Eaton Extended Battery Module (EBM) 9140 Manual de usuario
Powerware 9140
Extended Battery Module (EBM)
User’s Guide
For use with the Powerware 9140 7.5–10 kVA UPS Models
Powerware 9140
Extended Battery Module (EBM)
User’s Guide
For use with the Powerware 9140 7.5–10 kVA UPS Models
Special Symbols
The following are examples of symbols used on the UPS or accessories to alert you to important
information:
RISK OF ELECTRIC SHOCK - Indicates that a risk of electric shock is present and the
associated warning should be observed.
CAUTION: REFER TO OPERATOR’S MANUAL - Refer to your operator’s manual for
additional information, such as important operating and maintenance
instructions.
This symbol indicates that you should not discard the UPS or the UPS batteries
in the trash. This product contains sealed, lead-acid batteries and must be
disposed of properly. For more information, contact your local recycling/reuse or
hazardous waste center.
This symbol indicates that you should not discard waste electrical or electronic
equipment (WEEE) in the trash. For proper disposal, contact your local
recycling/reuse or hazardous waste center.
Powerware is a registered trademark of Eaton Electrical Inc.
ECopyright 2006 Eaton Corporation, Raleigh, NC, USA. All rights reserved. No part of this document may be
reproduced in any way without the express written approval of Eaton Corporation.
EATON Powerware®9140 EBM User’s Guide S164201623 Rev A FINAL DRAFT 2006 July 14 i
Table of Contents
1 Introduction 1.........................................................
Safety Warnings 2......................................................................
2 Installation 15..........................................................
Inspecting the Equipment 15................................................................
Unpacking the Cabinet 16..................................................................
EBM Setup 17..........................................................................
Checking the EBM Accessory Kit 17........................................................
Rack Setup for the EBM 18..............................................................
Installing the EBM Batteries 24...........................................................
EBM Installation 25......................................................................
3 Operation 27...........................................................
Configuring the UPS for EBMs 27............................................................
Initiating the Battery Test 28................................................................
4 Maintenance 29........................................................
UPS and Battery Care 29..................................................................
Storing the UPS and Batteries 29............................................................
When to Replace Batteries 30...............................................................
Replacing Batteries 30....................................................................
How to Replace EBM Batteries 31.........................................................
Testing New Batteries 33..................................................................
Recycling the Used Battery or UPS 34.........................................................
5 Service and Support 35..................................................
TABLE OF CONTENTS
EATON Powerware®9140 EBM User’s Guide S164201623 Rev A FINAL DRAFT 2006 July 14
ii
EATON Powerware®9140 EBM User’s Guide S164201623 Rev A FINAL DRAFT 2006 July 14 1
Chapter 1 Introduction
The Extended Battery Module (EBM) can be added to the
Powerware®9140 uninterruptible power system (UPS) to extend the
available battery time (see Table 1). Up to four EBMs can be installed
with the Powerware 9140 UPS.
Table 1. Battery Runtimes (in Minutes)
Load
(10 kVA Models) UPS Internal
Batteries +1 EBM +2 EBMs +3 EBMs +4 EBMs
100% Load 512 27 35 45
75% Load 717 35 46 60
50% Load 12 27 52 69 90
25% Load 31 61 99 138 181
Load
(7.5 kVA Models) UPS Internal
Batteries +1 EBM +2 EBMs +3 EBMs +4 EBMs
100% Load 8.5 23.5 37.5 53 65.5
75% Load 12 30 52 69 86.5
50% Load 22 51.5 78.5 98.5 111
25% Load 48 94 116 >120 >180
NOTE Battery times are approximate and vary depending on the load configuration and battery charge.
INTRODUCTION
EATON Powerware®9140 EBM User’s Guide S164201623 Rev A FINAL DRAFT 2006 July 14
2
Safety Warnings
IMPORTANT SAFETY INSTRUCTIONS
SAVE THESE INSTRUCTIONS
This manual contains important instructions that you should follow during installation and
maintenance of the EBM. Please read all instructions before operating the equipment and
save this manual for future reference.
WARNING
This UPS contains its own energy source (batteries). The UPS output receptacles may carry
live voltage even when the UPS is not connected to an AC supply.
CAUTION
SBatteries can present a risk of electrical shock or burn from high short-circuit current.
Observe proper precautions. Servicing should be performed by qualified service
personnel knowledgeable of batteries and required precautions. Keep unauthorized
personnel away from batteries.
SProper disposal of batteries is required. Refer to your local codes for disposal
requirements.
SNever dispose of batteries in a fire. Batteries may explode when exposed to flame.
INTRODUCTION
EATON Powerware®9140 EBM User’s Guide S164201623 Rev A FINAL DRAFT 2006 July 14 3
Sikkerhedsanvisninger
VIGTIGE SIKKERHEDSANVISNINGER
GEM DISSE ANVISNINGER
Denne manual indeholder vigtige instruktioner, som skal følges under installation og
betjening af EBM-enheden. Læs venligst alle instruktioner inden betjening af udstyret og
gem denne manual mhp. fremtidige opslag.
ADVARSEL!
Denne UPS indeholder sin egen energikilde (batterier). Udgangsstikkene kan endog være
strømførende, når UPS’en ikke er koblet til en vekselstrømsforsyning.
ADVARSEL
SBatterierne kan give risiko for elektrisk stød eller brandsår forårsaget af høj
kortslutningsstrøm. Overhold gældende forsigtighedsregler. Servicering skal udføres af
kvalificeret servicepersonale med kendskab til batterier og gældende forsigtighedsregler.
Hold uautoriseret personale væk fra batterierne.
SKorrekt bortskaffelse af batterier er påkrævet. Overhold gældende lokale regler for
bortskaffelsesprocedurer.
SSkaf dig aldrig af med batterierne ved at brænde dem. Batterierne kan eksplodere ved
åben ild.
INTRODUCTION
EATON Powerware®9140 EBM User’s Guide S164201623 Rev A FINAL DRAFT 2006 July 14
4
Belangrijke Veiligheidsinstructies
BELANGRIJKE VEILIGHEIDSINSTRUCTIES
BEWAAR DEZE INSTRUCTIES
Deze handleiding bevat belangrijke instructies die u dient te volgen tijdens de installatie en
het gebruik van EBM. Lees alle instructies voordat u de apparatuur in bedrijf neemt en
bewaar deze handleiding als naslagwerk.
WAARSCHUWING
Deze UPS bevat een eigen energiebron (batterijen). De uitgangscontactdoos kan onder
spanning staan, zelfs wanneer de UPS niet is aangesloten op de netspanning.
OPGELET
SBatterijen leveren gevaar op voor elektrische schokken en kunnen brandwonden
veroorzaken door een grote kortsluitstroom. Neem de juiste voorzorgsmaatregelen in
acht. Het onderhoud moet worden uitgevoerd door bevoegde onderhoudsmonteurs die
verstand hebben van accu’s en op de hoogte zijn van de vereiste voorzorgsmaatregelen.
Houd onbevoegden uit de buurt van de accu’s.
SDe batterijen moeten op de juiste wijze worden opgeruimd. Raadpleeg hiervoor uw
plaatselijke voorschriften.
SNooit batterijen in het vuur gooien. De batterijen kunnen ontploffen.
Este manual sirve para los siguientes modelos
1
Tabla de contenidos
Otros manuales de Fuente de alimentación de Eaton
Eaton
Eaton APS3-330 Series Instrucciones de funcionamiento
Eaton
Eaton TRIPP LITE Series Instrucciones de montaje
Eaton
Eaton SPS-24V-1A5/BNS Manual de usuario
Eaton
Eaton APS6-600 Series Instrucciones de funcionamiento
Eaton
Eaton PSG120F24RM Manual de usuario
Eaton
Eaton MTL 9493-PS-XXX Manual de usuario
Eaton
Eaton Crouse-hinds series Manual de usuario
Eaton
Eaton xComfort CDAE-01/02 Manual de usuario
Eaton
Eaton Crouse-Hinds MTL F890 Manual de usuario
Eaton
Eaton Crouse-hinds series Manual de usuario
Eaton
Eaton Crouse-hinds series Manual de usuario
Eaton
Eaton Power Xpert 825/550 Manual de usuario
Eaton
Eaton Crouse-hinds series Manual de usuario
Eaton
Eaton Powerware Prestige Series 1500 VA Guía de configuración
Eaton
Eaton APS3-300 Instrucciones de funcionamiento
Eaton
Eaton Powerware 9130 Manual de usuario
Eaton
Eaton 70C1081G01 Manual de usuario
Eaton
Eaton PSG120E Manual de usuario
Eaton
Eaton Powerware Series Manual de usuario
Eaton
Eaton RM3-400-0330 Instrucciones de funcionamiento
