Foc.us Gyrofocus Instrucciones de funcionamiento originales

Page 1 of 22

Gyrofocus

Design Installation & Operating Manual v.6.1 EN

Tested by OMNI-Test Laboratories, Inc. and approved to

ULC-S610-M87 (A1998), UL 737-1996 And ULC S627-00

US EPA exempt

this document was packed with the appliance.

KEEP THESE INSTRUCTIONS FOR FUTURE USE

Page 2 of 22

TABLE OF CONTENTS:

1 –INTRODUCTION

2 –SPECIFICATIONS

a) Characteristics

b) Roof outlet requirement

c) Chimney requirement

d) Structural requirement

e) Connector

f ) Fresh air intake

g) Clearances to combustibles

3 –INSTALLATION

a) Included parts, materials and required tools for installation

b) Options

c) Assembly details

4 –OPERATING INSTRUCTIONS

a) Storage/use of flammable liquids

b) Grate

c) Ashes

d) Fuel

e) Before lighting your first fire

f) Building, starting and maintaining the fire

g) Protective glove

h) Damper

5 –MAINTENANCE

a) Taking out the ashes

b) Inspection, maintenance and cleaning of the chimney

c) Surfaces

d) Replacement parts

6 –WARRANTY

Page 3 of 22

1 –INTRODUCTION:

Please read this entire manual before you install and use your focus fireplace.

Failure to follow instruction may result in property damage, bodily injury or even

death. When this room heater is not properly installed, a house fire may result.

To reduce the risk of fire, follow the installation instructions. Contact local

building or fire officials about restrictions and installation inspection

requirements in your area.

KEEP THIS MANUAL HANDY FOR EASY REFERRAL.

All WARNING and CAUTION statements will appear in bold font and upper

case letters: THEY SHOULD BE STRICTLY OBSERVED.

Thank you for choosing focus fireplaces.

Appliance designation: gyrofocus

Manufacturer: focus - atelier dominique imbert –le fort – 34380 viols le fort –

France.

2 –SPECIFICATIONS:

-NOT FOR MOBILE HOME INSTALLATION!

-DO NOT CONNECT TO ANY AIR DISTRIBUTION DUCT OR SYSTEM!

-THE AUTHORITY HAVING JURISDICTION (SUCH AS MUNICIPAL

BUILDING DEPARTMENT, FIRE DEPARTMENT, FIRE PREVENTION

BUREAU, ETC.) SHOULD BE CONSULTED BEFORE INSTALLATION TO

DETERMINE THE NEED TO OBTAIN A PERMIT.

-USING MAKE-SHIFT COMPROMISES DURING INSTALLATION CAN

CAUSE DAMAGE . SUCH INSTALLATION IS NOT COVERED UNDER

FOCUS LIMITED WARRANTY.

-WHEN THIS ROOM HEATER IS NOT PROPERLY INSTALLED, A HOUSE

FIRE MAY RESULT. TO REDUCE THE RISK OF FIRE, FOLLOW THE

INSTALLATION INSTRUCTIONS. CONTACT LOCAL BUILDING OR FIRE

OFFICIALS ABOUT RESTRICTIONS AND INSTALLATION INSPECTION

REQUIREMENTS IN YOUR AREA.

Page 4 of 22

a) Characteristics:

• Hearth 1.25m (49-7/32-inch) diameter; weight 97 kg (214 lbs)

• Flue diameter: 219 mm (8-3/8-inch) ; length custom-made

• Flue weight: 16kg per meter (10,6 lbs per foot)

• Standard plate weight of 19 kg (42 lbs)

• 3 mm (1/8-inch) thick steel

• High heat resistant matte black paint

• Stainless steel ball-bearing revolving system for a 360° rotation

• Fire screen

• Guaranteed efficiency with a minimum flue length (interior and exterior) of

4.25m (14 ')

Page 5 of 22

b) Roof outlet requirement:

c) Chimney requirement:

DO NOT CONNECT THIS UNIT TO A CHIMNEY FLUE SERVING ANOTHER

APPLIANCE!

Gyrofocus requirement: the total length of flue (inside + outside) must be 14 feet

minimum (17 feet for an installation less than 3 miles from the ocean or if a 30°

elbow is necessary).

The gyrofocus must be connected to a chimney complying with the

requirements for Type HT chimneys in the standard for Chimneys, Factory-built,

Residential Type and Building Heating Appliance, UL 103 / ULC S629. For

example, a class A insulated stainless steel flue chimney system with an 8-inch

minimum inside diameter.

Page 6 of 22

d) Structural requirement:

CAUTION: THE SUPPORT OF THE ANCHOR PLATE (ROOF STRUCTURE,

SLAB, ETC.) MUST BE SIZED IN CONGRUENCE WITH THE FIREPLACE

STATIC AND DYNAMIC CHARGES. THE SIZE CALCULATION FOR THE

SUPPORT IS NOT THE RESPONSIBILITY OF FOCUS OR ITS AFFILIATES.

IT IS YOUR RESPONSIBILITY TO CONSULT WITH AN ENGINEER OR

ARCHITECT FOR YOUR PROJECT.

e) Connector:

Connectors are all non-insulated chimney parts including focus black flue, focus

8" universal adaptor and the chimney manufacturer single wall slip adaptor.

To avoid heat traps the chimney connector shall not pass through an attic or

roof space, closet or similar concealed space, or a floor, or ceiling.

Passage through an attic, roof frame floor, or ceiling must be done using an

insulated chimney respecting all chimney manufacturer clearances.

CAUTION: PASSAGE THROUGH A WALL OR PARTITION OF

COMBUSTIBLE CONSTRUCTION IS NOT AN APPROPRIATE

INSTALLATION FOR THIS FOCUS FIREPLACE.

Refractory compound must be used to seal each connection. Please refer to

installation details in this manual.

Page 7 of 22

f) Fresh air intake:

For optimum functioning, focus recommends a fresh air intake in the room

(ideally under of the fire). We recommend deflect-O A0684 semi rigid aluminium

duct. Minimum fresh air intake size:

31 in

Ø 6"

fresh air intake

Important: this fresh air intake is compulsory when operating venting appliances

such as kitchen hoods, permanent air extractors or any appliances creating an

air depression in the habitation.

Page 8 of 22

g) Clearances to combustibles:

• Floor protection:

ROTATING VERSION REQUIRE 16 INCHES (US) OR 18 INCHES (CANADA)

OF FLOOR PROTECTION ON ALL SIDES (360°).

FIXED VERSION REQUIRE 16 INCHES (US) OR 18 INCHES (CANADA) ON

THE FRONT AND TO EXTEND 8 INCHES ON THE LEFT AND RIGHT SIDES

AS WELL AS FOR THE BACK SIDE.

USE OF PROVIDED FIREBOX INSULATOR UNDER THE GRATE

(VERMICULITE) IS COMPULSORY.

Page 9 of 22

• Clearances to walls:

CAUTION: THE DISTANCE TO A COMBUSTIBLE WALL MUST BE

MAINTAINED AT 30 inches. PROPERTY DAMAGE OR DEATH CAN OCCUR

IF THIS DISTANCE IS NOT MAINTAINED. DRYWALL PRODUCTS LINED

WITH PAPER SUCH AS SHEETROCK ARE COMBUSTIBLE. CLEARANCES

AS INDICATED FURTHER APPLY.

• Wall clearance with 360° rotation fireplace:

• Wall clearance with optional blocking mechanism:

Page 10 of 22

Important - manufacturer specifications:

-When placed close to a non-combustible wall leave a minimum of 4" for

proper ventilation. To avoid premature aging of your painted walls, only

use mineral or acrylic paints. With other paints, above clearances apply.

-Fire clearance to glass (from hearth edge): 20".

-Fire clearance to vinyl windows: refer to window technical specifications.

CLEARANCES MAY ONLY BE REDUCED BY MEANS APPROVED BY THE

REGULATORY AUTHORITY.

3 –INSTALLATION:

a) Included parts, materials and required tools for installation:

-Appliance and designated parts are the fire box, anchor plate, black steel

flue pipe, focus kit (heat protective glove, mounting gloves, can of touch-up

paint, ash removal hatch), and insulating washers.

-Required tools: drill, M8 allen key, level, screwdrivers, M12 key, scaffolding

(up to underceiling height), refractory compound.

-2 persons minimum are required for installation.

b) Options:

• custom ceiling cover disc (steel disc)

• custom anchor steel plate (inclined...)

• focus black steel flue extension

• grey paint finish

Otros manuales para Gyrofocus

Tabla de contenidos

Otros manuales de Chimenea de interior de foc.us

foc.us

foc.us Hubfocus Manual de usuario

foc.us

foc.us néofocus Manual de usuario

foc.us

foc.us emifocus hublot dv Manual de usuario

foc.us

foc.us MAGMAFOCUS Guía del usuario

foc.us

foc.us omegafocus Manual de usuario

foc.us

foc.us Slimfocus sur pied Manual de usuario

foc.us

foc.us pictofocus 1200 Manual de usuario

foc.us

foc.us nemofocus Manual de usuario

foc.us

foc.us Drumfocus M-B-C Manual

foc.us

foc.us Emifocus Manual de usuario

foc.us

foc.us BATHYSCAFOCUS Hublot Manual de usuario

foc.us

foc.us Filiofocus 1600 Manual de usuario

foc.us

foc.us Filiofocus 1600 Manual de usuario

foc.us

foc.us Bathyscafocus a hublot Manual de usuario

foc.us

foc.us filiofocus 2000 mural Manual de usuario

foc.us

foc.us Gigafocus 1500 Manual de usuario

foc.us

foc.us MEZZOFOCUS Manual de usuario

foc.us

foc.us agorafocus 630 suspendu Manual de usuario

foc.us

foc.us Gigafocus 1500 Manual de usuario

foc.us

foc.us pictofocus 860 Manual de usuario

foc.us

foc.us optifocus 1750 Manual de usuario

foc.us

foc.us PICTOFOCUS Guía del usuario

foc.us

foc.us Edofocus 631 DV Manual de usuario

foc.us

foc.us Meijifocus Guía del usuario

Manuales populares de Chimenea de interior de otras marcas

Brigantia

Brigantia 35-DVRS31N-2 Manual del propietario

Nordpeis

Nordpeis Bergen Manual de usuario

Superior

Superior BCT2536TMN Manual de usuario

Quadra-Fire

Quadra-Fire 5100I-GD-B Manual de usuario

Renaissance

Renaissance RUMFORD 1000 Manual de usuario

Lacunza

Lacunza IV-800 Manual de usuario

Baxi

Baxi 940 Instrucciones de uso

Dru

Dru Maestro 60/2 Tall RCH Manual de usuario

Diamond Fireglass

Diamond Fireglass SS-O22 Manual de usuario

HearthStone

HearthStone Windsor Bay 8830 Manual de programación

Napoleon

Napoleon ASCENT B42 Manual de usuario

Enviro

Enviro E33GI Manual de usuario

Smeg

Smeg L30 FABE Instrucciones de montaje

KEDDY

KEDDY K700 Manual de usuario

Godin

Godin 3451 Manual de usuario

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Manual de usuario

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 Manual de usuario

Desa

Desa CCFPDFT Manual de operación

foc.us Gyrofocus Instrucciones de funcionamiento originales

Manuales populares de Chimenea de interior de otras marcas