Electrolux Eurocombi Manual de usuario

SERVICE MANUAL

REFRIGERATION

ELETTRODOMESTICI S.p.A. 599 34 04-61

VIA GIARDINI CATTANEO, 3 2001-01-15

I - 33170 PORDENONE (ITALY) EN/SERVICE/AA

Fax (0434) 394096

EUROCOMBI

This publication updates and replaces the previous.

Eurocombi 2/32

Eurocombi 3/32

CONTENTS

1. Introduction

1.1 Presentation page 5/33

1.2 Eurocombi: total nofrost page 7/33

2 Characteristics

2.1 Dimensions and volumes page 8/33

2.2 Characteristics page 8/33

2.3 Circuit diagram page 10/33

3 Components

3.1. Main components page 11/33

3.2. Electronic module page 13/33

3.2.1. CTB – Control board page 14/33

3.2.2. PWB – Power board page 14/33

3.2.3. Connection box page 14/33

3.3. Fans page 15/33

3.3.1. Operation with doors closed page 15/33

3.3.2. Door aperture with compressor on page 16/33

3.3.3. Door aperture with compressor off page 16/33

3.4. Heating elements page 17/33

3.5. NTC sensors page 17/33

3.6. Overheating protection page 17/33

3.7. Evaporator page 18/33

3.8. Condenser page 18/33

3.9. Flap-operated mechanical thermostat page 18/33

4. Operation

4.1. Normal operation page 19/33

4.2. Defrosting page 19/33

5. Control panel

5.1. Switching the appliance on and off page 20/33

5.2. “Door open” alarm page 21/33

5.3. “Temperature” alarm page 21/33

5.4. Rapid freezing page 21/33

5.5. NTC sensors failure page 22/33

6. Service mode

6.1. Activation page 23/33

6.2. Signalling of faults page 23/33

6.3. Separate activation of loads page 24/33

6.4. Checking the door switches page 24/33

6.5. Disactivation page 24/33

6.6 Days counter page 24/33

7. Demo mode

7.1. Selecting Demo mode page 25/33

7.2. Main functions page 25/33

7.3. Exiting Demo mode page 25/33

8. Accessibility

8.1. Flap-operated thermostat page 26/33

8.2. Control board (CTB) page 28/33

8.3. Freezer compartment page 29/33

8.4. Glass shelves page 32/33

8.5. Air inlets page 32/33

8.6. Power board (PWB) page 33/33

Eurocombi 4/32

Eurocombi 5/32

1. INTRODUCTION

1.1. Presentation

The EUROCOMBI is a new free-standing combined refrigerator (with a refrigerator compartment in the upper

section and the freezer in the lower section) produced in the Fuenmayor factory in Spain.

This appliance features a single compressor and a total no-frost system. The operating cycles are controlled

electronically. The temperature inside the refrigerator compartment is controlled by a flap-operated

mechanical thermostat.

The Eurocombi range consists of eight models, with ALFA or DELTA stylings. All models are arched doors.

The differences between the various models consist in the size of the refrigerator and freezer compartments

and therefore in the number of shelves and drawers.

Eurocombi 6/32

Markets: UK, Spain, France, Germany, Italy, Sweden, Norway, Finland, Est Europe.

Brands: Zanussi, Electrolux, AEG, AME, Frigidaire, Corbero’.

Eurocombi 7/32

1.2. Eurocombi: total no-frost

The Eurocombi is a total no-frost appliance, and as such its operation is based exclusively on the battery

evaporator in the freezer compartment, which cools the air; the air is circulated by the fan.

A duct embedded in foam channels the cold air into the refrigerator compartment, where the flap-operated

mechanical thermostat regulates the flow of cold air and thus the temperature inside the refrigerator

compartment. The air returns to the freezer compartment through two outlets located at each side of the

vegetable drawer.

Operation of the compressor (switching on and off) is governed by an NTC sensor located externally (in air)

in the freezer compartment. The electronic system periodically defrosts the ice which accumulates on the

evaporator battery; defrosting terminates when a second NTC sensor, positioned in contact with the

evaporator battery, detects a temperature of +15°C.

The main characteristic of the control system used in the Eurocombi is the fact that the defrost operating

cycles are not of fixed duration, but calculated on the basis of the time required for defrosting (see section 4,

page 16).

Eurocombi 8/32

2. CHARACTERISTICS

2.1. Dimensions and volumes

The models in the Eurocombi range are numbered from 1 to 9 (with the exception of number 7, which has

been eliminated).

Model no. 1 2 3 4 5 6 8 9

height* mm 1950 1800 1800 1800 1650 1650 1750 1950

width mm 595 595 595 595 595 595 595 595

depth mm 664 664 664 664 664 664 664 664

gross vol. freezer liters 94 126 94 157 94 126 94 126

gross vol. fridge liters 267 193 230 156 193 155 217 230

total gross vol liters 361 319 324 313 287 281 311 336

*with top panel: +60mm

2.2. Technical characteristics

Performance:

Refrigerator from 1°C to 10 °C

Freezer 4 stars

Energy class C

Cilmate class SN, N, T,ST

Coolant R600a

Compressor: HPT12 high efficiency (N, SN class)

Power supply V/Hz 220-240/ 50

Rated power HP 1/5

Power absorption W 135

Current (normal / starting) A 0.6/8

Output power kcal/h 141

Resistance (normal / starting) ohm 17.8/27

Compressor: HPT14 high efficiency (T, ST class)

Power supply V/Hz 220-240/ 50

Rated power HP 1/5

Power absorption W 143

Current (normal / starting) A 1.1/6.4

Output power kcal/h 162

Resistance (normal / starting) ohm 11.6/19

Evaporator fan:

Voltage (DC) V 21 (class N) , 24 (class T)

Power W 3

Condenser fan:

Voltage (DC) V 21 (class N) , 24 (class T)

Power W 2.5

Eurocombi 9/32

Defrosting heater:

Power at 230V W 250

Drainage duct heater:

Power at 230V W 43.5

Safety overheating switches:

aperture °C 55

closure °C 45

Settings for refrigerator compartment:

Position of

thermostat knob

Cut-in Cut-out

stand by* Flap closed Flap closed

3 +10 °C +7°C

5 +7°C +4°C

7 +4°C +1°C

* in this position, the thermostat completely blocks the passage of cold air coming from the freezer

compartment.

Settings for freezer compartment:

Position of

thermostat knob

Cut-in Cut-out Alarm

0 -15 °C -16°C -12°C

3 -18 °C -19°C -12°C

5 -21°C -22°C -12°C

7 -23°C -24°C -12°C

Normal operating times:

pre-determined** hrs 6

minimum hrs 4

maximum hrs 25

** A six-hour operating cycle is performed each time the appliance is switched on.

Defrosting:

standard time minutes 22

maximum time minutes 30

temp. for end of defrosting °C +15

Eurocombi 10/32

2.3. Circuit diagram

1 power supply; 2 compressor; 5 fan; 9 defrosting heater; 11 drainage duct heater; 13 refrigerator light; 16

freezer switch; 26 safety switch (+55°C); 28 condenser; 41 electronic circuit board; 56 air sensor for

refrigerator (optional); 57 external (in air) NTC sensor; 59 NTC sensor for evaporator.

Tabla de contenidos

Otros manuales de Refrigerador de Electrolux

Electrolux

Electrolux ERB 3023 Guía rápida

Electrolux

Electrolux ER7322D Guía rápida

Electrolux

Electrolux ERG29610 Manual de usuario

Electrolux

Electrolux EN3850DOX Manual de usuario

Electrolux

Electrolux EAL6240AOU Manual de usuario

Electrolux

Electrolux SB339NFCN Manual de usuario

Electrolux

Electrolux ER 7526/1 B Manual de usuario

Electrolux

Electrolux ENN2754AOW Manual de usuario

Electrolux

Electrolux SB26910 Manual de usuario

Electrolux

Electrolux ERY1201FOW Manual de usuario

Electrolux

Electrolux EI28BS80KS Instrucciones de montaje

Electrolux

Electrolux ERC33430W Manual de usuario

Electrolux

Electrolux EI26SS30JB1 Manual de usuario

Electrolux

Electrolux EK242S Manual de usuario

Electrolux

Electrolux ERD18001W8 Manual de usuario

Electrolux

Electrolux ER 7824 D Manual de usuario

Electrolux

Electrolux EI26SS30J W Manual de usuario

Electrolux

Electrolux EI23CS55GB4 Manual de usuario

Electrolux

Electrolux ERC 39392 S Manual de usuario

Electrolux

Electrolux ER2510C Guía rápida

Electrolux

Electrolux IK2240CR Manual de usuario

Electrolux

Electrolux ER8509BX Manual de usuario

Electrolux

Electrolux TK 137 Manual de usuario

Electrolux

Electrolux LXB1SF11W0 Manual de usuario

Manuales populares de Refrigerador de otras marcas

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Manual de usuario

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Manual de usuario

Sharp

Sharp SJ-BA31IEXW2-EU Manual de usuario

CORBERO

CORBERO CC2300MCW Manual de usuario

KitchenAid

KitchenAid 2205264 Manual de usuario

Stengel

Stengel KU 1101 A++ Manual de usuario

NEFF

NEFF KI181 Series Manual de usuario

Hoshizaki

Hoshizaki Reach-In Manual de usuario

Amana

Amana ASD2524VES00 Manual de usuario

BOMANN

BOMANN KGC 213 Manual de usuario

Danby

Danby DAR044A1SLDD Instrucciones de montaje

Samsung

Samsung RF323TE Manual de usuario

Beko

Beko CSA31022 Manual de usuario

IKEA

IKEA FROSTIG C 185 E Manual de usuario

True

True TS-28 Manual de usuario

Frigidaire

Frigidaire FSC23R5DW9 Manual de usuario

Beko

Beko LSP4579W Manual de usuario

Teledyne

Teledyne 6712FR and Instrucciones de funcionamiento