Empire Comfort Systems LS38DF-1 Guía de inicio rápido

Page 1

INSTALLATION INSTRUCTIONS

AND OWNER'S MANUAL

BLUE BAY

LOG SET MODELS

LS38DF-1

LS48DF-1

WARNING: If not installed, operated and maintained in ac-

cordance with the manufacturer's instructions, this product

could expose you to substances in fuel or from fuel combus-

tion which can cause death or serious illness.

Log sets comply with ANSI Z21.11.2 Unvented Heaters and

also comply with ANSI Z21.60 Decorative Vented Appliances

for Solid Fuel Burning Fireplaces. State or local codes may

only allow operation of log sets in a vented conguration.

Check your state or local codes.

WARNINGS

– Do not store or use gasoline or other ammable

vapors

and liquids in the vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any phone

in your building.

• Immediately call your gas supplier from neighbor’s

phone. Follow the gas supplier’s instructions.

• If you cannot reach your gas supplier, call the re de-

partment.

– Installation and service must be performed by a qualied

installer, service agency or the gas supplier.

If the information in this manual is not followed exactly,

a re or explosion may result causing property damage,

personal injury or loss of life.

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

GAS-FIRED

EMPIRE

Comfort Systems

32819-0-0913Page 2

Proper Log Placement

Log placement is critical to proper burner performance. Logs must

be correctly positioned onto the burner. The photos in this manual

show the proper pinned position for logs on this set. Owners need to

be shown proper log placement and instructed not to move the logs.

Logs must t rmly onto the burner when positioned as shown in

the photos. Misformed logs or logs with sloppy pin holes must be

replaced.

Proper Primary Airow into Burner

For proper burner operation and ame appearance, the ow of

primary air into the venturi tube, located on the rear of the burner,

must not be reduced. This ow of air is reduced if dirt, lint or other

obstructions build-up around or inside the venturi. Any obstruction

in the venturi tube area must be removed. The ow of air into the

venturi is also reduced if the gas orice isn’t centered in the venturi

inlet and/or is not aligned with the venturi. Any misalignment of the

burner orice may be corrected by bending the shutter cap holding

the orice to the inlet of the venturi tube.

Ceiling Fans, Portable Fans or Logs Installed Near Cold Air

Returns

Ceiling fans or oscillating oor type fans need to be monitored

during the operation of vent-free logs. If the air blows directly into

the ame causing it to impinge on the log set, or rebox, it should be

turned off or redirected. Ceiling fans could be reversed to possibly

eliminate ame impingement, and the oor fan could be redirected.

Upon installation, be aware of any cold air returns or vents in the

proximity of the log set. Any draft created around a vent-free log

set can cause the ame to impinge on the log and create a sooting

situation.

WARNING: Do not allow fans to blow directly into the replace.

Avoid any drafts that alter burner ame patterns.

WARNING: Do not use a blower insert, heat exchanger insert or

other accessory not approved for use with this heater.

Candles

Avoid the use of scented or decorative candles while the log set is

in operation. Candles produce a residue in the air that creates a

soot like substance. Burning candles while the log set is operating

magnies the problem. It should be noted that candles, in general,

produce soot. The amount of time burned and the quantity of candles

burned will determine the amount of soot produced and deposited.

Make Owners Aware of Proper Log Set Operation

Properly installed and properly maintained log sets do not deposit

soot on the logs. If users see soot appear on a log, call for service.

Do not continue to operate the log set.

Qualied Installing Agency

Installation and replacement of gas piping, gas utilization

equipment or accessories and repair and servicing of equip-

ment shall be performed only by a qualied agency. The term

"qualied agency" means any individual, rm, corporation,

or company that either in person or through a representa-

tive is engaged in and is responsible for (a) the installation,

testing, or replacement of gas piping or (b) the connection,

installation, testing, repair, or servicing of equipment; that is

experienced in such work; that is familiar with all precautions

required, and that has complied with all the requirements of

the authority having jurisdiction.

The installation must conform with local codes or, in the

absence of local codes, with the National Fuel Gas Code,

ANSI Z223.1/NFPA54.*

*Available from the American National Standards Institute, Inc. 11 West

42nd St., New York, N.Y. 10018.

State of Massachusetts: The installation must be made

by a licensed plumber or gas tter in the Commonwealth

of Massachusetts.

Sellers of unvented propane or natural gas-red supple-

mental room heaters shall provide to each purchaser a

copy of 527 CMR 30 upon sale of the unit.

IMPORTANT INSTALLATION GUIDELINES

GENERAL INFORMATION

32819-0-0913 Page 3

LOG IDENTIFICATION

DESCRIPTION PART NUMBER LOG IMAGE

LS38DF LS48DF

REAR LOG 30901 32823

RIGHT FRONT LOG 30904 30904

LEFT FRONT LOG 30902 32824

LEFT BRANCH 30903 30903

32819-0-0913Page 4

Before you begin: Do not handle these logs with your bare

hands! Always wear gloves to prevent skin irritation. After

handling logs, wash your hands gently with soap and water.

All Logs

Properly positioning the logs is critical to the safe and clean

operation of this heater. Sooting and other problems may

result if the logs are not properly and rmly positioned in the

appliance.

WARNING

Failure to position the parts in accordance with the dia-

grams and instructions below or failure to use only parts

specically approved for use with this heater may result in

property damage or personal injury.

Index Letter Description Part Number

LS38DF LS48DF

A Rear Log 30901 32823

B Right Front Log 30904 30904

C Left Front Log 30902 32824

D Left Branch 30903 30903

E Log Plate 30437 32821

32819-0-0913 Page 5

INSTALLATION

1. Remove glass front from replace by lifting the glass front

up, sliding it to the right, and then carefully angling left side

out of the slots. See Figures 1 - 4.

TOP VIEW

Figure 4

Figure 1

Figure 2

Figure 3

2. Install locator plate over the burner cover assembly.

NOTE: TOP OF FIREBOX

REMOVED FOR CLARITY.

Figure 5

32819-0-0913Page 6

3. Place Rear Log onto the rear two pins on the locator plate.

TOP VIEW

FRONT VIEW

32819-0-0913 Page 7

4. Place Right Front Log onto the two front right pins on the locator plate.

TOP VIEW

FRONT VIEW

32819-0-0913Page 8

5. Place Left Front Log onto the middle left front pin on the locator plate. The left end of the log should angle up and will rest against

the glass.

TOP VIEW

FRONT VIEW

32819-0-0913 Page 9

6. Place the Left Branch on the left pin on the locator plate and the pin on the Left Front Log.

TOP VIEW

FRONT VIEW

32819-0-0913Page 10

TOP VIEW

7. Replace the glass front into the replace by placing the right

side into the slots in the rebox. Carefully angle in the left side

of the glass and then slide the glass to the left. Settle the glass

into the slots by gently lowering it.

TOP VIEW

Figure 7

Figure 6

Figure 9

Figure 8

Use a clean cloth to wipe away any ngerprints on the glass

before lighting the replace. The glass should be cleaned with an

ammonia free cleaner. Ammonia can etch and stain glass when

heated.

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Chimenea de interior de Empire Comfort Systems

Empire Comfort Systems

Empire Comfort Systems VFFB-36D Manual de usuario

Empire Comfort Systems

Empire Comfort Systems SELECT VFS32FB0F-6 Guía de inicio rápido

Empire Comfort Systems

Empire Comfort Systems DVP42DP31N-2 Guía de inicio rápido

Empire Comfort Systems

Empire Comfort Systems pmn Instrucciones de instalación

Empire Comfort Systems

Empire Comfort Systems INTERMITTENT PILOT DVCD36FP70 Manual de usuario

Empire Comfort Systems

Empire Comfort Systems DVCP36(PP Guía de inicio rápido

Empire Comfort Systems

Empire Comfort Systems MILLIVOLT 3 Series Guía de inicio rápido

Empire Comfort Systems

Empire Comfort Systems DVP36FP30N-5 Guía de inicio rápido

Empire Comfort Systems

Empire Comfort Systems Tahoe DVP36PP32EN-1 Guía de inicio rápido

Empire Comfort Systems

Empire Comfort Systems VFD32FB0L-1 Manual de usuario

Empire Comfort Systems

Empire Comfort Systems DVP42FP3(0 Guía de inicio rápido

Empire Comfort Systems

Empire Comfort Systems EMBF11S Series Manual de usuario

Empire Comfort Systems

Empire Comfort Systems Mantis Manual de usuario

Empire Comfort Systems

Empire Comfort Systems LS55CD-1 Guía de inicio rápido

Empire Comfort Systems

Empire Comfort Systems superb CHBR-16-3 Guía de inicio rápido

Empire Comfort Systems

Empire Comfort Systems LTH1118ST-1 Manual de usuario

Empire Comfort Systems

Empire Comfort Systems DVP42DP31-2 Guía de inicio rápido

Empire Comfort Systems

Empire Comfort Systems VFP32BP20LN-1 Guía de inicio rápido

Empire Comfort Systems

Empire Comfort Systems Boulevard VFLB60FP90N-1 Guía de planificación

Empire Comfort Systems

Empire Comfort Systems DVCT36CBP95KN-2 Guía de planificación

Empire Comfort Systems

Empire Comfort Systems VFP28IN3 series Guía de inicio rápido

Empire Comfort Systems

Empire Comfort Systems DVLXG75BP90N-1 Instrucciones de montaje

Empire Comfort Systems

Empire Comfort Systems Boulevard LS41THF-1 Guía de inicio rápido

Empire Comfort Systems

Empire Comfort Systems VFP20IN30L10N-1 Guía de inicio rápido

Manuales populares de Chimenea de interior de otras marcas

Brigantia

Brigantia 35-DVRS31N-2 Manual del propietario

Nordpeis

Nordpeis Bergen Manual de usuario

Superior

Superior BCT2536TMN Manual de usuario

Quadra-Fire

Quadra-Fire 5100I-GD-B Manual de usuario

Renaissance

Renaissance RUMFORD 1000 Manual de usuario

Lacunza

Lacunza IV-800 Manual de usuario

Baxi

Baxi 940 Instrucciones de uso

Dru

Dru Maestro 60/2 Tall RCH Manual de usuario

Diamond Fireglass

Diamond Fireglass SS-O22 Manual de usuario

HearthStone

HearthStone Windsor Bay 8830 Manual de programación

Napoleon

Napoleon ASCENT B42 Manual de usuario

Enviro

Enviro E33GI Manual de usuario

Smeg

Smeg L30 FABE Instrucciones de montaje

KEDDY

KEDDY K700 Manual de usuario

Godin

Godin 3451 Manual de usuario

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Manual de usuario

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 Manual de usuario

Desa

Desa CCFPDFT Manual de operación