Electrolux TCW 1990 Manual de usuario

820 41 72 58

USER

USERs MANU

s MANUAL -

AL - NO

NOTICE DUTILIS

TICE DUTILISA

ATION -

TION -

MANU

MANUAL DEL USU

AL DEL USUARIO

ARIO

TCW 1990

ICE LINING REFRIGERATOR FREEZER GB

REFRIGERATEUR / CONGELATEUR

A PAROI REFRIGERANTE - ILR

FRIGORIFICO/CONGELADOR

REVESTIDO DE HIELO

USER MANUAL

ICE LINING REFRIGERATOR FREEZER

Handle

Lid ice accu

Rubber gasket

Data label

Thermometer

850

1050

630

1465

Compressor

compartment

Pilot lamp ON

Thermostat for

refrigerator function

Drain plug

Locking device

Interior wall

1. GENERAL INFORMATION ......................................................page 4

2. INSTALLATION .....................................................................page 5-9

3. PREPARATIONS....................................................................page 10-11

4. USE THE APPLIANCE ...........................................................page 12

5. DEFROSTING & CLEANING ..................................................page 13-14

6. PERIODIC OBSERVATIONS/CHECKS/ACTIONS .....................page 15

7. TROUBLE SHOOTING ...........................................................page 16-17

(A) ILR not working

(B) Compressor is working,

but cabinet temperature is higher than normal

(D) Abnormal noise in the ILR

8. SHUTTING DOWN ................................................................page 18

9. STORAGE OF VACCINES IN THE ILR .....................................page 18

INDEX

THE ILR

One of the most important links in the cold-chain is Ice

Lining Refrigerator (ILR). This is a unit which operates

on the principle of vapour compression system,

similar to any conventional compressor type

refrigerator operating on 1 15 or 230 volts, A.C. mains

supply. However, the ILR has top opening door to

prevent loss of cold air during door opening.

ICE LINING

The Icelined Refrigerator and Freezer has a icebank

inside the cabinet. The ice bank consists of frozen

icepacks during its operation. During periods of

power failure and load procedures, the ice bank acts

as cold storage to protect the vaccines. The ice bank

keep the temperature is not above +8°C for 30 hours.

HOLD OVER TIME

In case of power failure this unit is capable to hold the

temperature (if all the ice-packs are installed) inside

the Refrigeration compartment between 2 and 8°C

under following conditions.

Ambient temperature: Minimum hold over:

32°C 30 hours

43°C 20 hours

POWER SUPPLY

The ILR is fitted with heavy duty compressor which

requires low starting current and can also operate

within a range of voltage variations.

E.g. if the normal operating voltage is 230 volts, 50

Hz., A.C., it can work even when the supply voltage

occasionally go as low as 150 volts or as high as

280 volts.

THERMOMETER

To enable to measure the temperature inside the

cabinet without opening the lid, a thermometer is

provided with its dial on the front side. This makes

monitoring of the vaccine temperature easy.

LOCKING SYSTEM

The ILR is equipped with a lock, operated with a

key.

POWER-SUPPLY ARRANGEMENT

For smooth functioning of the ILR it is advisable to

connect the same to a 15 Amps power plug socket

outlet, wired from the mains with PVC insulated

cables of minimum 2.5 mm section of Aluminium

(see also page 5 under `Installation'). The larger

size of the plug and socket decreases the contact

resistance which in turn reduces voltage drop and

provides an easy path for the current.

Safety of the personnel and the equipments can not

be guaranteed unless the earth wire (green/yellow)

of the cord is really earthed. It is advisable to have

the earth connections to the socket checked by a

competent electrician.

VOLTAGE STABILIZER

Though the ILR is capable of operating within a

wide range of voltage variations, for extra safety one

separate Automatic Voltage Stabilizer should be

used with it.

1. GENERAL INFORMATION

Check the manufacturer's plate, at the back of the ILR

and make sure that the ILR has correct voltage for

local supply, i.e. 1 15 or 230 volts (fig. 1).

CAUTION

Connecting the equipment to wrong supply

voltage may damage it.

If you have received equipments of wrong voltage

ratings, notify concerned authorities and keep the

equipments repacked.

The ILR is to be installed in a well ventilated room,

avoiding direct sunshine or any other source of heat.

Power supply socket (15 amps socket with switch,

fuse and mains indicator lamp is advisable) should be

available nearest to the place of installation of the ILR.

Unscrew and remove the screws holding the side

cover of the compressor compartment on the right

hand side of the ILR and remove carefully the side

cover (fig. 2)

2. INSTALLATION

Fig. 2.

Fig. 1.

EXAMINE the compressor compartment (fig. 3;

Check carefully for any damage, dislocation or

looseness etc. of the components, specially at

locations A, B. C, and D as below and rectify if

necessary.

LOCATION A (fig. 4)

Check that all 4 mounting brackets of the compressor

are in place and secured.

2. INSTALLATION

Fig. 4.

Fig. 3.

LOCATION B (fig. 5)

Check that the incoming electrical connections of the

power supply cord to the terminal strip are tight.

LOCATION C (fig. 6)

Check that the outgoing electrical connections from

the terminal strip are tight.

LOCATION D (fig. 7)

Check that the mounting brackets of the fan are tight

and also that the fan blades are free to rotate.

2. INSTALLATION

Fig. 5.

Fig. 6.

Fig. 7.

Refit side cover of the compressor compartment into

position refixing the screws holding the side cover (fig. 8)

INSTALL firmly the ILR on a level

floor, preferably on wooden

blocks or on a wooden platform to

protect it from damp and dirt.

(fig. 5)

Leave sufficient space on all sides

of the ILR, keep it away from the

walls for good circulation of air

around it, see below:

Back and left side should be

minimum 3 cm away from the

walls (fig. 9a)

Hinges can be pushed against the

wall

Right side should be minimum

10 cm away from the wall (fig. 9b)

The ILR has 4 supporting legs. If

the ILR is not in a level and stable

position, adjust this by adding

wooden blocks or similar under

the legs.

2. INSTALLATION

Fig. 8.

Fig. 9.

Fig. 9a

Fig. 9b

Connect the leads of the power supply cord to a

suitable 3-pin plug as shown below (fig. 10)

Lead of cord Pin of plug

Green/yellow Earth

Blue Neutral

Brown Phase

CAUTION:

DO NOT CONNECT THE ILR TO POVER SUPPLY

NOW

2. INSTALLATION

Fig. 10.

Open the lid of the appliance. Unscrew the the lid

ballast container. (fig. 11)

Unscrew the cap of the lid ice accu and fil it with clean

water.

Unscrew the 3 frame screws and remove the plastic

Refrigerator innerliner. (fig. 12)

Remove all 36 ice-packs from the ice bank and the 5

ice-packs in the refrigeration compartment.

Plug in the appliance for test. The green lamp

indicates that the unit is under power. (fig. 13)

Check in the compressor compartment that the

compressor starts and the fan on the left side is running.

Check that the blower in the bottom of the dividing wall

is running. Check by pushing with your fingers to the

flap thermostat, if a free moving to open and close the

cold air channel is granted.

3. PREPARATIONS

Fig. 11.

Fig. 12.

Fig. 13.

Otros manuales para TCW 1990

Otros manuales de Refrigerador de Electrolux

Electrolux

Electrolux LRB3DE18S Manual de usuario

Electrolux

Electrolux ICON Designer E23BC68JSS Manual de usuario

Electrolux

Electrolux Icon E23CS78GSS Manual de usuario

Electrolux

Electrolux 807650601 Manual de usuario

Electrolux

Electrolux ER 7535 I Guía rápida

Electrolux

Electrolux EI24RD65HS - 6.0 cu. Ft. Double Drawer... Manual de usuario

Electrolux

Electrolux Juno JRZ90122 Manual de usuario

Electrolux

Electrolux IG1235SN Manual de usuario

Electrolux

Electrolux Icon E32AR75JPS Manual de usuario

Electrolux

Electrolux ER3260BN Manual de usuario

Electrolux

Electrolux ER 8126/1 B Manual de usuario

Electrolux

Electrolux LNT6ME36U2 Manual de usuario

Electrolux

Electrolux ER 8034 I Manual de usuario

Electrolux

Electrolux ERN 19500 Manual de usuario

Electrolux

Electrolux ER 6822 D Manual de usuario

Electrolux

Electrolux JUNO JKG 9498 Manual de usuario

Electrolux

Electrolux ERN 16300 Manual de usuario

Electrolux

Electrolux ICON Professional E32AR75JP Manual de usuario

Electrolux

Electrolux EI23CS55GS - 22.5 cu. ft. Refrigerator Manual de usuario

Electrolux

Electrolux ER 3396B Manual de usuario

Electrolux

Electrolux TC15013 Manual de usuario

Electrolux

Electrolux ENN 26800 Manual de usuario

Electrolux

Electrolux LNC7ME32W1 Manual de usuario

Electrolux

Electrolux RF617 Manual de instrucciones

Manuales populares de Refrigerador de otras marcas

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Manual de usuario

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Manual de usuario

Sharp

Sharp SJ-BA31IEXW2-EU Manual de usuario

CORBERO

CORBERO CC2300MCW Manual de usuario

KitchenAid

KitchenAid 2205264 Manual de usuario

Stengel

Stengel KU 1101 A++ Manual de usuario

NEFF

NEFF KI181 Series Manual de usuario

Hoshizaki

Hoshizaki Reach-In Manual de usuario

Amana

Amana ASD2524VES00 Manual de usuario

BOMANN

BOMANN KGC 213 Manual de usuario

Danby

Danby DAR044A1SLDD Instrucciones de montaje

Samsung

Samsung RF323TE Manual de usuario

Beko

Beko CSA31022 Manual de usuario

IKEA

IKEA FROSTIG C 185 E Manual de usuario

True

True TS-28 Manual de usuario

Frigidaire

Frigidaire FSC23R5DW9 Manual de usuario

Beko

Beko LSP4579W Manual de usuario

Teledyne

Teledyne 6712FR and Instrucciones de funcionamiento