Danby DWM5500W Manual de usuario
Danby Products Ltd.
DWM5500W SWM5500W
SERVICE MANUAL
INDEX
1.
CONTROL OF THE COLLECTOR ELECTRIC MOTORS
2.
DRIVE ELECTRIC MOTOR
3.
THERMOSTAT
4.
PRESSURE SWITCH
5.
POTENTIOMETER
6.
PUMP
7.
HEATER
8.
SOLENOID VALVE
9.
DOOR SWITCH
10.
CONTACTOR
11.
TIMER
12.
FLOW CHART
13.
PRODUCT INFORMATION SHEETS
14.
SERVICE EQUIPMENT
15.
TROUBLE SHOOTING
16.
PARTS LIST AND DIAGRAM
1. CONTROL OF THE COLLECTOR ELECTRIC MOTORS ON WM WITH EL.
REGULATION
When rotor of the electric motor comes into short circuit it is likely that the el.
regulation will get damaged. It is impossible to check short circuit with the multimeter
at the customer due to very low impedance.
To avoid new el. regulation to get damaged is our suggestion to check el. motor as
follows:
Check visual electronic regulation (burnt out components).
Check wiring harness
Connect new el. motor
If it does not rotate and wiring harness is O.K. , change el. regulation.
Before connecting old el. motor, check it as follows:
Visual: burnt out collector, damaged collector – change the el. motor
Adjust wash program to the intermediate spins or final spin on washing machine with
800 – 1000 rpm (with potentiometer or with switch reduce the spin to the minimum).
Intermediate spins perform in steps , it is low possibility of getting el. regulation
damaged due to short circuit of the el. motor rotor coil.
If the rotor coil is in short circuit, there will be sparkling on the collector. If there is no
sparkling, wait for the end of the spin and try again.
2. DRIVE ELECTRIC MOTOR
Tip: FHP U112 G55 USA - universal part No.: 607931
Nominal voltage: 220-240 V, 60 Hz
Nominal mains supply: tumbling phase: 230 W
spinning phase: 47 W
Max. number of revolutions: spin: 12900 rpm
tumbling: 650 rpm
Ohm resistance: Tachogenerator (1-2): 137 ohm
Rotor (3-4): 2.00 ohm
Stator (5-6): 1.36 ohm
Direction of spin rotation (observed in direction of the pulley):
Counter-clockwise: power supply 6 and 3, short circuited 4 and 5
3. THERMOSTAT - ADJUSTABLE
Typ: 55 13019.103 part number: 078624
alternative part numbers: 550914,
530407
Temperature range: 27.5 – 88 +/- 4 °C
Switching capacity: 16(4) A / 250 V
Switching difference: 6 +/- 2.5 °C
wiring diagram:
4. PRESSURE SWITCH - DOUBLE
Type: A2 – 681 part number: 609461
rated level (mm H2O):
contacts: 11-12 11-14 (heater protection)
80 +/-7.5 110 +/- 7.5
contacts: 21-22 21-24 21-26
95 +/-5 130 +/-5 300 +/- 30
wiring diagram:
PRESSURE SWITCH - DOUBLE
Type: A2 – 688 part number: 609462
rated level (mm H2O):
contacts: 11-12 11-14 11-16
120 +/-5 160 +/- 5 300 +/- 30
contacts: 21-22 21-24
150 +/-7.5 190 +/-7.5
wiring diagram:
5. POTENTIOMETER
Typ: PC 6G 22k log part number: 368306
Resistance range: 0-22 K+/- 10%
6. PUMP - SYNCHRONOUS
Typ: part number: 553645
Supply voltage: 208-240 V, 60 Hz
Power: 34 W
Capacity: 16 l/min at nominal voltage
Winding resistance: 95 +/- 7%
7. HEATER
Typ: TUBULAR HEATER šifra: 657139
Voltage: 120 V
El. power: 1300 W
Ohmska upornost: 11 ohm
8. SOLENOID VALVE – SINGLE – WARM WATER
Type: ES 180/88 part number: 550957
Supply voltage: 220/240 V, 50/60 Hz
Coil resistance: 3700 +/-8% (at 20 °C)
Connection of inlet hose: ¾ "
Working pressure: 0.2 – 10 bar
Rated flow: 7 l/min +/-15%
Rated power: 8 VA
SOLENOID VALVE - DOUBLE
Type: ED 180/88 part number: 606715
alternative part numbers: 609396
Supply voltage: 220/240 V, 50/60 Hz
Coil resistance: 3700 +/-8% (at 20 °C)
Connection of inlet hose: ¾ "
Working pressure: 0.2 – 10 bar
Rated flow: 7 +/-10% l/min
Rated power: 8 VA
9. DOOR SWITCH WITH LOCKING DEVICE
Type: ROLD part number: 667490
supply voltage: 120/240 V, 60 Hz
closed: 16 (4) A
open: 0 (0) A
locking: min.2 – max.8 sec. at temperature 20°-35°C after machine
switching on
unlocking: min.35 – max.65 sec. at temperature 20°C after machine
switching off
wiring diagram:
10. CONTACTOR
Type: EBERLE 0419 01 1101 00 part number: 657141
wiring diagram:
Otros manuales para DWM5500W
2
Este manual sirve para los siguientes modelos
1
Tabla de contenidos
Otros manuales de Arandela de Danby
Danby
Danby DWM030WDB-6 Manual de usuario
Danby
Danby DWM17WDB Manual de usuario
Danby
Danby DWM030WDB-6 Manual de usuario
Danby
Danby DWM060WDB Manual de usuario
Danby
Danby DWM055A1WDB-6 Manual de usuario
Danby
Danby DWM055A1WDB-6 Manual de usuario
Danby
Danby DWM17WDB Instrucciones de montaje
Danby
Danby DWM045WDB Instrucciones de montaje
Danby
Danby DWM060WDB Instrucciones de montaje
Danby
Danby DWM12C1WDB Manual de usuario
Danby
Danby DWM045DB Manual de usuario
Danby
Danby DWM5500W Manual de usuario
Danby
Danby DWM99W Manual de usuario
Danby
Danby DTT100A1WDB Instrucciones de montaje
Danby
Danby DWM028WDB-3 Manual de usuario
Danby
Danby Simplicity SWM5500W Manual de usuario
Danby
Danby DWM055WDB Manual de usuario
Danby
Danby DTT420 Manual de operación y mantenimiento
Danby
Danby DWM5500W Manual de usuario
