clamp Band

Lid

Intlet

2” FNPT

Drain (far-side), out-

let chamber, 1/2”

FNPT

Housing

O-ring Seal

Intlet stream

baffel

Top Plate

Assembly

Clamping

Knob

Vent Port,

1/4” FNPT

801 Cartridge

Este manual sirve para los siguientes modelos

Otros manuales de Sistema de filtración de agua de HARMSCO

HARMSCO

HARMSCO BC6-1 Manual del propietario

HARMSCO

HARMSCO WaterBetter WBC 170SC-2 Manual de usuario

HARMSCO

HARMSCO Hurricane HUR 1X170FL-XP Manual de usuario

HARMSCO

HARMSCO Hurricane HUR 170 HP Manual de usuario

Manuales populares de Sistema de filtración de agua de otras marcas

Wisy

Wisy LineAir 100 Manual de usuario

Schaffner

Schaffner Ecosine FN3446 Series Manual de funcionamiento

Pentair

Pentair FLECK 4600 SXT Guía del usuario

H2O International

H2O International H20-500 Manual de usuario

Renkforce

Renkforce 2306241 Manual de usuario

Neo-Pure

Neo-Pure TL3-A502 Manual de usuario

FLTR

FLTR OBF Manual de usuario

STA-RITE

STA-RITE VERTICAL GRID DE FILTERS S7D75 Manual de usuario

Applied Membranes

Applied Membranes W-G844EM Manual de usuario

BEGA

BEGA 116 Manual de usuario

WATA

WATA Standard Manual de usuario

Price

Price FFU series Manual

Gaggenau

Gaggenau BRITA INTENZA 467873 Manual de usuario

Brita

Brita SAFF-100 Manual de usuario

HEISSNER

HEISSNER FPU24000-00 Manual de usuario

BGS technic

BGS technic 1518 Manual de usuario

Reverse Osmosis

Reverse Osmosis RF Series Manual de usuario

ubbink

ubbink Filtramax Series Manual de usuario