Cleveland 24-CDP-10 Manual de usuario

Cleveland

™

Project ________________________________

Item __________________________________

Quantity _______________________________

FCSI Section ____________________________

Approval _______________________________

Date __________________________________

1333 East 179 St.,

Cleveland, Ohio, U.S.A. 44110

Tel: 1-216-481-4900

Fax: 1-216-481-3782

Web Site: www.ClevelandRange.com

Email: Steam@ClevelandRange.com

STEAMCRAFT®GENERATOR STYLE

HIGH SPEED CONVECTION STEAMERS

MODEL: c24-CDP-10

Cleveland Standard Features

nCooking Capacity for up to ten 12˝ x 20˝ x 21⁄2˝ deep

Cafeteria Pans.

nDurable 14 Gauge Stainless Steel Construction:

For compartment door, cavity and front.

nOne 60 Minute Electro-Mechanical Timer and Switch

for manual operation. Audible signal for cooking time

completion.

nSeparate Switch for Power “on/off.”

nExclusive Steam Cooking Distribution System: Exclusive

Brass Steam Jets produce a high velocity convection steam

without fans. Coved Corner design in cooking compartment

distributes heat evenly, and is easy to keep clean. Creased

top & bottom enhance drainage. Cold Water Condenser for

each compartment maintains a dry steam. Fully insulated

cooking compartment for thermal efficiency. Removable

Stainless Steel Slide Racks.

nExclusive “Cool to the Touch” Compartment Door

Design: Free floating inner door with reversible door gasket

provides an air tight seal. Stainless Steel Slam/Latch Door

Latch mechanism for reliability.

nCondensate Drip Trough: Provided under lower

compartment door to collect condensate.

nLeft Hand Door Hinging: Compartment Doors hinged left,

control on the right.

nMoisture Separator for incoming steam.

nPressure reducing Valve or 20-50 psi steam supply

pressure, based on a 3⁄4˝ line size.

nSingle Cold water Connection.

nNSF Certified 6˝ Stainless Steel Legs with adjustable

flanged feet for a one inch level adjustment.

nStandard voltage for controls: 115 volts, 60 Hz. single

phase.

oClean non-toxic, uncontaminated steam is required for all

“Direct Steam” steamers.

Options & Accessories

pSecond Pressure Reducing Valve for 50-120 psi steam

pressure. (PRV)

Shall be CLEVELAND,

SteamCraft



Ultra 10

, two compartments,

Direct Steam Floor Model Steamer, Model 24-CDP-10, single, large

capacity Pressureless Convection Steamer. Choice of Compartment

Controls, Manual By Pass Operation Mode, Compensating

Thermostat, Exclusive Cold Water Condenser design, Type 430

Stainless Steel exterior and cooking compartments.

pRight Hand Door Hinging, Controls on the Right (DHR)

pElectronic Timer with Compensating Load Feature (ETC)

pON/OFF Steam Switch only for compartment controls (MC)

p10˝ Stainless Steel Legs (LF10)

pCompartment Door Steam Shut Off Switch (SCS)

pCafeteria Pans in depths of 1˝, 21⁄2˝, 4˝

and 6˝

pWater Filters

pCorrectional Packages

Short Form Specifications

SteamCraft ®Ultra 10 D

TWO COMPARTMENT FLOOR MODEL DESIGN

PRESSURELESS CONVECTION STEAMER

DIRECT STEAM, 24˝ WIDE DESIGN

SECT. IV PAGE 21

0707

UTILITY CONNECTIONS

ELECTRIC

115V - 1 Phase

Controls - 51 Watts

(NOT TO SCALE)

SECT. IV PAGE 22

0707

Litho in U.S.A.

DIRECT STEAM COLD WATER DRAINAGE

35 psi minimum

60 psi maximum

3⁄4˝ Dia. NPT for

Condenser

11⁄2˝ Dia.

Do not connect other units

to this drain.

Drain must not be located

beneath the steamer itself.

No PVC pipe for drain.

Steam supply:

Furnish 3⁄4˝ IPS minimum line.

20 to 50 psi minimum required.

For pressures between 50 to 120 psi, on additional

Pressure Reducing Valve must be specified.

10 — 12˝ x 20˝ x 21⁄2˝ Cafeteria Pans or

20 — 12˝ x 20˝ x 1˝ Cafeteria Pans or

26 — 12˝ x 20˝ x 4˝ Cafeteria Pans

TOTAL CAPACITY (2 Compartments)

Electrical Supply Drain: 1.50˝ Dia.

Water Supply for Condenser

⁄

˝ Dia. NPT

Steam Supply: 0.75˝ Dia.

Each Compartment has

capacity for:

• Five, 12˝ x 20˝ x 21⁄2˝ deep

Cafeteria Pans.

WATER QUALITY

REQUIREMENTS

The quality of water varies

greatly from region to region.

Steam equipment generators

must be drained daily and

chemically descaled periodically

to ensure proper operation. To

minimize service problems

caused by the accumulation of

minerals and chemicals in water

review the following quality

guidelines with a local water

treatment specialist. Inlet water

that is beyond these specified

guidelines should be treated to

achieve these acceptable limits.

Total Dissolved Solids less than

60 ppm, Alkalinity less than 20

ppm, Silica less than 13 ppm,

pH factor greater than 7.5,

Chlorine less than 30 ppm.

NOTES:

Cleveland Range reserves right of design improvement or modification, as warranted.

Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes.

Cleveland Range equipment is built to comply with applicable standards for manufacturers. Included among those approval agencies are UL, ULC and UL/NSF#4.

CLEARANCE

Right - 3”, Left - 3”, Rear - 3”

(12” on control side if

adjoining wall or

equipment is over 30”

high for service access)

Contact factory for

variances to clearances.

Este manual sirve para los siguientes modelos

Otros manuales de Vaporera eléctrica de Cleveland

Cleveland

Cleveland ConvectionPro XVI 36-CEM-16-48 Manual de usuario

Cleveland

Cleveland PGM-200-2 Manual de usuario

Cleveland

Cleveland SteamCraft 21-CGA-5 Guía de referencia rápida

Cleveland

Cleveland 24-CGM-200 Manual

Cleveland

Cleveland SteamChef 3 Manual de usuario

Cleveland

Cleveland 24/36CGM Manual de usuario

Cleveland

Cleveland 22CET3A Manual de usuario

Cleveland

Cleveland KE50151-E Manual de usuario

Cleveland

Cleveland 24CSM Series Manual de usuario

Cleveland

Cleveland SteamCraft V Manual de usuario

Cleveland

Cleveland SteamCraft 21-CGA-5 Manual de usuario

Cleveland

Cleveland SteamChef 22CGT3 Manual de usuario

Cleveland

Cleveland ConvectionPro XVI 36-CGM-16-300 Manual de usuario

Cleveland

Cleveland PDM-2 Manual de usuario

Cleveland

Cleveland SteamChef 22CGT6 Manual de usuario

Cleveland

Cleveland Convotherm OGB-12.20 Manual de usuario

Cleveland

Cleveland PSM-2 Manual de usuario

Cleveland

Cleveland Convotherm OEB-20.20 Manual de usuario

Cleveland

Cleveland SteamPro Manual de usuario

Cleveland

Cleveland 24-CGA-10.2 Manual de usuario

Cleveland

Cleveland OGS-20.10 Manual de usuario

Cleveland

Cleveland 22CET3A Manual de usuario

Cleveland

Cleveland SteamCraft 10 Manual de usuario

Cleveland

Cleveland 24CGA6.2S Manual de usuario

Manuales populares de Vaporera eléctrica de otras marcas

Eloma

Eloma Joker B Manual de instrucciones

Clatronic

Clatronic DG 3547 Manual de usuario

Heaven Fresh

Heaven Fresh NaturoPure HF 8333 Manual de usuario

Memco

Memco 6625B Manual

Braun

Braun 3216 Manual de usuario

Kooper

Kooper 2165306 Manual de usuario

Morphy Richards

Morphy Richards FS48751MEE Manual de usuario

Cuisinart

Cuisinart STM1000AR Manual de usuario

Hastings

Hastings DIRECT GAS FIRED ELECTRIC STEAM Guía rápida

Galantine

Galantine SILVER Style SC-5003B Manual de usuario

Oster

Oster 5711 Manual de usuario

Back to Basics

Back to Basics NUTRI STEAMER L5725A 01/09 Manual de usuario

Gallet

Gallet CUV 968 Colmar Manual de usuario

Rasonic

Rasonic RSB-B1CR Manual de usuario

Basilico

Basilico K047 Manual de usuario

Cuisinart

Cuisinart Cook & Steam Manual de usuario

Cookworks

Cookworks SM013M Manual de usuario

Cuisinart

Cuisinart Cook & Steam Manual de usuario