Digiray FireCR Flash Manual de usuario
Service Manual
FireCR Flash Computed Radiography Reader
Doc No.: TM-411-EN
Rev: 1.2.1 Nov 2014
Part No.: CR-FPM-51-005-EN
Digiray,FireCR,FireCR Flashand Quantor are trademarks of Digiray Corp, South Korea, and its
affiliates. All other trademarks are held by their respective owners and are used in an editorial
fashion with no intention of infringement.
The data in this publication are for illustration purposes only and do not necessarily
represent standards or specifications, which must be met by Digiray Corp.
All information contained herein is intended for guidance purposes only, and characteristics of the
products and services described in this publication can be changed at any time without notice.
Products and services may not be available in your local area. Please contact your local sales
representative for availability information.
Digiray Corp.strivesto provide asaccurate information as possible, but shall not beresponsible for
any typographical error.
©Copyright 2019Digiray Corp,allrights reserved, printed, and published in South Korea by Digiray
Corp.
Table of contents
Parts removal/replacement
Replacing the top cover ...........................................................................................................................1
Replacing the fiber optics module .......................................................................................................... 3
Replacing the laser steering module....................................................................................................... 6
Replacing the stage Assembly .................................................................................................................9
Replacing the cassette lock motors ...................................................................................................... 13
Replacing the housing assembly........................................................................................................... 15
Calibration .............................................................................................................16
Spare part list.........................................................................................................18
When ordering parts, please inform the technical supporter the serial number of the unit being
repaired.
The serial number can be found on the back of the scanner.
Parts removal/replacement
Replacing the top cover
1. Switch the reader off on the back and unplug both cables.
2. Remove the 4 screws using a 3 mm hex key.
3. Move the top cover towards the back and lift it off. The cover has a tight fit, and a bit of force
has to be applied to move it.
Off
On
USB socket
Power inlet
Power switch
1
2
1
4. When mounting the new top cover, or remounting the old top cover, ensure that locks on the
top cover is seated in the guides in the bottom cover, then move it towards the front to lock it
in place.
5. Insert and fasten the 4 screws in the back of the scanner using a 3 mm hex key.
1
2
2
Replacing the fiber optics module
1. Follow step 1 through 3 of Replacing the top cover.
2. Remove the 3 screws on the back using a 3 mm hex key.
3. Tilt the cover off the laser steering assembly.
3
4. Unplug the connectors shown from the laser steering module. Bear in mind that screw (1) must
be removed using a 2.5 mm hex key before the multicable (2) can be unplugged.
5. Remove the 8 screws using a 3 mm hex key. It is recommended to use a magnetic tool for the
two rear screws.
1
2
4
Replacing the laser steering module
1. Follow step 1 through 3 of Replacing the top cover.
2. Follow step 2 through 7 of Replacing the fiber optics module.
3. Unplug the limit sensor and Y-axis motor from the main board PCB.
4. Remove the 4 screws holding the Y-axis motor using a 3 mm hex key.
5. Carefully lift the Y-axis motor out of the scanner.
6
6. Unplug the three wires from the mains switch.
7. Remove the 2 screws holding the mains power switch using a PH #1 screwdriver.
8. Remove the mains power switch out of the back of the chassis.
Ground
(green/yellow) Load
(white)
Neutral
(black)
7
Otros manuales para FireCR Flash
1
Tabla de contenidos
Otros manuales de Equipo dental de Digiray
Manuales populares de Equipo dental de otras marcas
Vatech
Vatech EzRay Air VEX-P300 Manual de usuario
KaVo
KaVo GENTLEpower LUX Contra-angle 25 LP Manual de usuario
DENTSPLY
DENTSPLY SmartLite Focus Manual de usuario
LM
LM ProPower CombiLED Manual de usuario
Owandy Radiology
Owandy Radiology RX-AC Manual de usuario
mectron
mectron Piezosurgery Manual de usuario
