Daikin FT24KV2S Manual de usuario
REMOVAL
PROCEDURE
SERVICE MANUAL
Indoor Unit
Inverter / Non-Inverter
Wall Mounted Type
5.0/6.0/7.1 kW Class
24000 Btu/h Class
Si041055
Service Manual
Removal Procedure
Indoor Unit
zCooling Only zHeat Pump
FT24KV2S FTX50GV1B
FTX60GV1B
FT50GV1G6 FTX71GV1B
FT60GV1G6
FTX50JVLT
FTK50JVLT
FTXN50KV1B
FTE50KV16 FTXN60KV1B
FTE60KV16
FTYN50HV1A
FTN50HV1A FTYN60HV1A
FTN60HV1A
FTN50JV18
FTN60JV18
Si041055
Removal Procedure 1
Table of Contents
1. Removal of Air Filters / Front Panel ........................................................2
2. Removal of Front Grille ...........................................................................5
3. Removal of Horizontal Blades / Vertical Blades......................................7
4. Removal of Electrical Box / PCBs / Swing Motors ..................................9
5. Removal of Indoor Heat Exchanger......................................................15
6. Removal of Fan Motor / Fan Rotor........................................................18
Note: The illustrations may be slightly different depending on the model.
Removal of Air Filters / Front Panel Si041055
2Removal Procedure
1. Removal of Air Filters / Front Panel
Procedure Warning Be sure to wait for 10 minutes or more after turning off all power
supplies before disassembling work.
Step Procedure Points
1. Appearance features
Warning
Dangerous: High voltage
A high voltage is applied to all
the electric circuits of this
product including
thermistors.
When the signal receiver
catches a signal from the
remote controller, the
receiving tone sounds and
the operation lamp blinks
immediately to confirm the
signal reception.
When the [ON/OFF] button
is kept pressed for 5
seconds, the forced cooling
operation is performed for
about 15 minutes.
Some models have no
HOME LEAVE lamp.
2. Remove the air filters.
1Open the front panel to
the position where it
stops.
2
3
Slightly push up the
center knob of the air
filter and unfasten the
hooks.
Pull out the air filter
downward and remove
it.
The air filter is not marked
for difference between the
right and left sides.
Insert the air filter with the
"FRONT" mark faced up.
The air filter can be set
easily by inserting it along
the guides.
Be sure to insert the hooks
(at 2 lower positions) when
mounting the air filter.
(R12786)
Operation lamp
Signal receiver
TIMER lamp
[ON/OFF] button
(R17229)
Room temperature thermistor
HOME LEAVE
lamp
(R6701)
Front panel
Air filter
(R6702)
Si041055 Removal of Air Filters / Front Panel
Removal Procedure 3
3. Remove the Titanium
apatite photocatalytic air-
purifying filters.
The right and left filters are
interchangeable.
Some models have no
Titanium apatite
photocatalytic air-purifying
filter.
Some models have Air-
purifying filters with
photocatalytic deodorizing
function instead.
Some models have air filters
only.
1Push up the bottom of
the Titanium apatite
photocatalytic air-
purifying filter to
unfasten the hooks (2
on lower, 3 on upper)
and take the filter out.
Step Procedure Points
Hook
Hook
(R2751)
Titanium apatite
photocatalytic air-
purifying filter
(R12788)
Removal of Air Filters / Front Panel Si041055
4Removal Procedure
4. Remove the front panel.
1While opening the front
panel further than it
stops, release both the
shafts and remove the
front panel.
Slide the front panel from
side to side to release each
shaft.
When reassembling the front
panel, fit the right and left
rotary shafts one by one into
the grooves and fully push
them into position.
Step Procedure Points
(R2753)
(R2754)
(R2755)
Si041055 Removal of Front Grille
Removal Procedure 5
2. Removal of Front Grille
Procedure Warning Be sure to wait for 10 minutes or more after turning off all power
supplies before disassembling work.
Step Procedure Points
1. Remove the service
cover.
Preparation
Remove the front panel
according to "Removal of the
Air Filters / Front Panel".
You can remove the front
grille without detaching the
service cover.
1Remove the screw and
remove the service
cover.
2. Remove the front grille.
1Remove the 3 screws
of the front grille.
Refer to the removal
procedure in a reverse way
when reassembling.
Service cover (R2756)
(R2757)
(R2758)
Front grille
Removal of Front Grille Si041055
6Removal Procedure
2Unfasten the 3 hooks
on the top of the front
grille.
The convex marks (...) on
the front panel indicate the
position of the hooks.
3Pull the upper part of
the front grille out and
lift the lower part up,
and then remove the
front grille.
Make sure that all the 3
hooks are engaged securely
when reassembling.
Step Procedure Points
Hook
(R2759)
Hook
(R2760)
(R2761)
(R2762)
Si041055 Removal of Horizontal Blades / Vertical Blades
Removal Procedure 7
3. Removal of Horizontal Blades / Vertical Blades
Procedure Warning Be sure to wait for 10 minutes or more after turning off all power
supplies before disassembling work.
Step Procedure Points
1. Remove the horizontal
blades.
1Open the horizontal
blades.
2Bend the horizontal
blade slightly and
release the center
shaft. (2 locations)
Remove both the horizontal
blades (upper and lower) in
the same way.
3Release the left shaft.
4Slide the horizontal
blade to the left and
release the right shaft.
Installation procedure
1. Since the key pattern hook is
provided, rotate the blade
and fit it to the right shaft
first.
2. Fit the blade to the center
and left shafts.
Horizontal blade
(R6703)
(R2765)
Center shaft
Left shaft
Center shaft
(R12894)
Right shaft
(R2766)
Removal of Horizontal Blades / Vertical Blades Si041055
8Removal Procedure
2. Remove the vertical
blades.
The unit has 3 sets of
vertical blades linked to one
another with interlock rods.
1Release the right and
left shafts.
2Unfasten the 3 hooks
for each set of vertical
blades.
3Pull the vertical blades
rightward and remove
them.
Step Procedure Points
Vertical blade
(R6705)
Hook
(R2768)
(R6706)
Este manual sirve para los siguientes modelos
17
Tabla de contenidos
Otros manuales de Acondicionador de aire de Daikin
Daikin
Daikin FTHF50VVMV Manual de usuario
Daikin
Daikin FXSQ-PAVE Guía de dimensiones
Daikin
Daikin FTXJ20LV1BW Manual de usuario
Daikin
Daikin FTKS20D3VMW Manual de usuario
Daikin
Daikin RXYSCQ4TMV1B Manual de usuario
Daikin
Daikin SkyAir FCQ18PVJU Manual de usuario
Daikin
Daikin RKS30HVJU Manual de usuario
Daikin
Daikin FHB35FK7V1 Manual de usuario
Daikin
Daikin VRV FXTQ12PVJU Manual de usuario
Daikin
Daikin RXQ5P7W1B Manual de usuario
Daikin
Daikin FBQ35B8V1 Manual de instrucciones
Daikin
Daikin FH(Y)C35FVE Manual de usuario
Daikin
Daikin R410A SPLIT SERIES FTXN25LV1B Manual de usuario
Daikin
Daikin FXZQ20M9V1B Manual de usuario
Daikin
Daikin Altherma 3 R F Manual de usuario
Daikin
Daikin FDQ125C7VEB Manual de usuario
Daikin
Daikin SIESTA SERIES Manual de usuario
Daikin
Daikin FTXN09KEVJU Manual de usuario
Daikin
Daikin RXYSQ6T7Y1B9 Manual de usuario
Daikin
Daikin FTD20JEV1K Manual de usuario
