HAMPTON BAY GFHD42 Manual del propietario

Instructions

& User’s Manual

Model No：GFHD42

FOR OUTDOOR USE ONLY.

KEEP THE INSTRUCTIONS FOR FUTURE REFERENCE.

For product warranty,please go to www.hamptonbay.com or call 1-855-HD-HAMPTON

WARNING

Before you assemble or operate this unit, please carefully read this entire manual. Failure to do so

may r

SAFETY INFORMATION

• The installation of this unit must adhe re to local codes or either the National Fuel Gas Code, ANSI

Z223. 1/NFPA54, OR CAN/CGA-B149.1, National Gas and Propane Installation Code.

• THIS UNIT IS INTENDED FOR OUTDOOR USE ONLY! This product shall be used outdoors, in a

ventilated space and shall not be used in any enclosed a rea.

• This unit is to be used with p ropane gas only! (sold separately)

• Do not attach a remote gas supply to this unit.

• Only use propane gas for this unit.

• Do not use any solid fuel or charcoal for this unit.

• LP GAS WARNING: Do not use any more than 1/4in depth lava rocks/pumice stones/LavaGlass ™

• If the propane gas tank is leaking gas, you may hear, see, or smell a hiss. Do the following:

• Applying too much p ropane may result in gas pooling and will not bu rn. Allow fresh air into the unit

so that the remaining gas may escape.

• The max. inlet supply pressure: max. Gas supply 11 in w.c. (2.74kPa)

• Use LP propane tanks with the following dimensions: diameter 12 in, height 18 in - capacity 20 lbs.

• You must use a propane tank that has a collar to p rotect the gas valve.

• The tank system must be set up for vapor withdrawal.

• Discontinue use if any part of the p ropane tank is damaged. Rust and dents may be haza rdous and

should be inspected by a gas supplie r.

rocks/pumice stones/LavaGlass ™ could pop out and cause injur y. Should any rocks pop out, disca rd

them.

• Always ensure that lava rocks/pumice stones/LavaGlass ™ are completely dry befo re use. Failure to

do so will cause them to crack or pop.

• Do not operate unit until all parts a re fully assembled.

• Do not paint or color any part of this heating unit.

• Unit may be hot while in use, do not attempt to move it while in use.

• Never leave this heating unit unattended while in use.

• This unit is not intended for cooking.

• Keep a safe distance to avoid bu rning skin or clothing.

• Do not sit or rest hands or feet on this heating unit.

• Keep all electrical cords and fuel supply hose away f rom heated surfaces.

bowl.•

• Combustible material should not be within 72 inches of the top of the unit, or within 48 inches

around the entire unit.

• Keep the appliance area clear and free fr

vapors and liquids.

• ning, turn the gas valve off. Wait 5 minutes before repeating the initial

• Do not add water into the unit.

• Do not operate unit if any part has been under water. Immediately callaqualified service

technician to inspect the appliance and replace any part of the control system and any gas

control that has been under water.

• Do not disconnect any part while unit is in use.

• Do not store a spare propane tank on or near this unit.

• If the heating unit is indoors, detach the propane tank and leave outdoors.

• Always remove protective cover before operating (if applicable).

• Do not set the protective cover over the unit until it is turned off and completely cooled down.

• Check for leaks after not using the unit for long periods of time.

• Children should never operate this unit. Children must be supervised while near this unit.

• Keep gas tank at least 5 feet away from unit when lit. (if external tank)

• The maximum gas supply pressure is 250psi.

inspected annually and cleaned regularly.

• Inspect all elements of this heating unit before each use. If there is damage, the burner must be

replaced.

• Keep the hose out from any pathways to eliminate any accidental damage. (if external tank)

• Be aware of the hazards of high temperatures and stay away from the unit to avoid any burns or

injury.

of the U.S. Department of Transportation or the National Standard of Canada CAN/CSA-B339, LP gas

tanks, spheres and tubes for Transportation of Dangerous Goods; and Commission.

gas tank connection.

cks.

• Children and adults should be alerted to the hazards of high surface temperatures and should

stay away to avoid burns or clothing ignition.

• Young children should be carefully supervised when they are in the area of the appliance.

near the appliance.

• Any guard or other protective device removed for servicing the appliance shall be replaced

prior to operating the appliance.

may be required as necessary. It is imperative that the control compartment, burners and

circulating airways of the appliance are kept clean.

IF APPLICABLE:

• Allow heating item to cool completely before placing on lid.

• DO NOT use heating item while lid is installed. Always remove the lid while heating item is in use.

Only use the regulator and hose assembly provided with this unit.

Inspect the bur ner before use of this unit. If the bur ner shows any kind of damage, do not operate

the appliance.

NOTE: You must follow all steps to properly assemble this heating item. Make sure the gas

valve is turned “OFF” before assembling. Do NOT attempt to assemble without proper tools.

SAFETY INFORMATION

Min. Clearance

48 in (121.9 cm)

Min. Clearance

48 in (121.9 cm)

Min. Clearance

48 in (121.9 cm)

Min. Clearance

48 in (121.9 cm)

Combustible materials should not be within 72

inches of the top of the unit, or within 48 inches

around the entire unit.

Item Description Qty

A Lid

B Lava Rocks 1 box

C Body 1

D Tank Holder 1

E Battery 1

F Control Knob (preassembled) 1

G Electronic Igniter (preassembled) 1

H 4

CONTENTS

Adjust Foot

I 1Protective Cover for Gas Cylinder

ASSEMBLY INSTRUCTIONS

2. Check that the cont

1.Turn over the body(C) and assemble 4pcs

adjust feet(H) into bottom.

rol knob (F) for the gas

supply system is tu rned to the “OFF” position

before starting any assembly.

3. Put the 20 lb. propane gas tank (not included)

into the tank holder (D). Turn the wing screw on

the outside of the tank holder (D) clockwise to

tighten the tank into the tank holde r.

Propane tank must be a minimum of 60 inches

away at all times.

DANGER

OFF

5. Remove the rubber cap on the electronic igniter

(G) by unscrewing and slide battery (E) into the

battery slot. Make sure the positive side of the

battery faces outwards. Screw the electronic

igniter cap (G) over the battery tightly.

6. Remove the lid(A), and pour the box of lava

To ensure proper function, the guard on this

burner should be free of lava rocks at all times.

WARNING

CYLINDER VALVE

PRESSURE

RELIEF VALVE

BLEED-OFF

VALVE

BLACK COUPLING NUT

REGULATOR

turn clockwise to connect

turn clockwise

to reseal

4. Turn the cylinder valve on the tank

clockwise to close the p ropane tank.

Attach the p reassembled regulator

from the body (C) to the cylinder valve

by turning the regulator coupling nut

clockwise. Make su re it is fastened

securely and tighten connections by hand

only.

To Light

To Extinguish

Before performing a leak test, be sure that no sparks can occur and you a re in a spacious outdoor

area. Connect the propane gas tank to the regulator and turn the valve on the unit to the “o ff”

position. Brush a soap and water mixtur e on all connections. Turn the gas supply on; if bubbles

occur on any connection the re may be a leak. If you smell gas or a leak is discove red tu rn the

gas valve o ff, disconnect p ropane gas tank and do not use the appliance until the leak is

repai red.

Do not use the heating unit without inspecting the gas hose. If the re are signs of wear or abrasion

you must replace the hose (if applicable). Pumice stones/lava rocks/LavaGlass could pop up and

20 minutes after igniting. Flame height should be a yellow/blue color between 2 - 10 inches in height.

heating item.

1. Make sure the control knob (F) is in the “off” position. Slowly open the valve on the p ropane gas

tank by turning the knob counte rclockwise.

2. Push and hold in the electronic ignit r (G) to create sparks within the elect rode, continue to hold.

3. Push in the control knob (F) and turn to the “low” position. Keep holding down the cont rol knob

5 seconds.

4. If ignition doesn’t occur within a few seconds , release the control knob (F) and rotate to the “OFF”

position. Wait for 5 minutes for gas to clear and then repeat the above lighting instructions.

between the “low” and “high” positions.

1. Turn control knob (F) clockwise to the “low” posi

the control knob (F) to the “off” position.

2. Close the cylinder valve on the propane gas tank if you don ’t intend to use it for a long time.

OPERATION

Fire product and p ropane gas cylinder minimum

distance must be over 60 inches (as per right side

photo)

WARNING

60”

tion; let the knob pop up and continue turning

MAINTENANCE

• Before performing any maintenance always disconnect propane gas tank.

• Keep the heating item free and clear from combustible materials.

• Visually inspect burner for obstructions and keep tank enclosure free and clear from debris.

• Use a soft brush to get rid of the mild stains, loose dirt and soil after the burner and pumice stones/

lava rocks/LavaGlass™ are completely cooled down. Wipe down with a soft cloth.

• Harsh weather conditions may cause stubborn stains, discoloration and possibly rust pitting.

• Permanent damage may occur if powder or solvent comes in contact with painted or plastic

components on this heating unit.

• Keep the heating unit stored away from direct sunlight.

• If storing this unit inside, disconnect the propane gas tank from the gas valve.

• Not using manufacturer approved or supplied parts/accessories may result in a defective condition

and void the warranty of this heating unit.

• Always place lid (if applicable) or protective cover on heating item when not in use.

TROUBLESHOOTING

Problem Cause Solution

Igniter pin and burner are wet Dry off with a soft cloth

Igniter battery is incorrectly inserted Check which direction the battery is

inserted

Igniter pin is broken Contact Bond Manufacturing for a

replacement part

Electrode wire is loose or disconnected Reconnect wire to the igniter box located

inside the ﬁre table behind the igniter box

Electrode wire is shorting between valve

and igniter pin

Contact Bond Manufacturing for a re-

placement part

No gas ﬂow Check that the gas tank isn’t empty

Regulator isn’t connected securely to the

tank

Tighten regulator connection to the gas

tank

Gas ﬂow is obstructed Check all hoses for kinks and bends

Burner ports are clogged Turn all gas ﬂow connections off. Insert

an opened paperclip (or similar item) into

each of the burner ports to clear them

out.

Flame is obstructed at burner ports Check that all burner ports are free of any

small lava rocks/pumice stones/Lava-

Glass™ pieces

Regulator hose is kinked Straighten hose of all bends or kinks

No gas ﬂow Check that the gas tank isn’t empty

Excess ﬂow safety valve has been

activated

Turn the control knob to the ‘off’ posi-

tion. Close the tank valve and disconnect

propane gas tank. Turn the control knob

to ‘high’; wait 1 minute. Turn the control

knob back to the ‘off’ position. Recon-

nect propane gas tank. Light the ﬁre unit

as indicated in the ‘To Light’ section of

this manual.

High or gusting winds Increase ﬂame to ‘high’

No gas ﬂow Check that the gas tank isn’t empty

Excess ﬂow safety valve has been

activated

See ‘sudden drop in gas ﬂow’ above

Heating unit won’t light

Burner won’t light

while using a match

Heating unit emits a lot

of black smoke

Sudden drop in gas

ﬂow

Flame blows out easily

Tabla de contenidos

Otros manuales de Chimenea al aire libre de HAMPTON BAY

HAMPTON BAY

HAMPTON BAY Hudson Manual de usuario

HAMPTON BAY

HAMPTON BAY FT-61606 Manual de usuario

HAMPTON BAY

HAMPTON BAY STONEHAM Manual de usuario

HAMPTON BAY

HAMPTON BAY FT-86147 Manual de usuario

HAMPTON BAY

HAMPTON BAY WESTBURY OFW906S Manual de usuario

HAMPTON BAY

HAMPTON BAY COLLETTE L-FT629PST-A Manual de usuario

HAMPTON BAY

HAMPTON BAY W129C Manual de usuario

HAMPTON BAY

HAMPTON BAY FT-61689 Manual de usuario

HAMPTON BAY

HAMPTON BAY ROSEMARKET XSC-1786-FP Manual de usuario

HAMPTON BAY

HAMPTON BAY Bromo 36 Manual de usuario

HAMPTON BAY

HAMPTON BAY BECKTON OFW111R-HD Manual de usuario

HAMPTON BAY

HAMPTON BAY FT-116 Manual de usuario

HAMPTON BAY

HAMPTON BAY FT-01C Manual de usuario

HAMPTON BAY

HAMPTON BAY AD364 Manual de usuario

HAMPTON BAY

HAMPTON BAY 3022FP-3PC-1 Manual de usuario

HAMPTON BAY

HAMPTON BAY TIPTON Manual de usuario

HAMPTON BAY

HAMPTON BAY FP21525 Manual de usuario

HAMPTON BAY

HAMPTON BAY FP20902 Manual de usuario

HAMPTON BAY

HAMPTON BAY TRS43GA Manual de usuario

HAMPTON BAY

HAMPTON BAY FHWS80004A Manual de usuario

HAMPTON BAY

HAMPTON BAY OFW994FRA-HD Manual de usuario

HAMPTON BAY

HAMPTON BAY COLLETTE L-FT629PST-A Manual de usuario

HAMPTON BAY

HAMPTON BAY 100 Manual de usuario

HAMPTON BAY

HAMPTON BAY FT-62480 Manual de usuario

Manuales populares de Chimenea al aire libre de otras marcas

Outdoor Plus

Outdoor Plus PISMO OPT-2448 Manual de usuario

Legacy

Legacy Fire Pit Manual de usuario

Coleman

Coleman 5055-710 Manual de usuario

Uniflame

Uniflame GAD1348HN Manual de usuario

Jensen

Jensen 300NG Manual de usuario

FEUERHAND

FEUERHAND PYRON Manual de usuario

Firegear

Firegear KWB-NG1 Guía de inicio rápido

Classics

Classics FP35077 Manual de usuario

Jensen

Jensen 1590LP Manual de usuario

Mayer Barbecue

Mayer Barbecue HEIZA MFK-220 Manual de usuario

Costway

Costway NP11018 Manual de usuario

Target

Target Foxborough Manual de usuario

Blumfeldt

Blumfeldt Merano Manual de usuario

Blooma

Blooma Brasero Ulong Manual de usuario

The Fireplace

The Fireplace JETMASTER 700 D Manual de usuario

Superior

Superior VRE4543EN Manual de usuario

Morsø

Morsø Forno Manual de usuario

dobar

dobar CONICO 35439E Manual de usuario