Dometic 8700 Series MasterFlush Manual de usuario

Dometic8700

Awning

Service Manual

AWNINGS

8700 SERIES

Dometic8700_SVM_APAC(en).book Seite 1 Dienstag, 23. Juni 2020 3:32 15

Dometic8700_SVM_APAC(en).book Seite 2 Dienstag, 23. Juni 2020 3:32 15

Dometic8700 Explanation of symbols

Please read this instruction manual carefully before installation and first

use, and store it in a safe place. If you pass on the product to another

person, hand over this instruction manual along with it.

Table of contents

1 Explanation of symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

2 Important safety instructions for installation. . . . . . . . . . . . . . . . . . . . .4

3 Servicing the awning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

3.1 Removing the awning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

3.2 Removing the torsion rods . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8

3.3 Replacing the awning fabric/fabric roller tube . . . . . . . . . . . . . . . . . 11

3.4 Replacing the torsion rods . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13

3.5 Wind torsion rods . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16

3.6 Reattach torsion. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18

3.7 Remount the awning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18

3.8 Verifying the installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18

4Disposal. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19

1 Explanation of symbols

WARNING!

Safety instruction: Indicates a hazardous situation that, if not avoided,

could result in death or serious injury.

CAUTION!

Safety instruction: Indicates a hazardous situation that, if not avoided,

could result in minor or moderate injury.

NOTICE!

Indicates a situation that, if not avoided, can result in property damage.

NOTE

Supplementary information for operating the product.

Dometic8700_SVM_APAC(en).book Seite 3 Dienstag, 23. Juni 2020 3:32 15

Important safety instructions for installation Dometic8700

2 Important safety instructions for

installation

Please observe the prescribed safety instructions and stipulations from the

vehicle manufacturer and service workshops.

The manufacturer accepts no liability for damage in the following cases:

• Faulty assembly or connection

• Damage to the product resulting from mechanical influences

• Alterations to the product without express permission from the manufacturer

• Use for purposes other than those described in the operating manual

!WARNING!

• If you do not have sufficient technical knowledge for installing

components in vehicles, you should have a specialist to service your

awning.

3 Servicing the awning

ANOTICE! Damage hazard

• Prepare an area large enough for the fabric roller tube assembly and

the unrolled awning fabric.

The area must be smooth, clean, and clear of debris to prevent fabric

damage.

INOTE

• A stepladder may be necessary to reach awning rail.

3.1 Removing the awning

➤Proceed as shown to remove the awning (fig. 1, page 5 to fig. 0, page 8).

INOTE

Save all mounting materials you remove for reinstallation later.

Dometic8700_SVM_APAC(en).book Seite 4 Dienstag, 23. Juni 2020 3:32 15

Dometic8700 Servicing the awning

CLICK

Dometic8700_SVM_APAC(en).book Seite 5 Dienstag, 23. Juni 2020 3:32 15

Servicing the awning Dometic8700

Dometic8700_SVM_APAC(en).book Seite 6 Dienstag, 23. Juni 2020 3:32 15

Dometic8700 Servicing the awning

CAUTION! Lifting hazard

Use proper lifting technique and control when lifting product.

NOTICE! Damage hazard

• Keep both arm assemblies parallel to each other to avoid twisting.

• Maintain roll down position of the awning safety lock to prevent the

fabric roller tube assembly from uncontrolled unwinding when the

fabric is removed from the awning rail.

Dometic8700_SVM_APAC(en).book Seite 7 Dienstag, 23. Juni 2020 3:32 15

Servicing the awning Dometic8700

3.2 Removing the torsion rods

➤Proceed as shown to remove the torsion rods (fig. a, page 9 to fig. g,

page 11).

!WARNING! Health hazard

Do not remove the awning from arm assembly until the torsion rod is

securely pinned. Otherwise rapid casting spin off will occur. Spring

tension will attempt to spin the fabric roller tube quickly and

unexpectedly.

Dometic8700_SVM_APAC(en).book Seite 8 Dienstag, 23. Juni 2020 3:32 15

Dometic8700 Servicing the awning

!WARNING! Health hazard

•Donot remove the nail from torsion rod until the arm cap is securely

held. Otherwise rapid casting spin off will occur. Spring tension will

attempt to spin the arm cap and/or fabric roller tube quickly and

unexpectedly.

• Use extreme care when winding/unwinding the arm cap. If not

controlled, rapid casting spin off will occur. Spring tension will

attempt to spin the arm cap and/or fabric roller tube quickly and

unexpectedly.

Dometic8700_SVM_APAC(en).book Seite 9 Dienstag, 23. Juni 2020 3:32 15

Servicing the awning Dometic8700

INOTE

Pin both torsions to prevent uncontrolled unwinding of spring, or

unintended awning movement.

Dometic8700_SVM_APAC(en).book Seite 10 Dienstag, 23. Juni 2020 3:32 15

Otros manuales para 8700 Series MasterFlush

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Accesorios de Dometic

Dometic

Dometic PERFECTROOF PR2000 Manual de usuario

Dometic

Dometic BordBar TF14 Manual de usuario

Dometic

Dometic CF SERIES Manual de usuario

Dometic

Dometic 9500E Manual de usuario

Dometic

Dometic ACX3 Series Manual de usuario

Dometic

Dometic Kampa RALLY AIR ALL-SEASON 330 D/A Manual de usuario

Dometic

Dometic SUNSHINE AIR PRO VW Manual de usuario

Dometic

Dometic Cup Cooler Manual de usuario

Dometic

Dometic WeatherPro 855 Series Manual de usuario

Dometic

Dometic A&E Systems 8500 Guía

Dometic

Dometic 103EAA Manual de usuario

Dometic

Dometic Sunchaser II 8275000 Series Manual de usuario

Dometic

Dometic WINTER AIR PVC 260 S Manual de usuario

Dometic

Dometic 9500E Manual de usuario

Dometic

Dometic 3316736.000 Manual

Dometic

Dometic BORDBAR AS25 Manual de usuario

Dometic

Dometic 3309790.008 Manual de usuario

Dometic

Dometic CFX40 Manual de usuario

Dometic

Dometic SC Series Manual de usuario

Dometic

Dometic Waeco CoolFun MB40 Manual de usuario

Dometic

Dometic A&E Systems 8500 Manual de usuario

Dometic

Dometic PERFECTROOF PR2000 Manual de usuario

Dometic

Dometic PerfectWall PW3500 Manual de usuario

Dometic

Dometic 8270000.401 Series Manual de usuario

Manuales populares de Accesorios de otras marcas

Hillco

Hillco 2810 Manual de usuario

Siemens

Siemens QSA2700D Manual del operador

Contours

Contours ZY024 Manual de usuario

Saivod

Saivod VS621 Manual de usuario

Virtuox

Virtuox VirtuCLEAN 2.0 Manual de usuario

SCE

SCE ENVIRO-THERM SCE-TE170B24VSS Manual de usuario

Z-Wave

Z-Wave HSD-200Z Manual de usuario

turck

turck FMX-IM-2UPLI63FX Manual de usuario

Decagon Devices

Decagon Devices 10HS Manual de usuario

UPPAbaby

UPPAbaby Cup Holder Manual de usuario

Elko

Elko SmartSensor Leakage Wireless Manual de usuario

Grizzly

Grizzly H8371 Manual de usuario

Panasonic

Panasonic HG-T Series Manual de usuario

IFM Electronic

IFM Electronic Efector 250 Series Guía de referencia

DigiDesign

DigiDesign 888/24 I/O Manual de usuario

PROZIS

PROZIS QUAY Manual de usuario

patagonia

patagonia PSI Vest Manual de usuario

SFC Energy

SFC Energy EFOY GO! Manual de usuario