Code Blue CB 5 Series Manual de servicio
800.205.7186 •www.codeblue.com
Administrator Guide
Installation | Configuration | Operation | Troubleshooting
CB 5 Series
Code Blue •259 Hedcor Street •Holland, MI 49423 USA •800.205.7186 •www.codeblue.com GU-158-Mpage 2 of 50
CB 5 Series
Administrator Guide
WARNING
ONLY QUALIFIED PERSONNEL SHOULD INSTALL THESE UNITS. THE INSTALLATION
SHOULD CONFORM TO ALL LOCAL CODES. IN SOME COUNTRIES, A CERTIFIED ELECTRI-
CIAN MAY BE REQUIRED.
NOTICE TO USERS
Copyright © Code Blue Corporation. All rights reserved. This guide or software described herein, in
whole or part, shall not be reproduced, translated or reduced to any machine-readable form without
prior written approval from Code Blue Corporation.
CODE BLUE CORPORATION PROVIDES NO WARRANTY WITH REGARD TO THIS GUIDE, THE
SOFTWARE OR OTHER INFORMATION CONTAINED HEREIN AND HEREBY EXPRESSLY DIS-
CLAIMS ANY IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR ANY PARTICU-
LAR PURPOSE WITH REGARD TO THIS GUIDE, THE SOFTWARE OR SUCH OTHER INFORMA-
TION. IN NO EVENT SHALL CODE BLUE CORPORATION BE LIABLE FOR ANY INCIDENTAL,
CONSEQUENTIAL, OR SPECIAL DAMAGES, WHETHER BASED ON TORT, CONTRACT, OR
OTHERWISE, ARISING OUT OF OR IN CONNECTIONS WITH THIS GUIDE, THE SOFTWARE
OR OTHER INFORMATION CONTAINED HEREIN OR THE USE THEREOF.
Code Blue Corporation reserves the right to make any modications to this guide or the information
contained herein at any time without notice. The software described herein may also be governed
by the terms of a separate user license agreement.
Code Blue®is a registered trademark of Code Blue Corporation.
Code Blue •259 Hedcor Street •Holland, MI 49423 USA •800.205.7186 •www.codeblue.com GU-158-Mpage 3 of 50
CB 5 Series
Administrator Guide
Table of Contents
(NOTE: Phone programming instructions can be found in the IP5000 and IA4100 Guides.)
Section Page
2 Introduction........................................................................................... 5
3 Getting Started...................................................................................... 7
4 Spare Parts............................................................................................ 9
5 Power Requirements..............................................................................11
6 Legacy Power Requirements................................................................14
7 Software Conguration.........................................................................16
8 CB 5-s Low Voltage Exploded View.....................................................17
9 CB 5-s High Voltage Exploded View....................................................18
10 CB 5-p Low Voltage Exploded View.....................................................19
11 CB 5-p High Voltage Exploded View....................................................20
12 CB 5-s with Decorative Top Low Voltage Exploded View..................21
13 CB 5-s with Decorative Top High Voltage Exploded View.................22
14 How to Replace LED Light Connectors...............................................23
15 CB 5-s and CB 5-p Installation Instructions........................................25
16 CB 5 Series Tower Base Gasket Installation Instructions...................27
17 CB 5-s with Public Address Installation Instructions.........................29
18 CB 5-s with Decorative Top Installation Instructions.........................30
19 CB 5 Series Anchor Bolt Installation Instructions..............................32
20 CB 5 Overhead Camera Mount Installation Instructions....................33
21 S-1000/S-1050 Installation Instructions................................................35
22 PoE Installation Instructions..................................................................37
23 CB 5 Series Deck Mount Installation Instructions...............................38
24 CB 5-s and CB 5-p 24V or Multi-Tap Power Brick Wiring (prior to 2015)...39
25 CB 5-s and CB 5-p Standard Wiring (after 2015) (with 24V Fuse Block)...............40
26 CB 5-s and CB 5-p Standard Wiring (prior to 3/2013) (with Hammond Transformer).41
27 CB 5 Series Standard Wiring Diagram (after 2015) (with Triad Transformer)........42
28 CB 5 Series with Public Address Wiring...............................................43
29 Multi-Tap Transformer Wiring................................................................45
30 Maintenance Schedule...........................................................................46
31 Locating Unit Serial Numbers...............................................................48
Code Blue •259 Hedcor Street •Holland, MI 49423 USA •800.205.7186 •www.codeblue.com GU-158-Mpage 4 of 50
CB 5 Series
Administrator Guide
32 Warranty...................................................................................................49
33 Download Information............................................................................50
Code Blue •259 Hedcor Street •Holland, MI 49423 USA •800.205.7186 •www.codeblue.com GU-158-Mpage 5 of 50
CB 5 Series
Administrator Guide
2 Introduction
Thank you for choosing the CB 5 Series for your Code Blue application.
The CB 5 Series Help Points®are the original Code Blue pedestal units that set the industry
standard for rugged construction, full feature availability and high visibility. The CB 5 Series is
easily recognized throughout a full 360-degree area. The high output strobe is easily identiable by
security when activated.
The CB 5 Series is an excellent choice for walkways, parks, college and commercial campus areas,
open landscape areas and anywhere a freestanding pedestal unit is required.
The exclusive analog InterAct and VoIP speakerphones are designed for maximum reliability,
vandal resistance, auxiliary functions, mass notication control, and fault monitoring and reporting
capability. (See IA4100 or IP5000 guides for more information.)
Our unmistakable craftsmanship makes our Help Points® the most rugged on the market,
withstanding the punishment of natural and man-made disasters. With durable construction, our
pedestal units can meet any requirement or purpose. CB 5 Series units have a rugged steel
construction, industrial engineering grade reective graphics and weather, UV and grafti resistant
paint.
Other options include:
• IP and analog phones
• 360° Public Address Speaker (PAS)
• Overhead Camera Mount
• Strobe Cage
Code Blue •259 Hedcor Street •Holland, MI 49423 USA •800.205.7186 •www.codeblue.com GU-158-Mpage 6 of 50
CB 5 Series
Administrator Guide
This guide contains all of the CB 5 Series information. This guide contains a general overview of the
CB 5 Series options and its applications, installation and wiring.
CB 5-s with
Decorative Top
CB 5-s CB 5-pCB 5-s with
Public Address
Code Blue •259 Hedcor Street •Holland, MI 49423 USA •800.205.7186 •www.codeblue.com GU-158-Mpage 7 of 50
CB 5 Series
Administrator Guide
3 Getting Started
Basic Install Instructions
1. EIA/TIA, ANSI, CSA and BICSI cabling or similar standards shall be adhered to for proper
operation of Code Blue communication devices connected to copper or ber infrastructures.
Communications cable and electrical cable in the same conduit is not an acceptable instal-
lation and shall not be supported. Analog phones require a minimum of 23mA for proper
operation (26-29mA recommended).
2. Each analog speakerphone requires its own phone line or PBX extension. Multiple units
shall not be supported.
3. Speakerphones require programming before operation. Consult the User Guide or Admin-
istrator Guide enclosed with the unit or visit www.codeblue.com > Support > Downloads to
read or download manuals.
4. If you are installing IP speakerphones, please read the appropriate manuals and consult
with your Network Administrator.
5. Size electrical wiring based on length of run.
6. Consult the enclosed document packet for internal wiring instructions.
What’s Included
Quantity Part Description
1 Anchor Bolt Kit (3 L-Bolts, 6 Washers, 3 Hex Nuts, 1 Cardboard Template)
1 Security Bit
1 Enclosure
2 Access Door Screws
1 URL listing sheet of Installation, Programming, Wiring & Warranty locations
1 PAS Top (PAS Option Only)
1Dome Top Assembly (Solar not Available)
1Decorative Top Assembly w/Strobe
Code Blue •259 Hedcor Street •Holland, MI 49423 USA •800.205.7186 •www.codeblue.com GU-158-Mpage 8 of 50
CB 5 Series
Administrator Guide
CB 5-s, CB 5-p Tools Required
1. Ladder to reach the top of the units
2. Drill and security bit for removing and inserting security screws on phone, dome top and
access door
3. 11/8 socket set and extension for installing anchor bolts or Deck Mount Kits
4. Phillips head screwdriver and at head screwdriver
CB 5-s with Public Address Tools Required
1. Ladder to reach the top of the units
2. Drill and security bit for removing and inserting security screws on phone and
access door
3. 11/8 socket set and extension for installing anchor bolts
4. Phillips head screwdriver and at head screwdriver
5. 3/8 socket set to mount the mounting plate containing the new toroid transformer
6. 6mm Allen Wrench small black for adapter ring
7. 9/16 inch Wrench for painted ring bolts
CB 5-s with Decorative Top Tools Required
1. Ladder to reach the top of the units
2. Drill and security bit for removing and inserting security screws on phone, dome top and
access door
3. 11/8 socket set and extension for installing anchor bolts
4. Phillips head screwdriver and at head screwdriver
Code Blue •259 Hedcor Street •Holland, MI 49423 USA •800.205.7186 •www.codeblue.com GU-158-Mpage 9 of 50
CB 5 Series
Administrator Guide
4 Spare Parts
CB 5-s
Part Part Number
LED Strobe Light 40159
LED Faceplate Light 40196
Faceplate Screws 41544 (6pk)
Access Door Screws 41545 (2pk)
Manifold R/B 5-way 40101
Analog Surge Suppressor 41471
IP Surge Suppressor 41421
CB 5-p
Part Part Number
LED Strobe Light 40159
LED Faceplate Light 40196
Faceplate Screws 41544 (6pk)
Access Door Screws 41545 (2pk)
Manifold R/B 5-way 40101
Analog Surge Suppressor 41471
IP Surge Suppressor 41421
Strobe Guard 44022
CB 5-s with Public Address
Part Part Number
LED Strobe Light 40159
LED Faceplate Light 40196
Faceplate Screws 41544 (6pk)
Access Door Screws 41545 (2pk)
Analog Surge Suppressor 41471
IP Surge Suppressor 41421
PAS Toroid Transformer 41121
Dome Top Lens w/active vent 40007
PAS 120V Amp Assembly 40010
Code Blue •259 Hedcor Street •Holland, MI 49423 USA •800.205.7186 •www.codeblue.com GU-158-Mpage 10 of 50
CB 5 Series
Administrator Guide
CB 5-s with Decorative Top
Part Part Number
LED Strobe Light 40159
LED Faceplate Light 40196
Faceplate Screws 41544 (6pk)
Access Door Screws 41545 (2pk)
Manifold R/B 5-way 40101
Analog Surge Suppressor 41471
IP Surge Suppressor 41421
CB 5 Series Additional Options
Part Part Number
Overhead Camera Mount Need Color for Part#
Multi Tap Transformer (powers accessories) 120V, 240V, 277V 40104
Blank Lexan Plate Assembly 40067
Service Plate - Lexan w/graphics (This Location Being Serviced) 40208
Deck Mount Kit 40063
Triad Transformer 40V A 120V (will not power accessories) 41246
S-1050 LED Strobe Photo Cell 40542
PoE Power Splitter Kit Assembly 41574
IP5000 Speakerphone FP1 50101
IP5000 Speakerphone FP2 50102
Keypad IP5000 Speakerphone 50103
IA4100 Speakerphone FP1 50001
IA4100 Speakerphone FP2 50002
Keypad IA4100 Speakerphone 50003
Otros manuales para CB 5 Series
1
Este manual sirve para los siguientes modelos
2
Tabla de contenidos
Manuales populares de Equipo de iluminación de otras marcas
Qazqa
Qazqa Suplux SL 3 Black 103062 Manual de usuario
Commercial Electric
Commercial Electric 54568141 Manual de usuario
CREE LIGHTING
CREE LIGHTING 304 Series Manual de usuario
Goobay
Goobay 49867 Manual de usuario
ECOMAN ITALIA
ECOMAN ITALIA LED T8 Manual de usuario
Alkalite
Alkalite Krypton KT-81 Manual de usuario
