DIG ECO1 MVA Manual de usuario
Ambient Light Powered,
Irrigation Controller
ECO1 MVA
ECO1 ASV.075
INSTRUCTION MANUAL
TABLE OF CONTENTS
INTRODUCTION ……………………………………………………………… 3
1. About the controller …………………………………………………… 3
2. Component identification ……………………………………………… 4
2.1 ECO 1.ASV with anti-siphon valve …………………………………… 4
2.2 ECO 1MVA manual valve actuator …………………………………… 5
3. System components …………………………………………………… 6
4. Anti-siphon valve installation …………………………………………… 7
4.1 Changing actuator adapters ………………………………………… 9
4.2 Manual valve actuator installation …………………………………… 11
5. Programming ………………………………………………………… 13
6. Setting time and date …………………………………………………… 13
7. Setting watering day schedules ………………………………………… 15
8. Setting watering start time ……………………………………………… 17
9. Setting watering run times ……………………………………………… 19
10. Setting the SimpleSmart™ option ………………………………………… 21
11. Setting seasonal adjustment (monthly budget) …………………………… 24
12. Rain delay setting ……………………………………………………… 25
13. Events off setting ……………………………………………………… 26
14. Manual watering ……………………………………………………… 28
15. Connecting a rain sensor ……………………………………………… 29
16. Maintenance, troubleshooting and repairs ……………………………… 30
17. Warranty ……………………………………………………………… 33
18. Technical assistance …………………………………………………… 34
2
1. ABOUT THE CONTROLLER
The is a one-station, ambient light (solar) powered controller that uses a patented
energy management system to power the controller day and night. The controller
requires no batteries, AC power or direct sunlight and can be installed above grade
anywhere in the landscape.
Employing the latest in water conservation features, the ECO 1 can be pre-set
to automatically adjust the watering durations according to regional seasonal
changes.
Before beginning installation of the unit, please follow the steps below:
Remove the ECO 1™from the box and place it in the sun to
charge for approximately 2 hours or 3 to 4 hours if cloudy.
3
2. COMPONENT IDENTIFICATION
2.1 ECO1 ASV WITH ANTI-SIPHON VALVE
1. Solar PVM
2. LCD screen
3. 7 button keypad
4. Rain sensor connection
5. Quick reference label
6. Collapsible
solenoid wire
7. Manual flow control
8. External bleed screw
9. DC Solenoid
10. Anti-siphon cap
11. Pipe thread outlet
12. Pipe thread inlet
13. Anti-siphon valve
q
w
e
r
t
y
u
i
o
a
s
d
f
4
2.2 ECO1 MVA MANUAL VALVE ACTUATOR
See section 4.1 to change adapters from the factory 3/4 in. assembly to the
1 in. assembly.
1. Solar PVM
2. LCD screen
3. Quick reference label
4. 7 button keypad
5. Rain sensor connection
6. DC Solenoid
7. Collapsible solenoid wire
8. Manual flow control
9. External bleed screw
10. Actuator stem
Seat washer assemblies
AS FACTORY ASSEMBLED FOR
3/4 IN. BRASS VALVES ONLY
CHAMPION, RAIN BIRD & ORBIT
3/4 in. brass adapter
3/4 in. brass washer
Retainer clip
3/4 in. seat washer body
Main screw for seat
washer assembly
ASSEMBLY FOR ALL PLASTIC
VALVES & 1 IN. BRASS VALVES
CHAMPION & ORBIT adapter for 1
in. brass & RAINJET, RAIN BIRD &
ORBIT 3/4 in. & 1 in. plastic
1 in. brass washer
Retainer clip
1 in. & 3/4 in. seat washer body
Main screw for seat
washer assembly
q
w
e
r
t
y
u
i
o
a
5
3. SYSTEM COMPONENTS
LCD Display
1. Time and Date - Indicates current time and day
2. Set Watering Days - Choose either specific days, odd/even days, or up to once
every 30 days
3. Start Time - Up to 5 start times per day available
4. Run Time - Watering duration from 1 minute to 6 hours
5. Manual Run - Appears when manual button is pushed
6. Set ET - Used to set one of the 20 SimpleSmart™presets
7. Set Monthly Budget - Seasonal adjustment setting (0%-200%) in 5%
increments or to fine-tune SimpleSmart™programming
8. Rain Delay - Delay irrigation setting from 1-99 days with automatic restart
9. Events Off - Suspends watering for any month or any specific day within
the month.
10. Power Level - Represents current charge level
11. Sensor - Appears only when sensor is connected and active
12. Watering - Appears when valve is open
q
wr y io
a
e t u
d
s
6
Control Buttons
Select programming mode
Turn ON/OFF program
Start/stop a manual cycle
Move left/right to select a value
Raise/lower the selected value
4. ANTI-SIPHON VALVE INSTALLATION
The ECO1 ASV.075 can be installed directly to PVC pipe. (Inlet 3/4 in. FNPT, outlet
3/4 in. FNPT.)
Operating pressure: 10 to 125 PSI
Recommended operating pressure: 10 to 80 PSI
NOTE: Wrap all fittings with Teflon tape.
Do not use pipe cement on the valve as this will damage the valve and void
the warranty.
Make sure when wrapping fittings with Teflon tape that no excess gets into the
internal assembly. Tighten the fittings with a wrench, but do not over tighten.
NOTE: The ECO1 ASV.075 must be installed at least 6 in. higher than the highest
sprinkler head on the system or back-drainage may occur. Additional control
valves must not be installed downstream of the anti-siphon valve. The valve must
not be operated continuously for more than 12 hours in any 24-hour period.
Consult local codes for specific details.
1. Flush main line until water runs clear before installation.
2. Shut off main water supply.
3. Install the anti-siphon valve directly to PVC pipe using 3/4 in. PVC male adapter
or use Schedule 80 nipple. The arrow on valve body indicates direction of water
flow (see Figure 6).
7
4. Turn the main water supply on and pressurize the system.
5.To test the ECO 1™, press the button. A click will be heard, indicating the
valve is open. An icon of a droplet on the upper left of the screen and the
run time remaining will appear on the display in 5 seconds. Check that the
system is operating correctly and press the button again to turn it off. A
second click will be heard indicating that the valve closed. The droplet icon
and the manual icon will disappear from the display and OFF will appear
momentarily; then the display will revert to the time of day.
6. Program the ECO 1™controller (see section 5).
FIGURE 6 FIGURE 7
6 IN. MINIMUM
8
4.1 CHANGING ACTUATOR ADAPTERS
The ECO 1™with actuator is factory set to fit a 3/4 in. brass manual anti-siphon
valve. To install the controller with actuator on a 1 in. manual anti-siphon valve
the 3/4 in. seat washer and adapter must be removed and replaced with the 1 in.
adapter and seat washer, which are included in this box.
1. Turn the actuator so that the seat washer and the 3/4 in. threaded adapter face up.
2. Using pliers, or a 5/18 in. wrench,
remove the seat washer screw by
turning counter clockwise
and pull off the 3/4 in. seat
washer assembly
(see Figure A).
3. Push the 3/4 in. threaded adapter
down towards the actuator to
ease the tension on the retainer
clip (see Figure B).
4. Next, place your thumb on one
side of the retainer clip and with
a pair of pliers grip the other
side of the retainer clip and pull
outwards, away from your thumb,
and upwards, removing it from
the base of the 3/4 in. threaded
adapter then, remove the adapter (see Figure C).
FIGURE A
FIGURE B
FIGURE C
9
5. Install the 1 in. threaded adapter by
pushing it onto the actuator stem
and making sure the notch on the
adapter lines up with the notch on
the stem of the actuator
(see Figure D).
6. Spread the retainer clip with your
thumbs and push the retainer into
the adapter until it clicks
(see Figure E).
7. Install the 1 in. seat washer
assembly as shown. Insert the seat
washer screw into the bottom of the
actuator stem and tighten turning
clockwise (see Figure F).
NOTE: Do not over-tighten.
FIGURE D
FIGURE F
FIGURE E
10
Otros manuales para ECO1 MVA
1
Este manual sirve para los siguientes modelos
1
Tabla de contenidos
Otros manuales de Sistema de riego de DIG
DIG
DIG 5004-I Four Station Manual de usuario
DIG
DIG 8855-1GB Manual de usuario
DIG
DIG FM01AS Manual de usuario
DIG
DIG 410BT Series Manual de usuario
DIG
DIG GRWKIT-12 Manual de usuario
DIG
DIG GE2050 Manual de usuario
DIG
DIG 12 Outlet Drip Manifold Manual de usuario
DIG
DIG LEIT X Series Manual de usuario
DIG
DIG 5006-IP Manual de usuario
DIG
DIG 400A Series Manual de usuario
Manuales populares de Sistema de riego de otras marcas
Hunter
Hunter Institutional Series Manual de usuario
Cellfast
Cellfast 52-305 Manual de usuario
Tyco Fire Product
Tyco Fire Product Star Galaxy SGQR Manual de usuario
Tyco Fire Product
Tyco Fire Product CENTRAL A Manual de usuario
Oral Care Technologies
Oral Care Technologies Hydro Floss Manual de usuario
Reliable
Reliable F1-300 Manual de usuario
