DentalEZ StarDental Titan-E Manual de usuario

866.DTE.INFO (383.4636)

www.DentalEZ.com

0344

StarDental®

1816 Colonial Village Lane

Lancaster, PA 17601 U.S.A.

Printed in the U.S.A.

Emergo Europe

Prinsessegracht 20

2514 AP The Hague

The Netherlands

EC REP

StarDental® Instruments

Caution: Federal law restricts this device to

sale by or on the order of a dentist.

065810 E Date of Issue 2019-05-24

Titan®-E Low-Speed

Handpiece Motor

Instruction Manual

Non-Sterile

Medical Device

Contents

Specications

20,000 rpm Motor: StarDental®Part #266131 (Fixed Back End Part #266132)

 •NoLubricationRequired

 •RecommendedAirPressure:40-45psi(swivelmotor)

 •AirFlow:2.1SCFM@40-45psiatMaximumPowerPoint(swivelmotor)

 •Rotation:ForwardandReverse

 •4-LineConnection(FixedBackEnd)

Installation

1. Selectthemotorappropriatefortubingbasedonpowerrequirements.Examineconnection

ofthemotorandswiveltubingcongurationasthesemustmatchcongurationofdelivery

systemtubing.

DriveAir Water

Exhaust

Air Air

4-Line Tubing 2/3-Line Tubing

Drive

Air

Water

•Specications

•Installation

•Operation

•Cleaning&Sterilization

•Troubleshooting

•ReplacementPartNumbers

•Warranty

Sterilizableupto135°C

135°C

Titan E

20,000 rpm - Lube Free

Made in the U.S.A.

JXXXXX

StarDental

20KMotor

(StarDental Part #266131) Swivel

BEFORE OPERATING THE MOTOR, CAREFULLY READ AND FOLLOW ALL OF THESE INSTRUCTIONS. SAVE

THESE INSTRUCTIONS FOR FUTURE REFERENCE AND OBSERVE ALL WARNINGS AND CAUTIONS.

Indications For Use

Usedintraorallybytraineddentalprofessionalsfordrillingandpreparationofdentalcavities

forrestoration,suchasllings.Theintendeduseextendstodisking,cavityandcrownpreps,

polishing,postandpindrillingandpinsetting.

Swivel

BearingAssembly

ISOConnector

Tubing

Coupler

Tubing

2. Disconnect swivel from handpiece if necessary. Grasp the swivel in front of the bearing

assemblybetweenthethumbandindexngerasshown.

3. SlidetubingcoupleruntiltheendoftheISOconnectorisexposed;holdinhandasshown

withngerssecuringthetubing.

4. AlignandinsertswiveltubesintotheISOconnectorholes.

5. Whileapplyingslightpressuretoholdttingsintheconnectorholes,slidecouplerforward

andengagethreads.Continuethreadingcouplerclockwiseuntilhandtightagainsttheswivel.

Wrench Tubing

Coupler TurnCouplerWhileHolding

SwivelinPlace

6. Usingthewrenchasshown,tighten theswivel to thetubing coupler.Besuretoturntubing

coupler,notswivel.DONOTOVERTIGHTEN.

Note: Thisjointloosensovertime,resultinginlossofpower.Checkfortightnessperiodically.

7. Connecthandpiecetoswivel.

8. Usinganairpressuregaugefor4-line,StarDentalPart#262591,betweenswivelandtubing,

obtainareading.Adjusttheairpressureatdeliveryhead until gaugereads40-45 psiwhile

operatinghandpieceinfullforwardpositionandwithfootcontrolcompletelydepressed.

Note:Ifdeliveryunithasoil/mistlubrication,detachanddrain;handpieceneedsnolubrication.

Installation - Fixed Back End Motor

Titan E

20,000 rpm - Lube Free

Made in the U.S.A.

JXXXXX

StarDental

Direction&Speed

ControlRing

RearEndConnector

20KFixedBackEndMotor

(StarDental®Part #266132)

Note:Ifdeliveryunithasoil/mistlubrication,detachanddrain;motorisLUBEFREE.

NOTICE Topreventdamagetobearings,beforeinstallingalwayscheckdriveairpressureby

usingairpressuregauge,StarDentalPart#262591(4/6-Line)betweenmotorandtubingand

obtainareading.Adjustairpressureatdeliveryheaduntilgaugereads40-45psiwhileoperating

motorandwithfootcontrolcompletelydepressed.

1. Examinetubing.Verifytubinguses4-Lineconnection.

2. Toconnectmotortotubing,aligndriveairandexhausttubeswithmatingISOconnectorholes

incoupler.

3. Whileapplyingslightpressuretoholdtubinginconnectorholes,slidetubingcouplerforward

andengagethreads.Continuethreadingtubingcouplerclockwiseuntil

handtightagainstthemotor.DONOTOVERTIGHTEN.

Note:Thisjointloosensovertime,resultinginairleakageandlossofpower.Checkfor

tightnessperiodically.

Operation

The120°rotationspeedadjustmentringsetsdirectionandspeed.Torunmotorforwardatfull

speed,rotateringtowardstheletter‘F’whileoperatingthefootcontrol.Rotatetotheletter‘R’to

yieldfullspeedinreverse.Varyspeedbyrotatingringineitherdirectiontowardscenter.Note

thesmalldepressionforthecurrentsetting.Aftersetting,themotorrunsatcurrentspeedand

directionuntilreset.Pausingthemotorisnotneededtoalterdirectionorspeedusingthering.

Titan E

20,000 rpm - Lube Free

Made in the U.S.A.

JXXXXX

StarDental

SmallDepression

120°RotationSpeed

AdjustmentRing

ATTACHMENTS

TheTitan-E20KMotorisdesignedtoworkwithallstandardE-Typeattachments.

Titan E

20,000 rpm- Lube Free

Made in the U.S.A.

JXXXXX

StarDental

StraightNoseCone

Motor-to-Angle

Contra-AngleAttachment

20KTitan-EMotor

ANGLE INSTALLATION

StarDental Titan angles can be attached to E-Type Motor-to-Angle

Contra-AngleAttachments

ToinstallaTitanAngle:

1. Unthreadknurledring.

2. Pullknurledringenoughtoshowsplines,remove

knucklefromangle*. Splines

Knuckle

Knurled Ring

Titan 3 LubeFree Ball Bearing

Auto Latch Angle Head

*Note:Savetheknuckleinasafeplace.Youwill

needtheknuckletouseanglewithTitan

attachments.

StraightNoseCone:

Attachtomotor.Installburaccordingtomanufacturer'sinstructions.

NOTICE AnyseriousincidentoccurringfromtheuseofthisdeviceshouldbereportedtoStarDental

immediately.IfincidentoccurredinaEUMemberStatethecompetentauthoritymust

benotied.

3. CarefullymeshthesplinesontheanglewiththesplinesoftheMotor-to-AngleContra-Angle

Attachment

 (seeillustrationbelow).

4. Tightenknurledringontothreadsuntilsnug.

5. Installburaccordingtotheangle’sinstructionmanual.

7LWDQ (

USP/XEH)UHH

0DGHLQWKH86$

-;;;;;



6WDU'HQWDO



Splines

Angle

Motor-to-Angle

Contra-AngleAttachment

Titan-EMotor

TransmissionGear

CAUTIONWhenangledoesnotseatonattachment,gearsarenotmeshedcorrectly.Remove

angle;spinangletransmissiongearandrepeatStep3.

Titan E

StarDental

Internal

Surfaces

SwivelBearing/

SpringAssembly

Clean

Cleaning & Sterilization

CAUTION

INSTRUCTIONS

Maintenance &Lubrication: TheTitan®-EMotorisLubeFreeand,therefore,requiresnolubrication.Motorshouldberoutinely

maintained,checkedforcorrosion,wornparts,etc.andshouldbereplacedonanasneededbasis.

WARNING

Donotexceed135°C

Donotuse:

Limits on Reprocessing

Thehandpiecemotormustbecleanedandsterilizedbeforerstuseandbetweenpatientuse.

Cleaning-Manual: TheTitan®-EMotorisLubeFreeand,therefore,requiresnolubrication.

Attimesdebrisfromthedeliverysystem’sdriveairtubingcollectsinthemotor.Thisbuild-up

maycausesluggishmotoroperation.Toease,place3dropsofDentaLube II,StarDental®Part

#262539intothedriveairtubeofmotor,andalternatelyoperatethemotorinforwardand

reverse.

Cleaning the Swivel, the Mating Motor Part

Cleanallinternalsurfacesatrearofhandpiecemotorwithacottonswabsoakedin

isopropylalcoholuntilclean.

Cleanallexternalsurfacesusingasmalltoothbrushwithisopropylalcohol.

Tooptimizeoperationoftheswivelconnector,cleanallinternalsurfacesofthemotorwith

acottonswabsoakedinisopropylalcoholuntilclean.Cleanareaaroundbearing/spring

assemblyatrearofswivelusingisopropylalcoholandatoothbrush.Drybothusingsyringeair.

Cleaning-Automated: Washer-disinfectorsarenotrecommended.

Wrapped Instrument

Sterilization:

GravityTypeAutoclave:Pre-VacuumAutoclave:

•Minimumof15minutesat132°C•Minimumof4minutesat132°C

•Minimumof30minutesat121°C

Donotexceed135°C

•dryheatsterilizer

•immersiontechniques

•coldsterilizers •ultrasoniccleaners

•sterilizerbagscontainingdisinfectants •handsoaps

•detergents

•chemicaldisinfectors

•surfacesprays •surgicalmilk

•surfacewipes

Additional Information: Do not exceed the sterilizer manufacturer’s guidelines for load capacity. Use only paper or

paper/plasticbags.

Storage: Storeinbagaftersterilizationuntilreadytouse.

Repeatedprocessinghasminimaleffectontheseattachments.Endoflifeisnormally

determinedbywearanddamageduetouse.

Drythemotorfor30minutesminimumusingthesterilizationdrycycleandallowthemotorto

cooltoroomtemperatureinbagpriortouse.Ifmoistureispresent,increaseyoursterilizerdry

cycleappropriately.

Drying:

Containment andtransportation: Itisrecommendedthathandpiecesarereprocessedassoonasisreasonablypracticalfollowinguse.

Preparation for cleaning: Wearpuncture-resistantglovesandprotectiveeyewear.Aftereachpatient,ushairbyrunning

handpiecemotorfor20seconds.Removemotorfromswivelifapplicableortubing.

Usesteamsterilizationexclusivelyforcompletesterilityasoutlinedbelow.

Disinfection:

SeeInstallation,OperatingRecommendations,and/orTroubleshootingsectionsofthismanual.

Inspection & function testing:

Single:Astandardsterilizationpackagingmaterialmustbeused.Ensurethatthepackislarge

enoughtocontaintheitemwithoutstressingtheseals.

Packaging:

Manufacturer Contact: Seerstorlastpanelsofthismanual.

StarDental®

Instrument Solutions

StarDental®

Instrument Solutions

7LWDQ (



6WDU'HQWDO



7LWDQ (



6WDU'HQWDO



Drive

Air

RedTip

Applicator

ItistheresponsibilityoftheusertouseonlyFDAcompliantsterilizingequipmentandaccessories

thatarecapableofmeetingthemanufacturersrecommendationsbelow.

CAUTION

Troubleshooting

Problem: LACK OF POWER

Cause:  Airpressure

Correction:  Verifyproperhandpieceairpressure.RefertoInstallation.

Cause:  Crimpedtubing

Correction:  Straightentubinginsideandoutsidedeliveryhead.

Cause:  Swivelnotthreadedfullyontotubing

Correction:  RefertoInstallation.

Cause:  Brittlemotororswivelsiliconerubberseal

Correction:  Replacesiliconerubbersealfor2/3-lineswivelwithStarDentalPart#203103

and4-linewithStarDentalPart#202897.

Cause:  SwivelO-ringsworn

Correction:  ReplaceswivelO-rings,StarDentalPart#259884.

Cause:  Debrisbuild-upinhandpiece

Correction:  Cleanhandpiece.RefertoCleaning.

Problem: SWIVEL WILL NOT DISENGAGE FROM HANDPIECE

Cause:  Build-upofdebris

Correction:  Place3dropsofDentaLube II,StarDentalPart#262539,intotheswivel/tubing

connector.Rotateswiveltocirculatelube.Disengagehandpiece.Contactdealer

ifunabletodisengageswivel.Topreventreoccurrence,refertoCleaning.

Note: Ifaproblempersists,contactdealerforfurtherassistanceorcontactStarDental technical

serviceat1-866-DTE-INFO.

AlwaysinsistonStarDentalpartsforbestperformance.

Replacement Part Numbers

Titan 3 Titan T

Description Item Number Item Number

AirPressureGaugefor4/6-Line.....................................................262591............................................................262591

SiliconeRubberSeal,4-Line(Pkg.of3).......................................202897...........................................................202897

DentaLube II............................................................................................262539...........................................................262539

ACCESSORIES

Swivel,Motor2/3-Line.......................................................................260152............................................................260152

Swivel,Motor4-Line............................................................................260144............................................................260144

LubeFreeBallBearingAutoLatchAngle......................................264146........................................................... 263950

LubeFreeBallBearingManualLatchAngle................................262738........................................................... 263948

LubeFreeBallBearingAutochuckFrictionGripAngle..................264151........................................................... 263954

LubeFreeBallBearingManualChuckFrictionGripAngle...........262740

BallBearingAutoLatchAngle..........................................................264182

BallBearingManualLatch.................................................................259005...........................................................263947

BallBearingAutochuckFrictionGripAngle...............................264149

TitanEndodonticAngle,AutoLatch..............................................262570............................................................ 262570

TitanEndodonticAngle,ManualLatch........................................262571............................................................ 262571

For new products, manuals and technical information, call

1-866-DTE-INFO or visit our web site at www.dentalez.com.

Important Notice About

Returning Product To The DentalEZ Inc.

Anyone wishing to return any DentalEZ Inc. product to a DentalEZ facility MUST obtain the proper

RETURN AUTHORIZATION NUMBER from the Customer Service Department. The RA Number must

appear clearly marked on both the outside and inside of the returned product carton. When calling for

a return authorization number you will be asked to provide the following information:

To Obtain A

Return Authorization

Number Call

1-866-DTE-INFO

Items will be evaluated. Return Authorization Number is not a guarantee for credit. Your cooperation

with this procedure will help us expedite processing of any returns.

• Product Name, Model Number or Part Number

• Serial Number of Product

• Dealer Return Purchase Order Number

• Reason For Return

• Copy of Invoice Showing Purchase

Limited Warranty

O-RingsandSealsarespecicallyexcludedfromthiswarranty.

DentalEZ®warrantstheTitan

®-EMotorfor1yearfromthedateofpurchase*.

Pleasenotethefollowingadditionaltermsofourwarrantypolicy:

• Warrantiescovermanufacturingdefectsonlyanddonotcoverdefectsresultingfrom

abuse,improperhandling,cleaning,careormaintenance,normalwearandtearor

non-observanceofoperating,maintenanceorinstallationinstructions.Failure to use

authorized parts or an authorized repair facility voids this warranty.

• Liability is limited to repair or replacement of the defective product at our sole

discretion. All other liabilities, in particular liability for damages, including,

without limitation, consequential or incidental damages are excluded.

• THISWARRANTYISINLIEUOFALLOTHERWARRANTIES,EXPRESSEDORIMPLIED,

INCLUDINGANYIMPLIEDWARRANTIESOFMERCHANTABILITYORFITNESSFORA

PARTICULARPURPOSE.NOEMPLOYEE,REPRESENTATIVEORDEALERISAUTHORIZED

TOCHANGETHISWARRANTYINANYWAYORTOGRANTANYOTHERWARRANTY.

*Providedconditionsinwarrantyaremet.

WARRANTY REGISTRATION

PLEASEVISITTHEWEBSITEBELOWTOREGISTERYOURSTARDENTALPRODUCT.THISWILL

ENSUREPROPERREGISTRATIONANDPROMPTANDACCURATESERVICESHOULDANYOFYOUR

PURCHASESNEEDEVALUATIONORREPAIRDURINGTHEWARRANTYPERIOD.

StarDental®Products:www.dentalez.com/warranty

Este manual sirve para los siguientes modelos

Manuales populares de Motor de otras marcas

Rotax

Rotax 125 senior MAX evo Manual de usuario

Kohler

Kohler K361 Manual de usuario

MTD

MTD OHV Series Manual de usuario

Kohler

Kohler COMMAND CH18-745 Manual de usuario

Mercury

Mercury D4.2L D-Tronic Manual de usuario

Selve

Selve SE Plus-RC Series Manual de usuario

Perkins

Perkins 1206E-E66TA Manual de usuario

Skov

Skov DA 174 Manual

Rossi

Rossi TX11 Series Manual de usuario

Siemens

Siemens SIMOTICS T-1FW3 Hoja de instrucciones

AL-KO

AL-KO PRO 350 Manual de usuario

MTU

MTU 12 V 4000 Lx4 Manual de usuario

Nanni

Nanni N3.30 Manual de instrucciones

Nanni

Nanni N5.160 CR2 Manual de usuario

KSB

KSB SuPreme Series Instrucciones de instalación

Hiwin

Hiwin EM1 Series Manual de usuario

Rotax

Rotax 912 i series Instrucciones de funcionamiento

Siemens

Siemens SIMOTICS XP 1MB1 Manual de usuario