Daikin SM-12-012 Manual de usuario

Service Manual SM-Inverter_(i)

Air Conditioners

Service Manual

Split Inverter

012

Service Manual SM-Inverter_(i) 2

Inverter Air conditioning technology is today’s solution for superior comfort, higher efficiency and better energy

saving. This Service Manual will intro Daikin Inverter Residential and Light Commercial product.

INVERTER Y Series Single Split (Residential, Light Commercial)

i) INDOORS

ii) OUTDOORS

1.1 INVERTER SINGLE SPLIT

Residential (ATXN/FTXN-LV/FTXN-LV1B9 & ARXN/RXN-LV/RXN-LV1B9):

- High Quality & Efficiency Daikin DC Inverter compressor

- High Performance Daikin Inverter Controller

- 5-speed Step-less Fan operation

- New Inverter-only Remote Control

Piping Length & Elevation

Model

Max. total

piping

length

(m)

Max. height

difference

(m)

Pre-charge

for up to

piping length

(m)

Additional

charge

(g/m)

ARXN/RXN25LV1B(9) 20 10 7.5 20

ARXN/RXN30LV1B(9) 20 10 7.5 20

ARXN/RXN50LV1B(9) 30 10 7.5 20

ARXN/RXN60LV1B(9) 30 10 7.5 20

Terminal Block for outdoor:

- Equipped with 7-segment display to improve serviceability. (Excluded for ARXN/ RXN25/30LV1B(9))

- To retrieve error code & running parameters.

1.0 Introduction

Service Manual SM-Inverter_(i) 3

Disable Auto Random Restart function:

Series I Series II

To disable the auto random restart function, kindly cut off the jumper J_AUTO as highlighted in attachment.

Please be informed that after disable auto random restart, unit is not able to restart with last state memory after

power resume from failure. Unit will revert to default setting as below:

Default setting

Unit: Off

Temperature: 24°C

Fan speed: High

Mode: Cooling

Service Manual SM-Inverter_(i) 4

INDOOR BASIC FUNCTIONS

Residential and Light Commercial

The system has 5 operating modes. The mode selection is done from indoor using handset.

The operating modes are:

•

Cool

•

Heat

•

Fan

•

Auto

•

Dry

Cool Mode:

When Tr

≥

Ts - 1.5°C

•

Comp, Indoor Fan and Outdoor Fan ON.

When Tr

≤

Ts - 2°C

•

Compressor and Outdoor Fan OFF.

Tr = Room Temperature

Ts = Set Temperature

When cooling load is too small and the room temperature still falling below compressor cut off point,

compressor will stop.

2.0 Algorithm and Control

Service Manual SM-Inverter_(i) 5

Heat Mode:

When Ts > Tr - 1.0°C

•

Comp, ID Fan and OD Fan ON.

When Tr

≥

Ts + 1.5°C

•

Compressor and Outdoor Fan OFF.

•

Indoor Fan off if indoor coil

≤

20°C.

Tr = Room Temperature

Ts = Set Temperature

When heating load is too small, and the room temperature still rising above compressor cut off point, compressor

will stop.

FAN MODE

Only High, Medium and Low fan speeds are allowed.

When changing cool mode to fan mode, the compressor will stop and OD fan stops based on fan OFF

control.

Compressor only ON if the minimum stop time is > 3 minutes and the user change back to cool mode.

Fan speed will maintain same as during fan mode.

AUTO MODE

For heat pump only

Mode switching point:

•

Heating



Cooling



≥

Ts + 2.5

•

Cooling



Heating



≤

Ts – 2.5

During initial operation

•

Cooling operation: Tr > Ts

Service Manual SM-Inverter_(i) 6

•

Heating operation: Tr < Ts

ID-OD COMMUNICATION

Master by outdoor unit.

Indoor controller board will transmit signal to outdoor controller board every 0.5s. Outdoor unit will

response to indoor once the valid data is received.

If the data communication line between indoor and outdoor disrupted for 15s continuously, compressor

will stop, OD fan stop with fan OFF timer. ID LED blinks error.

If the communication resumes within 15s, error code is clear and compressor restarts after 3 minutes.

If the communication does not resume after 15s, unit unable to restart and the error keep blinking.

Service Manual SM-Inverter_(i) 7

THERMISTORS IN ARXN/ RXN-LV1B(9)

FUNCTIONS OF THERMISTOR

Thermistor

Functions

Discharge pipe Used for discharge superheat (SH) & EXV control.

Outdoor coil Used for defrost control. Also used for inverter current protection control in

Series II.

Outdoor air Used for defrost & outdoor fan speed control. Also used for PMV, overall

current protection & preheating operation control.

Heat sink Used for capturing heat sink temperature.

Suction pipe Used for EXV (SH) & suction pipe SH protection control in heating.

Gas pipe Used for gas pipe isothermal control in cooling. EXV opening is controlled so

that accurate cooling capacity is achieved in each room.

Liquid pipe Used for sub-cooling control in heating. Actual sub-cooling will be calculated

with liquid pipe & max. heat exchanger temperature among all rooms. EXV

opening is then adjusted to reach the target sub-cooling.

Service Manual SM-Inverter_(i) 8

MINIMUM RUN CONTROL

To prevent frequent compressor ON/OFF & to allow pressure equalization

•The compressor will be on 3 minutes stand-by after turning OFF before it is allowed to turn ON.

•OD fan OFF delay to improve pressure equalization & to prevent refrigerant from entering into

evaporator.

AUTO RESTART

-Factory pre-set.

-Allow unit to automatically resume the same operating mode it was in before a power failure.

4-WAY VALVE CONTROL

-Change over switching is only carried out during operation.

-OFF delayed is applied when the coil switches from ON to OFF.

Operating mode 4-way valve is

Heat, except for defrost ON

Cool

Dry

Defrost

OFF

DEFROST CYCLE

During defrost RXN-LV(1B/1B9)

Compressor ON

4-way valve OFF

EXV in operation room Fixed opening

EXV in operation stop room -

Outdoor fan OFF

Indoor fan OFF

Service Manual SM-Inverter_(i) 9

ATXN/FTXN-LV and ARXN/RXN-LV(1B/1B9):

DEFROST CONTROL

-Condition for entering defrost

•Compressor minimum run time – 6 minutes OR

•Compressor accumulated run time of 45 minutes if Outdoor coil < 3°C.

-Condition for terminating defrost

•OD coil > 12°C or

•Total defrost timer of 650 seconds.

OUTDOOR FAN CONTROL

-Determine from

•Compressor target rotation: higher fan speed with higher rotation.

•Outdoor air temperature.

-Cool mode: Higher fan speed with higher outdoor air temperature.

-Heat mode: Higher fan speed with lower outdoor air temperature.

-When compressor stops, fan OFF delay 30 seconds is carried out

INDOOR COIL FREEZE PREVENTION

-Only available in cooling mode.

-When the indoor coil temperature < 2°C, the compressor starts to drop the frequency.

-This protection will cut in when:

•Indoor coil temperature < 0°C for more than 180s. Compressor will stop, OD fan stop after 30s

and indoor fan can only run at lowest fan speed.

-The unit can only be restarted after 3 minutes.

-When the indoor coil temperature > 13°C, the compressor frequency will be reset based on the OD

ambient, room and set temperature.

Service Manual SM-Inverter_(i) 10

ROTATION REGULATING FUNCTIONS

* Defrost control for heat pump model only

STARTING ROTATION

STARTING CONTROL

-To avoid excessive oil discharge from compressor or to promote oil lubrication during startup.

-To prevent liquid flood back to the compressor.

-To limit starting current.

-When compressor starts to rotate from OFF to ON, compressor rotation is set to run gradually to each

upper limit at a specific timer setting.

Model Max. f

ARXN/RXN25LV1B(9) 68 Hz

ARXN/RXN35LV1B(9) 74 Hz

ARXN/RXN50LV1B(9) 90 Hz

ARXN/RXN60LV1B(9) 93 Hz

Upper limit rotation

Limit Rotation

Lower limit rotation

Target Rotation

Command Rotation

Starting Rotation

∆

Defrost*

Tabla de contenidos

Otros manuales de Acondicionador de aire de Daikin

Daikin

Daikin RXM20R5V1B Cómo utilizar

Daikin

Daikin Inverter FDXS25CVMB Manual de usuario

Daikin

Daikin RE60KV1 Manual de usuario

Daikin

Daikin FTV-A Series Guía de dimensiones

Daikin

Daikin FVXG25K2V1B Manual de usuario

Daikin

Daikin SUPER MULTI NX CTXS09HVJU Manual de usuario

Daikin

Daikin R-410A Manual de usuario

Daikin

Daikin FHQ35BWV1B Manual de usuario

Daikin

Daikin Stylish FTXA20BB/RXA20A Manual de usuario

Daikin

Daikin 4AMX80E7V3B Manual de usuario

Daikin

Daikin VAM350J8VEB Manual de usuario

Daikin

Daikin RP200B8W1 Manual de usuario

Daikin

Daikin FXMQ20PVE Manual de usuario

Daikin

Daikin SkyAir FAQ18TAVJU Manual de usuario

Daikin

Daikin FTXN-LV Manual de programación

Daikin

Daikin RKD50BVM Manual de usuario

Daikin

Daikin FTKS09HV2S Manual de usuario

Daikin

Daikin FTKA25VAVMV Manual de usuario

Daikin

Daikin SB.RKXYQ-T Manual de instrucciones

Daikin

Daikin FTKS50BVMA8 Manual de usuario

Daikin

Daikin IM 1193 Manual de instrucciones

Daikin

Daikin Si001554EC Manual de usuario

Daikin

Daikin FXFQ32PVE Manual de usuario

Daikin

Daikin 2MXM68A2V1B Cómo utilizar

Manuales populares de Acondicionador de aire de otras marcas

Spheros

Spheros CC 355 Manual de usuario

Bosch

Bosch Climate 5000 SCI 24 CAS/ OU- OUE Manual de usuario

Panasonic

Panasonic CS-E12HKEW Manual de usuario

nedis

nedis ACMB1WT7 Manual de usuario

Samsung

Samsung AR KV Series Guía

Fujitsu

Fujitsu Inverter ASBA30JFC Manual de usuario

Toshiba

Toshiba RAS-M10SMUV-E Manual de usuario

Hitachi

Hitachi RAS-E24CAK Manual de usuario

CIAT

CIAT Magister 2 Series Guía

Bestron

Bestron AAC6000 Manual de usuario

Hisense

Hisense 7K Manual técnico

Frigidaire

Frigidaire FFRE0533S1E0 Manual de usuario

Samsung

Samsung AS09HM3N Manual de usuario

Frigidaire

Frigidaire CRA073PU11 Manual del propietario

Soleus Air

Soleus Air GB-PAC-08E4 Manual de usuario

McQuay

McQuay MCK020A Manual de usuario

Webasto

Webasto Frigo Top 25 DS Manual de usuario

Frigidaire

Frigidaire FAZ12ES2A Manual de usuario