Generac Power Systems Mobile Power MLG25 Manual de usuario

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 1 of 4

6/12

Mobile Lite Generator – MLG25 Specifications

ENGINE

Isuzu®4LE1NYGV-01 -naturally aspirated, diesel engine

oPrime – 32.1 hp @ 1800 rpm

o4 cylinder

o2.2 L displacement

oInterim Tier IV approved

Polyethylene fuel tank

o56 gal. capacity

o31 hr. run time – full load

o3 ½” fill port

Fuel consumption at prime:

o100% - 1.80 gph (6.81 Lph)

o75% - 1.35 gph (5.11 Lph)

o50% - 0.90 gph (3.41 Lph)

Cooling system capable of operating at 120°F ambient

Rubber vibration dampers isolate engine/generator from frame

Full flow oil filter, spin on type

Fuel filter with replaceable element

Dry type cartridge air filter

60 Hz engine/generator

GENERATOR

Marathon Electric®

oBrushless

o4 pole

oClass H insulation

Voltage regulation +/- 1% with Marathon SE350 Voltage Regulator

SYSTEM OUTPUT

3 position selector switch

oSingle phase – 120 / 240V Zig Zag

oThree phase – 120 / 208V Low Wye

oThree phase – 277 / 480V High Wye

16 kW / 16 kVA – standby, single phase

15 kW / 15 kVA – prime, single phase

20 kW / 25 kVA – standby, three phase

18 kW / 23 kVA – prime, three phase

SYSTEM CONTROLS

Microprocessor-based controller

oBacklit, 128x64 pixel resolution display

o-40°F to 185°F operating temperature range

oThermostatically controlled LCD heater

MLG25 Generac Specifications Continued:

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 2 of 4

6/12

oSix LED indicators w/ lamp test

Alarm / Fault (Red)

Ready / Manual (Red)

Running (Green)

Warning (Yellow)

Ready / Auto (Green)

Supplying Load (Green)

Push buttons for easy operation

oManual or Auto Start

oEngine Start or Stop

oAlarm Cancel & Fault Reset

oScrolling Arrows for Diagnostic Information

System kW output display

Line output & frequency display

Engine diagnostic display

Oil pressure

Engine temperature

Fuel level

Battery

System hours

Running hours

kW hours

Time to service

oAlarm list – warnings / shutdowns are date & time stamped

Fuel level: warning – 15%; shutdown – 5%

Overspeed protection: shutdown – 115%

Oil pressure: warning – 25 psi; shutdown – 20 psi

Coolant temperature: warning – 220°F; shutdown – 230°F

Battery voltage: over – 15VDC; under – 11VDC

Generator over voltage: warning – 110%; shutdown – 111%

Generator under voltage: warning – 87%; shutdown – 86%

Generator over frequency: warning – 105%; shutdown – 110%

Generator under frequency: warning – 95%; shutdown – 90%

Over current shutdown

ELECTRICAL SYSTEM AND CONTROLS

90A breaker

Convenience receptacles with individual breakers

o(2) 120V 20 Amp GFCI duplex outlets (Nema 5-20R type)

o(2) 240V 30 Amp twistlock outlets (Nema L6-30R type)

o(2) 240V 50 Amp twistlock outlets (Non-Nema 6369)

oLug terminals for single and three phase output

720 CCA wet cell battery

MLG25 Generac Specifications Continued:

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 3 of 4

6/12

ENCLOSURE

Generac Mobile Power decals

Steel, 14-gauge, sound attenuated enclosure

oUV & fade resistant, high temperature cured, white polyester powder paint

oInsulated and baffled

o68 dB(A) at 23 feet – prime power

Fully lockable enclosure

Stainless steel hinges, door latches and exterior hardware

Emergency stop switch located on front panel

License plate holder with light

Multi-lingual operating/safety decals

Document holder with operating manual including AC/DC wiring diagrams

TRAILER

DOT approved tail, side, brake, and directional lights

oRecessed rear lights

Transportation tie downs

Safety chains with spring loaded safety hooks

Single wall polyethylene fenders

2” ball hitch

2200 lb. leaf spring axle

2000 lb. tongue jack with footplate

ST205/75R15 tubeless tires – 6 ply

48” track width

WEIGHTS & DIMENSIONS

Dry weight: 1640 lbs (744 kg)

Operating weight: 2038 lbs (924 kg)

105 x 68 x 56 in

(2.67 x 1.73 x 1.42 m)

WARRANTY

Engine and generator covered under OEM warranty – consult factory for details

CERTIFICATIONS

CSA certified

MLG25 Generac Specifications Continued:

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 4 of 4

6/12

MLG25 Options

ENGINE OPTIONS

Heated fuel filter

Lower radiator hose – engine heater

Oil drain valve kit

ELECTRICAL CONTROLS OPTIONS

720 CCA gel cell battery

685 CCA gel cell battery

Battery disconnect

Battery charger – 2A trickle

VOLTAGE OUTPUT OPTIONS

Alternative receptacle panel – consult factory for configurations

COOLANT OPTIONS

60/40 Coolant – cold weather applications

ENCLOSURE OPTIONS

Interior cabinet light

Level indicator

Tamper pack

Liquid containment / Quiet pack

Lift structure

FUEL TANK OPTIONS

56 gal. fuel tank

Tethered fuel tank cap

TRAILER OPTIONS

6 pin or 7 spade electrical connectors

Outrigger package

Tube and sleeve jack

Spare tire/wheel kit

HITCH OPTIONS

2.5” lunette ring

3” lunette ring

3” HD lunette ring

2 5/16” ball

Combination hitch – 2.5” lunette ring / 2” ball

Tabla de contenidos

Otros manuales de Generador portátil de Generac Power Systems

Generac Power Systems

Generac Power Systems QT018 Manual de usuario

Generac Power Systems

Generac Power Systems GP Series Manual de usuario

Generac Power Systems

Generac Power Systems MOBILEPOWER MMG130D Manual de usuario

Generac Power Systems

Generac Power Systems G0059395 Manual de usuario

Generac Power Systems

Generac Power Systems GP2500i Manual de usuario

Generac Power Systems

Generac Power Systems 7500EXL Rated watt Extended Life Generator Manual de usuario

Generac Power Systems

Generac Power Systems 5209 Manual de usuario

Generac Power Systems

Generac Power Systems 5747 Dimensiones

Generac Power Systems

Generac Power Systems MLG8 Manual de usuario

Generac Power Systems

Generac Power Systems Mobile Power MMG130 Manual de usuario

Generac Power Systems

Generac Power Systems 17,500 WATT Manual de instrucciones

Generac Power Systems

Generac Power Systems GP Series Manual de usuario

Generac Power Systems

Generac Power Systems 0065141C Manual de usuario

Generac Power Systems

Generac Power Systems D2.5L G2 Extended Tank Hoja de instrucciones

Generac Power Systems

Generac Power Systems XG8000E Manual de usuario

Generac Power Systems

Generac Power Systems 005723-0 GP Series Manual de usuario

Generac Power Systems

Generac Power Systems SG400 Manual de usuario

Generac Power Systems

Generac Power Systems 9 kW NG Manual de usuario

Generac Power Systems

Generac Power Systems GP7000E GP SERIES Manual de usuario

Generac Power Systems

Generac Power Systems Portable Generator Manual de servicio

Generac Power Systems

Generac Power Systems 005564-0 Manual de usuario

Generac Power Systems

Generac Power Systems iX Series Manual de usuario

Generac Power Systems

Generac Power Systems GP3000i Manual de usuario

Generac Power Systems

Generac Power Systems 00940-2 Instrucciones de funcionamiento

Manuales populares de Generador portátil de otras marcas

Kohler

Kohler 20EORZ Manual de instrucciones

Powerhorse

Powerhorse 83171 Manual de usuario

HURST

HURST ML-630-SI Manual de usuario

ETQ

ETQ TG4000 Manual de usuario

Briggs & Stratton

Briggs & Stratton 40265 Guía de configuración

ConMed

ConMed 7550 Manual de usuario

Owon

Owon Waveform Generator Manual de usuario

evertz

evertz 7700 Series Manual de usuario

Power Stroke

Power Stroke PS906025 Manual de usuario

Firefly

Firefly Cygnus CYG2400/460/24 Manual de usuario

Draper

Draper PG950S Actualización de firmware

PowerBoss

PowerBoss PowerBoss Manual de usuario

SDMO

SDMO SH 4000 Manual de usuario

EINHELL

EINHELL STE 5500 Manual de usuario

Wanco

Wanco WI3000P Manual de usuario

Full Boar

Full Boar FBT-3300 Manual de usuario

Dwyer Instruments

Dwyer Instruments ASG Manual de usuario

Westinghouse

Westinghouse WH1000i Series Manual de usuario