Dometic CoolPower44 RAPS44 Manual de usuario

OPERATION

MANUAL

Model: RAPS44

Operation manual

WAECO CoolPower 44

Please read instructions carefully before using your CoolPower44.

Keep instructions in a safe place for future reference.

Index

Before ﬁrst use 4

Installation and operation 4

Fridge running time 4

Testing 5

Charging 5

Depth of discharge v’s battery life 6

Storage 6

Troubleshooting 7

Technical information 7

Operation manual

Before ﬁrst use

Before using for the ﬁrst time, charge your CoolPower44 using one of the methods

described in Charging (page 5).

Installation and operation

Your CoolPower44 is designed to run standing upright for stability and convenient

access to sockets and voltage display. However operation at any angle, from sideways

to upside down, is permissible. The internal cells are completely sealed and leak proof.

In vehicle

• Fit the charge lead screw terminal to the battery ‘CHARGE’ socket and plug the

other end into the vehicle 12 volt socket.

• If the WAECO heavy duty wiring kit, RAPS12R-U2 has been ﬁtted to the vehicle

(recommended), connect the charge lead from the battery to heavy duty kit

socket.

• Plug your WAECO compressor fridge or other 12V appliance into one of the

front CoolPower sockets.

Stand alone

• Connect your WAECO compressor fridge or other 12V appliance into one of the

Front CoolPower sockets. To run your fridge for the longest possible time, make

sure your CoolPower is fully charged ﬁrst (see Charging - page 5).

Fridge running time

Your CoolPower44 is designed to run portable compressor refrigerators up to 65 litres,

but will also run larger models for a limited time. Approximate run times are as follows:

Model Approximate run time* operating as:

Fridge Only Freezer Only Fridge/Freezer

CFX-28 to CFX-65 36-40 hrs 13-17 hrs n/a

CFX-65DZ n/a n/a 18 hrs

CF80 18 hrs 8 hrs n/a

* @ 32ºC ambient

Your fridge will run for longer than stated times in cooler ambient conditions.

WAECO CoolPower 44

Testing

Disconnect the charge lead and press the button on your CoolPower front panel

whilst your fridge is running.

Voltage

Your battery voltage will appear on the digital display. The precise remaining

capacity will vary depending on conditions such as ambient temperature, but as a

general guide will be as follows:

LED’s (on front panel)

A quick visual indication of the condition of your CoolPower can be obtained at a

glance. After disconnecting charging leads and pressing the test button:

Charging

In-car (12V)

• Plug the charge lead 2-pin screw connector into the ‘CHARGE’ socket on the

left hand side of your CoolPower. Then plug the 12 volt plug on the other end of

the charge lead either directly into your vehicle 12 volt socket, or (recommended)

into the WAECO RAPS12R-U2 heavy duty wiring kit socket pre-ﬁtted to your

vehicle.

• When the CoolPower is accepting charge from your vehicle battery, the green

LED adjacent to the ‘CHARGE’ socket will illuminate.

240V mains

• Ensure the battery charger is suitable for 44Ah AGM batteries.

• Most multi-stage battery chargers up to 15A maximum should be suitable

Voltage Capacity

12.8V or more 80% - 100%

12.3V to 12.7V 40% - 80%

11.3V to 12.2V 20% - 40%

LED indicator Voltage Action Required

‘FULL’ green ON 12.8V or more None

Both OFF 11.4V to 12.7V Charging optional

‘LOW’ red ON 11.3V or less Must charge

Operation manual

•An automatic cut out charger must be used, otherwise irreparable

damage will occur and your warranty voided.

• Disconnect your fridge and DC charging lead from the battery.

• Before turning the battery charger on, connect the alligator clamps to the + and

- posts at the top of the CoolPower44, ensuring good contact. Now turn the

charger on.

• Charging times will vary depending on depth of battery discharge prior to

charging and the battery charger used.

• To test your battery after charging, disconnect the charger, wait 30 minutes and

then follow the procedure outlined in Testing (page 5).

Depth of discharge v’s battery life

• The depth of discharge (DOD) is the amount the battery is drained without charging.

For example, a remaining capacity of 20% equates to an 80% DOD.

• The service life is the number of times the battery will cycle from fully charged to a

given DOD. For a battery in continuous cycle service use, approximate service life

ﬁgures are as follows:

• Total battery life is a combination of service life and storage conditions when not in

use and is inﬂuenced by other variables. However as a general guideline you can

increase the life of your battery by not discharging any further than necessary before

charging.

Storage

All batteries beneﬁt from periodic charging when not in use. Following this advice will

ensure optimum life from your CoolPower44. Self-discharge characteristics vary with

ambient temperature and age, but as a general guideline the battery should be fully

charged every 3-4 months.

DOD Service Life (# Cycles)

80 % 350

50 % 600

30 % 1,250

WAECO CoolPower 44

Troubleshooting

Problem Possible solution

Battery charge OK, no power to

fridge

Check all connections – ensure they are secure and clean

Check fuse located at rear of battery directly behind the socket

powering your fridge. If blown, replace with 15A 3AG fuse

Not fully charging in-car Check connections – ensure they are secure and clean

Is the WAECO RAPS12R-U2 heavy duty wiring kit ﬁtted? If not, the

vehicle wiring may not be heavy enough to deliver adequate charging

current. Fit RAPS12R-U2 to vehicle

Technical Information (RAPS44)

Output sockets: 1 x 10A 12 volt, 1 x 15A ‘hella’ style (fused separately)

Fuses: 2 x 15A 3AG

Input sockets: 1 x 2-pin screw type (small) for DC charging

1 x 2-pin screw type (large) for 88Ah connection to second RAPS44

(not supplied – must be purchase separately)

Voltage test: Push button digital volts display

‘FULL’ LED (green) = 12.8V or more

‘LOW’ LED (red) = 11.3V or less

DC charging lead: 2.4m long, 2 pin screw connection battery end, 12 volt plug other end

Charge LED (green): Adjacent to screw socket. On when battery connected to in-car system

and accepting 12V charge from vehicle battery

AC charging: Multi-stage chargers up to 15A

Connection via + and – post terminals

Battery cells: 2 x 12V 22Ah(20 hr rate) deep cycle Absorbent Glass Mat (AGM)

Operating temp. range: -20 to +60ºC

Weight: 13.5 kg

Dimensions: W230 x H245 x D227mm

For further assistance call Dometic Technical assistance 1800 21 21 21.

151215

AUSTRIA

Dometic Austria GmbH

Neudorferstrasse 108

2353 Guntramsdorf

+43 2236 908070

+43 2236 90807060

Mail: [email protected]

BENELUX

Dometic Benelux B.V.

Ecustraat 3

NL-4879 NP Etten-Leur

+31 76 5029000

+31 76 5029090

Mail: [email protected]

DENMARK

Dometic Denmark A/S

Nordensvej 15, Taulov

DK-7000 Fredericia

+45 75585966

+45 75586307

Mail: [email protected]

FINLAND

Dometic Finland OY

Mestarintie 4

FIN-01730 Vantaa

+358 20 7413220

+358 9 7593700

Mail: [email protected]

FRANCE

Dometic SAS

ZA du Pré de la Dame Jeanne

F-60128 Plailly

+33 3 44633500

+33 3 44633518

Commercial : info@dometic.fr

SAV/Technique : service@dometic.fr

GERMANY

Dometic WAECO International GmbH

Hollefeldstraße 63

D-48282 Emsdetten

+49 (0) 2572 879-195

+49 (0) 2572 879-322

Mail: [email protected]

HONG KONG

WAECO Impex Ltd.

Suites 2207-2211 · 22/F · Tower 1

The Gateway · 25 Canton Road,

Tsim Sha Tsui · Kowloon

+852 24611386

+852 24665553

Mail: info@dometic-waeco.com.hk

HUNGARY

Dometic Plc. Sales Office

Kerékgyártó u. 5.

H-1147 Budapest

+36 1 468 4400

+36 1 468 4401

Mail: budape[email protected]

ITALY

Dometic Italy S.r.l.

Via Virgilio, 3

I-47100 Forlì

+39 0543 754901

+39 0543 756631

Mail: [email protected]

NORWAY

Dometic Norway AS

Skolmar 24

N-3232 Sandefjord

+47 33428450

+47 33428459

Mail: firmapost@waeco.no

POLAND

Dometic Poland Sp. z o.o.

Ul. Puławska 435A

02-801 Warszawa

+48 22 414 32 00

+48 22 414 32 01

Mail: [email protected]

RUSSIA

Dometic RUS LLC

Komsomolskaya square 6-1

107140 Moscow

+7 495 780 79 39

+7 495 916 56 53

Mail: [email protected]

SLOVAKIA

Dometic Slovakia Sales Office Bratislava

Nádražná 34/A

SK-900 28 Ivanka pri Dunaji

/+421 2 45 529 680

Mail: bratisl[email protected]

SPAIN

Dometic Spain S.L.

Avda. Sierra del Guadarrama, 16

E-28691 Villanueva de la Cañada

Madrid

+34 902 111 042

+34 900 100 245

Mail: [email protected]

SWEDEN

Dometic Scandinavia AB

Gustaf Melins gata 7

S-42131 Västra Frölunda (Göteborg)

+46 31 7341100

+46 31 7341101

Mail: [email protected]

SWITZERLAND

Dometic Switzerland AG

Riedackerstrasse 7a

CH-8153 Rümlang (Zürich)

+41 44 8187171

+41 44 8187191

Mail: info@dometic-waeco.ch

TAIWAN

WAECO Impex Ltd.

Taipei Office

9F.-10, No. 1180, Zhongzheng Rd.,

Zhonghe Dist., New Taipei City 23586

+886 2 22237225

+886 2 81926742

Mail: market[email protected].tw

UNITED KINGDOM

Dometic UK Ltd.

Dometic House · The Brewery

Blandford St. Mary

Dorset DT11 9LS

+44 844 626 0133

+44 844 626 0143

Mail: [email protected]

UNITED ARAB EMIRATES

Dometic Middle East FZCO

P. O. Box 17860

S-D 6, Jebel Ali Freezone

Dubai

+971 4 883 3858

+971 4 883 3868

Mail: [email protected]

UNITED STATES OF AMERICA

Dometic Marine Division

2000 N. Andrews Ave. Extension

Pompano Beach, FL 33069 USA

+1 954 973 2477

+1 954 979 4414

Mail: marinesales@dometicusa.com

AUSTRALIA

Dometic Australia Pty. Ltd.

1 John Duncan Court · Varsity Lakes QLD 4227

1800 212121 · +61 7 55076001

Mail: [email protected]

www.waeco.com.au

4445101339 09/2015

Tabla de contenidos

Otros manuales de Paquete de baterías de Dometic

Dometic

Dometic PLB40 Manual de usuario

Dometic

Dometic NDS 3LION Manual de usuario

Dometic

Dometic PLB40 Manual de usuario

Dometic

Dometic Go Power! GP-ADV-LiFePO4-100 Manual de usuario

Dometic

Dometic BatteryPack BP124 Manual de usuario

Dometic

Dometic PLB40 Manual de usuario

Dometic

Dometic GP-ADV-LiFePO4-300 Manual de usuario

Dometic

Dometic Go Power! GP-ADV-LiFePO4-100 Manual de usuario

Dometic

Dometic PLB40 Manual de usuario

Dometic

Dometic PLB40 Manual de usuario

Manuales populares de Paquete de baterías de otras marcas

Acumentrics

Acumentrics PACK-POWER SYSTEM Manual de usuario

ACDC Dynamics

ACDC Dynamics SPF12-50 Manual de usuario

Aegis

Aegis ABL-72020P Manual de usuario

Dyness

Dyness TowerESS Manual de usuario

Growatt

Growatt APX 5.0P-S0-US Manual de usuario

EGO

EGO BAX1300 Manual de usuario

CyberPower

CyberPower BCA Series Manual de usuario

Intermec

Intermec 700 Series Manual de usuario

V-TAC

V-TAC VT-48280-W2 Manual de usuario

Valence

Valence RT Manual de usuario

Nikon

Nikon MB-D14 Manual de usuario

IOGear

IOGear GBP24V Series Manual de usuario

Inventus Power

Inventus Power PROTRXion S-12V100-TRX-HD Manual de usuario

Clas Ohlson

Clas Ohlson PW-290A Manual de usuario

EINHELL

EINHELL MULTI-Ah Power X-Change Plus Manual de usuario

Samsung

Samsung EB-U3300 Manual de usuario

ECTIVE

ECTIVE LC Series Manual de usuario

Narada

Narada 12REXC70 Manual de usuario