Generac Power Systems Mobile Power MMG320 Manual de usuario
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 1 of 4
4/12
Mobile Generator – MMG320 Specifications
ENGINE
John Deere®RG6090HF485 - turbocharged, diesel engine
oPrime - 384 hp @ 1800 rpm
oStandby - 422 hp @ 1800 rpm
o6 cylinder
o9.0 L displacement
oTier III approved
Steel, single wall fuel tank
o459 gal. capacity
o24 hr. run time – full load
oFuel tank built into skid of generator set
Fuel consumption at prime:
o100% - 17.9 gph (67.8 Lph)
o75% - 13.4 gph (50.7 Lph)
o50% - 9.0 gph (34.1 Lph)
Cooling system capable of operating at 120°F ambient
Low coolant shutdown
Radiator and oil drains plumbed to exterior
Rubber vibration dampers isolate engine/generator from frame
In-line engine block heater
Disposable air filter - paper element
Air filter restriction indicator mounted on control panel
60 Hz engine/generator
Electronic isochronous governing
GENERATOR
Marathon Electric®
oBrushless
o4 pole
oClass H insulation
Voltage regulation +/- 1% with Marathon SE350 Voltage Regulator
SYSTEM OUTPUT
Link / Reconnect Board:
oThree phase – 120 / 208V Low Wye
oThree phase – 277 / 480V High Wye
278 kW / 348 kVA – standby, three phase
256 kW / 320 kVA – prime, three phase
SYSTEM CONTROLS
Microprocessor-based controller
oBacklit, 128x64 pixel resolution display
o-40°F to 185°F operating temperature range
oThermostatically controlled LCD heater
320
MOBILEPOWER
MOBILEPOWER
MMG320 Generac Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 2 of 4
4/12
oSix LED indicators w/ lamp test
Alarm / Fault (Red)
Ready / Manual (Red)
Running (Green)
Warning (Yellow)
Ready / Auto (Green)
Supplying Load (Green)
Push buttons for easy operation
oManual or Auto Start
oEngine Start or Stop
oAlarm Cancel & Fault Reset
oScrolling Arrows for Diagnostic Information
System kW output display
Line output & frequency display
Engine diagnostic display
Oil pressure
Engine temperature
Fuel level
Battery
System hours
Running hours
kW hours
Time to service
oAlarm list – warnings / shutdowns are date & time stamped
Fuel level: warning – 15%; shutdown – 5%
Overspeed protection: shutdown – 115%
Oil pressure: warning – 25 psi; shutdown – 20 psi
Coolant temperature: warning – 220°F; shutdown – 230°F
Battery voltage: over – 15VDC; under – 11VDC
Generator over voltage: warning – 110%; shutdown – 111%
Generator under voltage: warning – 87%; shutdown – 86%
Generator over frequency: warning – 105%; shutdown – 110%
Generator under frequency: warning – 95%; shutdown – 90%
Over current shutdown
ELECTRICAL CONTROLS
Remote start / stop contacts located next to lug box
Lockable control box door with diagnostics window
Lockable lug box with safety switch
oTrips main breaker when lug door is opened
oDisables voltage regulator
Cable entry guides to the lug box
oRestricts access of foreign objects
Output ground connection lug inside lug box
1200A main breaker with shunt trip
Convenience receptacles with individual breakers (restricted use in high wye mode)
o(2) 120V 20 Amp GFCI duplex outlets (Nema 5-20R type)
o(3) 125 / 250V 50 Amp, 3 pole, 4 wire twistlock (Non-Nema 6369)
oBuck Transformer kit – Provides 120V at GFCI outlets when in 277/480V
Panel mounted rheostat for voltage adjustment - +/- 10%
MMG320 Generac Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 3 of 4
4/12
(2) 1000 CCA wet cell batteries
oBattery disconnect switch
o2A trickle battery charger
ENCLOSURE
Generac Mobile Power decals
Aluminum, sound attenuated enclosure
oUV & fade resistant, high temperature cured, white polyester powder paint
oInsulated and baffled
o68 dB(A) at 23 feet – prime power
Fully lockable enclosure including doors and fuel fill
Stainless steel hinges on doors
Emergency stop switch located on outside of enclosure
Central lifting point
Multi-lingual operating/safety decals
Document holder with operating manual including AC/DC wiring diagrams
TRAILER
DOT approved tail, side, brake, and directional lights
oRecessed rear lights
Transportation tie downs
Safety chains with spring loaded safety hooks
3” lunette ring hitch
(2) 8000 lb. axles with electric brakes
15000 lb. tongue jack with footplate
ST215/75R17.5 tubeless tires – 16 ply
WEIGHTS & DIMENSIONS
Skid mounted
Dry weight: 8039 lbs (3646 kg)
Operating weight: 11499 lbs (5216 kg)
156 x 60 x 90 in
(3.96 x 1.52 x 2.29 m)
Trailer mounted
Dry weight: 10912 lbs
(4950 kg)
Operating weight: 14372 lbs
(6519 kg)
230 x 102 x 110 in
(5.84 x 2.59 x 2.79 m)
WARRANTY
Engine and generator covered under OEM warranty – consult factory for details.
CERTIFICATIONS
CSA certified
MMG320 Generac Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 4 of 4
4/12
MMG320 Options
GENERATOR OPTIONS
PMG Generator - critical grade power quality
Super Start Generator - motor starting applications
VOLTAGE OUTPUT OPTIONS
4 position phase switch
Single phase – 120 / 240V Zig Zag
Three phase – 120 / 208V Low Wye
Three phase – 277 / 480V High Wye
Three phase – 120 / 240V Delta
Dedicated voltage configurations
Cam locks
SYSTEM CONTROLS OPTIONS
Auxiliary strobe/audible indication for soft & hard alarm conditions
COOLANT OPTIONS
60/40 Coolant - cold weather applications
ENCLOSURE OPTIONS
Fire extinguisher
Interior cabinet light
Control panel light
FUEL TANK OPTIONS
36 hr. single wall fuel tank
120% Containment
Fuel transfer pump
TRAILER OPTIONS
6 pin or 7 spade electrical connectors
Spare tire/wheel kit
HITCH OPTIONS
Adjustable height - 3” lunette ring
Tabla de contenidos
Otros manuales de Generador portátil de Generac Power Systems
Generac Power Systems
Generac Power Systems XP Series Manual de usuario
Generac Power Systems
Generac Power Systems RS5500 Manual de usuario
Generac Power Systems
Generac Power Systems RD015 Manual de usuario
Generac Power Systems
Generac Power Systems GP Series Manual de usuario
Generac Power Systems
Generac Power Systems GP7000E GP SERIES Manual de usuario
Generac Power Systems
Generac Power Systems PowerDial RS8000E Manual de usuario
Generac Power Systems
Generac Power Systems GP Series Manual de usuario
Generac Power Systems
Generac Power Systems XG 6500 Watt Series Manual de usuario
Generac Power Systems
Generac Power Systems XP Series Manual de usuario
Generac Power Systems
Generac Power Systems XP8000E Manual de usuario
Generac Power Systems
Generac Power Systems 0065141C Manual de usuario
Generac Power Systems
Generac Power Systems 005564-0 Manual de usuario
Generac Power Systems
Generac Power Systems Magnum MTT25 Manual de usuario
Generac Power Systems
Generac Power Systems 5606 Manual de usuario
Generac Power Systems
Generac Power Systems Protector Series Hoja de instrucciones
Generac Power Systems
Generac Power Systems GP8000E Manual de usuario
Generac Power Systems
Generac Power Systems GP1800 Manual de usuario
Generac Power Systems
Generac Power Systems 0065791 Manual de usuario
Generac Power Systems
Generac Power Systems 004766-0 Manual de usuario
Generac Power Systems
Generac Power Systems 7117 Manual de usuario
