Daikin FT15HV2S Manual de usuario

REMOVAL

PROCEDURE

SERVICE MANUAL

Indoor Unit

Inverter / Hybrid /

Non-Inverter

Wall Mounted Type

4.2/5.0/6.0/7.1/8.0/9.0 kW Class

15000 Btu/h Class

Si04-855

Service Manual

Removal Procedure

Indoor Unit

zCooling Only zHeat Pump

FT15HV2S FTXS50FVLT

FTXS60FVLT

FT50GV1G FTXS71FVLT

FT60GV1G

FTXS50FVMA

FTKE15GV2S FTXS60FVMA

FTXS71FVMA

FTKE42GV1 FTXS80FVMA

FTXS90FVMA

FTKS50FVLT

FTKS60FVLT FTXS50GVMA

FTKS71FVLT FTXS60GVMA

FTXS71GVMA

FTKS50FVM FTXS80GVMA

FTKS60FVM

FTKS71FVM FTYN50GV1A

FTYN60GV1A

FTKS50FVMA FTYN71GV1A

FTKS60FVMA

FTKS71FVMA

FTKS50GVMA

FTKS60GVMA

FTKS71GVMA

FTKS50GVMG

FTKS60GVMG

Si04-855

Removal Procedure 1

Table of Contents

1. Removal of Air Filters / Front Panel ........................................................2

2. Removal of Front Grille ...........................................................................5

3. Removal of Horizontal Blades / Vertical Blades......................................7

4. Removal of Electrical Box / PCBs / Swing Motors ..................................9

5. Removal of Indoor Heat Exchanger ......................................................15

6. Removal of Fan Motor / Fan Rotor........................................................18

Note: The illustrations may be slightly different depending on the model.

Removal of Air Filters / Front Panel Si04-855

2Removal Procedure

1. Removal of Air Filters / Front Panel

Procedure Warning Be sure to wait for 10 minutes or more after turning off all power

supplies before disassembling work.

Step Procedure Points

1. Appearance features

Warning

Dangerous: High voltage

A high voltage is applied to all

the electric circuits of this

product including

thermistors.

When the signal receiver

catches a signal from the

remote controller, the

receiving tone sounds and

the operation lamp blinks

immediately to confirm the

signal reception.

When the [ON/OFF] button

is kept pressed for 5

seconds, the forced cooling

operation is performed for

about 15 minutes.

Some models have no

HOME LEAVE lamp.

2. Remove the air filters.

1Open the front panel to

the position where it

stops.

Slightly push up the

center knob of the air

filter and unfasten the

hooks.

Pull out the air filter

downward and remove

it.

The air filter is not marked

for difference between the

right and left sides.

Insert the air filter with the

"FRONT" mark faced up.

The air filter can be set

easily by inserting it along

the guides.

Be sure to insert the hooks

(at 2 lower positions) when

mounting the air filter.

(R12786)

Operation lamp

Signal receiver

TIMER lamp

[ON/OFF] button

(R17229)

Room temperature thermistor

HOME LEAVE

lamp

(R6701)

Front panel

Air filter

(R6702)

Si04-855 Removal of Air Filters / Front Panel

Removal Procedure 3

3. Remove the Titanium

apatite photocatalytic air-

purifying filters.

The right and left filters are

interchangeable.

Some models have no

Titanium apatite

photocatalytic air-purifying

filter.

Some models have Air-

purifying filters with

photocatalytic deodorizing

function instead.

Some models have air filters

only.

1Push up the bottom of

the Titanium apatite

photocatalytic air-

purifying filter to

unfasten the hooks (2

on lower, 3 on upper)

and take the filter out.

Step Procedure Points

Hook

(R2751)

Titanium apatite

photocatalytic air-

purifying filter

(R12788)

Removal of Air Filters / Front Panel Si04-855

4Removal Procedure

4. Remove the front panel.

1While opening the front

panel further than it

stops, release both the

shafts and remove the

front panel.

Slide the front panel from

side to side to release each

shaft.

When reassembling the front

panel, fit the right and left

rotary shafts one by one into

the grooves and fully push

them into position.

Step Procedure Points

(R2753)

(R2754)

(R2755)

Si04-855 Removal of Front Grille

Removal Procedure 5

2. Removal of Front Grille

Procedure Warning Be sure to wait for 10 minutes or more after turning off all power

supplies before disassembling work.

Step Procedure Points

1. Remove the service

cover.

Preparation

Remove the front panel

according to "Removal of the

Air Filters / Front Panel".

You can remove the front

grille without detaching the

service cover.

1Remove the screw and

remove the service

cover.

2. Remove the front grille.

1Remove the 3 screws

of the front grille.

Refer to the removal

procedure in a reverse way

when reassembling.

Service cover

(R2756)

(R2757)

(R2758)

Front grille

Removal of Front Grille Si04-855

6Removal Procedure

2Unfasten the 3 hooks

on the top of the front

grille.

The convex marks (...) on

the front panel indicate the

position of the hooks.

3Pull the upper part of

the front grille out and

lift the lower part up,

and then remove the

front grille.

Make sure that all the 3

hooks are engaged securely

when reassembling.

Step Procedure Points

Hook

(R2759)

Hook

(R2760)

(R2761)

(R2762)

Si04-855 Removal of Horizontal Blades / Vertical Blades

Removal Procedure 7

3. Removal of Horizontal Blades / Vertical Blades

Procedure Warning Be sure to wait for 10 minutes or more after turning off all power

supplies before disassembling work.

Step Procedure Points

1. Remove the horizontal

blades.

1Open the horizontal

blades.

2Bend the horizontal

blade slightly and

release the center

shaft. (2 locations)

Remove both the horizontal

blades (upper and lower) in

the same way.

3Release the left shaft.

4Slide the horizontal

blade to the left and

release the right shaft.

Installation procedure

1. Since the key pattern hook is

provided, rotate the blade

and fit it to the right shaft

first.

2. Fit the blade to the center

and left shafts.

Horizontal blade

(R6703)

(R2765)

Center shaft

Left shaft

Center shaft

(R12894)

Right shaft

(R2766)

Removal of Horizontal Blades / Vertical Blades Si04-855

8Removal Procedure

2. Remove the vertical

blades.

The unit has 3 sets of

vertical blades linked to one

another with interlock rods.

1Release the right and

left shafts.

2Unfasten the 3 hooks

for each set of vertical

blades.

3Pull the vertical blades

rightward and remove

them.

Step Procedure Points

Vertical blade

(R6705)

Hook

(R2768)

(R6706)

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Acondicionador de aire de Daikin

Daikin

Daikin RXM09VVJU Manual de usuario

Daikin

Daikin RXQ14P7W1B Manual de usuario

Daikin

Daikin Super Multi NX FFQ25B8V1B Manual de usuario

Daikin

Daikin RZQ24MVJU Manual de usuario

Daikin

Daikin vrv III -Q Series Manual de usuario

Daikin

Daikin RXS30HVJU Manual de usuario

Daikin

Daikin RTSYQ10PY1 Manual de usuario

Daikin

Daikin Altherma EABH16DA9W Manual de usuario

Daikin

Daikin RZQG100L9V1B Manual de usuario

Daikin

Daikin VRV IV-S RXYSQ6TMYFK Manual de usuario

Daikin

Daikin FVQ71BV1B Manual de usuario

Daikin

Daikin Inverter FLKS25BVMB Manual de usuario

Daikin

Daikin Super Multi NX FTXS60GV1B Manual de usuario

Daikin

Daikin Super Multi NX 3MKS50E3V1B Manual de usuario

Daikin

Daikin FXUQ71AVEB9 Manual de usuario

Daikin

Daikin FTXJ25T2VMAW Manual de usuario

Daikin

Daikin FH35GZ Manual de instrucciones

Daikin

Daikin RZQSG-L3/9V1 Manual de instrucciones

Daikin

Daikin FTXJ20MV1BW Manual de usuario

Daikin

Daikin FTXN24KVJU Manual de usuario

Daikin

Daikin VRV III-Q RQYQ140PY1 Manual de usuario

Daikin

Daikin RXJ42A2V1B Manual de usuario

Daikin

Daikin FXKQ25MVE Manual de usuario

Daikin

Daikin FTKF09XV2S Manual de usuario

Manuales populares de Acondicionador de aire de otras marcas

Spheros

Spheros CC 355 Manual de usuario

Bosch

Bosch Climate 5000 SCI 24 CAS/ OU- OUE Manual de usuario

Panasonic

Panasonic CS-E12HKEW Manual de usuario

nedis

nedis ACMB1WT7 Manual de usuario

Samsung

Samsung AR KV Series Guía

Fujitsu

Fujitsu Inverter ASBA30JFC Manual de usuario

Toshiba

Toshiba RAS-M10SMUV-E Manual de usuario

Hitachi

Hitachi RAS-E24CAK Manual de usuario

CIAT

CIAT Magister 2 Series Guía

Bestron

Bestron AAC6000 Manual de usuario

Hisense

Hisense 7K Manual técnico

Frigidaire

Frigidaire FFRE0533S1E0 Manual de usuario

Samsung

Samsung AS09HM3N Manual de usuario

Frigidaire

Frigidaire CRA073PU11 Manual del propietario

Soleus Air

Soleus Air GB-PAC-08E4 Manual de usuario

McQuay

McQuay MCK020A Manual de usuario

Webasto

Webasto Frigo Top 25 DS Manual de usuario

Frigidaire

Frigidaire FAZ12ES2A Manual de usuario