ECR International CCB-150 Manual de instrucciones

cod. 3541F061 - 01/2016

COMBI WALL MOUNTED GAS BOILER

INSTALLATION, OPERATION & MAINTENANCE MANUAL

CHAUDIÈRE À GAZ MURALE COMBI

MANUEL D’INSTALLATION, D’UTILISATION ET D’ENTRETIEN

Model

Modèle

CCB-150

Manufacturedfor:

ECRInternational,Inc.

2201 Dwyer Avenue, Utica NY 13501

web site: www.ecrinternational.com

Réf. 240010632, Rév. D [20/01/2016]

Figure 1 - Overall Dimensions

Rear View

Bottom View

1 = 1“ MPT Supply Water to Heating

System (Out)

2 = 3/4” MPT Tap Water Outlet

3 = 3/4” FPT Gas Inlet

4 = 3/4” MPT Tap Water Inlet

5 = 1” MPT Return Water

From

Heating System (IN)

DIMENSIONS

Top View

Side View Front View

(85 mm) (76 mm) (55 mm) (50 mm) (80 mm) (104 mm)

(64 mm)

(196 mm)(35

mm)

(Ø22.5 mm)

Ø0 57/64 in 13/8 in 7 23/32 in

2 33/64 in

3 11/32 in 2 63/64 in

2 11/64 in 1 31/32 in

3 5/32 in 4 3/32 in

(179 mm)

3/64 in

(127 mm)

5431 2

TABLE OF CONTENTS

1 - Introduction................................................................................................................... 4

2 - Important Safety Information........................................................................................... 5

3 - General View And Main Components ................................................................................. 6

4 - Locating Boiler ............................................................................................................... 9

5 - Hydronic Piping ............................................................................................................ 11

6 - Combustion Air And Vent Piping - Category I (Chimney Vent) ............................................ 15

6 - Combustion Air And Vent Piping Of Direct Vent And Category III ......................................... 17

6 - Combustion Air And Ventilation....................................................................................... 19

7 - Gas Supply Piping......................................................................................................... 22

8 - Electrical Connections ................................................................................................... 23

9 - Start Up Procedure ....................................................................................................... 24

10 - Operating Instructions................................................................................................. 26

11 - General Maintenance And Cleaning................................................................................ 33

12 - Ratings And Capacities ................................................................................................ 34

13 - Trouble Shooting......................................................................................................... 37

Wiring diagram ................................................................................................................. 38

Repair Parts List ................................................................................................................ 39

1 - INTRODUCTION

1.1 Designated Use

• Hot water heating boiler.

• Indoor installation.

• Closet or alcove installation.

• Catagory I or III Venting.

• Direct vent boiler.

• )RUXVHZLWKQDWXUDOJDVRUOLTXH¿HGSHWUROHXPJDVHV

(LP/propane).

• Directly heat potable water. Indirect heating is

acceptable.

1.2 The unit MUST NOT:

• Heat water with non-hydronic heating system chemicals

p r e s e n t ( e x a m p l e , s w i m m i n g p o o l w a t e r ) .

• Exceed 185°F (85°C) system design temperature.

• Exceed MWAP 43.5 PSIG

1.3 Operational Features

• Modulating: 3-1 turn down.

• Integral Dual Limit.

,QIRUPDWLRQDQGVSHFL¿FDWLRQVRXWOLQHGLQWKLVPDQXDOLQHIIHFWDWWKH

WLPHRISULQWLQJRIWKLVPDQXDOECR International, Inc.UHVHUYHVWKHULJKWWR

GLVFRQWLQXHFKDQJHVSHFL¿FDWLRQVRUV\VWHPGHVLJQDWDQ\WLPHZLWKRXW

QRWLFHDQGZLWKRXWLQFXUULQJDQ\REOLJDWLRQZKDWVRHYHU

2 - IMPORTANT SAFETY INFORMATION

NOTICE

Used to address practices not related to

personal injury.

CAUTION

Indicates a hazardous situation which, if not

avoided, could result in minor or moderate

injury.

WARNING

Indicates a hazardous situation which, if not

avoided, could result in death or serious injury.

DANGER

Indicates a hazardous situation which, if not

avoided, WILL result in death or serious injury.

This is the safety alert symbol. Symbol alerts you to

potential personal injury hazards. Obey all safety messages

following this symbol to avoid possible injury or death.

2.2 Become familiar with symbols identifying

potential hazards.

WARNING

Fire, explosion, asphyxiation and electrical

shock hazard. Improper installation could

result in death or serious injury. Read this

manual and understand all requirements

before beginning installation.

2.3 Installation shall conform to requirements of

authority having jurisdiction or in absence of such

requirements:

•

United States

• National Fuel Gas Code, ANSI Z223.1/NFPA 54

• National Electrical Code, NFPA 70.

• Canada

• Natural Gas and Propane Installation Code,

CAN/CSA B149.1.

• Canadian Electrical Code, Part I, Safety Standard

for Electrical Installations, CSA C22.1

2.4 Requirements for Commonwealth of

Massachusetts:

Boiler installation must conform to Commonwealth of

Massachusetts code 248 CMR which includes but is not

limited to:

• ,QVWDOODWLRQE\OLFHQVHGSOXPEHURUJDV¿WWHU

2.5 CSD-1 Requirements:

Where required by the authority having jurisdiction, the

installation must conform to the Standard for Controls and

Safety Devices for Automatically Fired Boilers, ANSI/ASME

CSD1.

2.1 General

%RLOHULQVWDOODWLRQVKDOOEHFRPSOHWHGE\TXDOL¿HGDJHQF\

See glossary for additional information.

Figure 2 - Component Listing

3 - GENERAL VIEW AND MAIN COMPONENTS

Item

1XPEHU

Description

5Sealed Chamber

7Gas Inlet

8Domestic Hot Water (DHW) Outlet

9Domestic Cold Water (DHW) Inlet

10 Supply System

11 System Return

16 Modulating Fan

19 Combustion Chamber

20 Burner Assembly

26 Combustion Chamber Insulation

27 Copper Heat Exchanger

28 Exhaust Manifold

29 Exhaust Outlet Manifold

32 Heating circulating pump

36 Automatic Air Vent

39 DHW Flow Regulator

42 DHW Temperature Sensor

44 Gas Valve

81 Ignition and Detection Electrode

95 3 Way Diverter Valve

114 Water Pressure Switch

136 Flow Meter

194 DHW Flate Plate Heat Exchanger

278 Double Sensor - High Limit NTC

297 Air Pressure Switch

364 Condensate Union

Unit Weight - 74 LBS (33.5 kg)

Shipping Weight - ~ 78 LBS (35.5 kg)

3 - GENERAL VIEW AND MAIN COMPONENTS

Remove Boiler Jacket

Unscrew screws (A).

5DLVH-DFNHWXSDQGRIIERLOHU6HH¿JXUH

Figure 3 -DFNHW5HPRYDO6FUHZ

Locations

Figure 4 - Pivot Jacket and Raise to Remove

WARNING

Fire, explosion, asphyxiation and electrical

shock hazard. Disconnect electrical power

supply and turn off gas at shutoff valve before

attemting to remove boiler jacket. Failure to

follow these instructions could result in death

or serious injury.

3 - GENERAL VIEW AND MAIN COMPONENTS

Pivot jacket upwards. See ﬁgure 4

Figure 5 - Boiler Clearances

4 - LOCATING BOILER

4.1 Boiler Location Considerations

• Ambient room temperature always above 32°F (0°C) to

prevent freezing.

• Approved for installation in closets.

• Protect gas ignition system components from water

(dripping, spraying, rain, etc.) during operation and

service (circulator replacement, control replacement,

etc.).

• Wall mount only.

• Access to outdoors to meet minimum and maximum

pipe lengths for combustion air and vent piping. See

section 6.

• Drainage of water (or water - antifreeze solution) during

boiler service or from safety relief valve discharge. See

section 5.

• Access to system water piping, gas supply, and electrical

service. See sections 5, 7 and 8.

• Clearances to combustible materials and service

FOHDUDQFHV6HH7DEOHDQG¿JXUH

• The boiler shall not be installed on carpeting.

FLOOR

TABLE 1: BOILER CLEARANCES

Dimension &RPEXVWLEOH

Materials (1) Service(1)(2)

Top (A)

16” (41cm) 16" (41cm)

Left Side (B)

0" (0 cm) 1” (3 cm)

5LJKW6LGH&

0" (0 cm) 1” (3 cm)

Front (D)

0" (0 cm) 1" 3 cm)

Back (E)

0" (0 cm) 0” (0 cm)

Bottom (F)

0" (0 cm) 12" (30 cm)

&RPEXVWLRQ$LUSLSLQJ

0" (0 cm) 3/8" (1 cm)

Vent piping

6" (15 cm) 6" (15 cm)

(1) Required distances measured from boiler jacket.

(2) Service, proper operation clearance recommendation.

Boiler

(Side View)

Boiler

(Front View)

Front

Figure 6 - Wall Mounting Bracket

4 - LOCATING BOILER

4.2 3UHSLSHVXSSO\DQGUHWXUQZDWHUFRQQHFWLRQV

ZLWKIDFWRU\¿WWLQJVEHIRUHZDOOPRXQWLQJ

4.3 Wall Mounting

Mount boiler on wall using wall mounting bracket included

with unit.

• Structure must be capable of supporting boiler weight

plus 60 lbs (28 kg). See page 7.

• Wall mount bracket has 2 slots, spaced at

9¼”

(23.5cm) on center

• Attach wall mount bracket level on wall.

• %RLOHUPXVWHQJDJHZLWKZDOOPRXQWEUDFNHW6HH¿JXUH

CAUTION

Boiler weight exceeds 75 pounds (34 kg). Do not

lift boiler onto wall without assistance.

NOTICE

Lift boiler using chassis. Using front jacket, vent

SLSLQJZDWHURUJDV¿WWLQJVWROLIWERLOHUPD\FDXVH

damage to the boiler.

223/64"

91/4" (23.5cm)

(6cm)

223/64"

(6cm)

Otros manuales para CCB-150

Tabla de contenidos

Idiomas:

Otros manuales de Caldera de ECR International

ECR International

ECR International Utica Boilers MAH-100 Manual de instrucciones

ECR International

ECR International Olsen OLSSC-050 Manual de instrucciones

ECR International

ECR International Olsen Q90 125-200 II Series Manual de instrucciones

ECR International

ECR International SBO Series Manual de instrucciones

ECR International

ECR International Dunkirk PLYMOUTH STEAM 2 Series Manual de instrucciones

ECR International

ECR International Utica Boilers UCS 240 Manual de instrucciones

ECR International

ECR International 100 Guía del usuario

ECR International

ECR International Dunkirk EXCELSIOR EXB Series Manual de instrucciones

ECR International

ECR International GreenMountain GMGW Manual de instrucciones

ECR International

ECR International Dunkirk WPSB 3 Series Manual de instrucciones

ECR International

ECR International Green Mountain GMGW Series Manual de usuario

ECR International

ECR International Columbia MCC II Series Manual de instrucciones

ECR International

ECR International Olsen OMGB II Series Manual de instrucciones

ECR International

ECR International Green Mountain GMHB125 Manual de instrucciones

ECR International

ECR International Utica Boilers UB90-50 Manual de instrucciones

ECR International

ECR International 15B-K Manual de instrucciones

ECR International

ECR International Dunkirk DMG-380 Manual de instrucciones

ECR International

ECR International UTICA BOILERS MAH-125 Manual de usuario

ECR International

ECR International 95M-200 Manual de usuario

ECR International

ECR International Dunkirk DCBF-125 Manual de usuario

ECR International

ECR International UTICA BOILERS MAHF-75 Manual de usuario

ECR International

ECR International Olsen OQ95M-200 Manual de instrucciones

ECR International

ECR International 75 Manual de instrucciones

ECR International

ECR International XEB Series Manual de instrucciones

Manuales populares de Caldera de otras marcas

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Manual de usuario

Radijator

Radijator BIO max 23.1 Manual de usuario

Brunner

Brunner BSV 20 Manual de usuario

Buderus

Buderus Logamax GB062-24 KDE H V2 Manual de usuario

Potterton

Potterton 50e Hoja de datos

UTICA BOILERS

UTICA BOILERS TriFire Manual de usuario

Joannes

Joannes LADY Series Manual

Froling

Froling FHG Turbo 3000 Manual de usuario

Froling

Froling P4 Pellet 8 - 105 Manual de usuario

U.S. Boiler Company

U.S. Boiler Company K2 Manual de usuario

Henrad

Henrad C95 FF Manual de usuario

NeOvo

NeOvo EcoNox EF 36 Manual de usuario

Potterton

Potterton PROMAX SL 12 Manual de usuario

Eco Hometec

Eco Hometec EC 25 COMPACT Manual de usuario

Viessmann

Viessmann VITODENS 200 Guía

Baxi

Baxi Prime 1.24 Manual de usuario

REXNOVA

REXNOVA ISA 20 BITHERMAL Manual de usuario

Radiant

Radiant R2K 55 Manual