Char-Griller DC50 Manual de usuario
OWNER’S MANUAL
LP
Gas & Charcoal Grill
Gas Grill Features
:
•
40,800 BTU
•
Stainless Steel Tube Burners
•
12,000 BTU Side Burner
•
Cast Brass Side Burner
•
Electronic Igniters
WARNING:
Improper installation, adjustment, alteration,
service or maintenance could cause injury
or property damage Read the installation,
operation and maintenance instructions
thoroughly before assembling or servicing
this equipment.
Failure to follow these instructions could
result in fire or explosion that could cause
property damage, personal injury or death.
DANGER:
DO NOT use gas grill for indoor cooking or
heating. TOXIC fumes can accumulate and
cause asphyxiation. Do not use in or on
boats or recreational vehicles.
PROP 65 WARNING
:
Chemicals known to the state of California
to cause cancer, birth defects or other
reproductive harm are created by the
combustion of propane.
SAVE THESE INSTRUCTIONS FOR FUTURE
REFERENCE. IF YOU ARE ASSEMBLING
THIS UNIT FOR SOMEONE ELSE, GIVE THIS
MANUAL TO HIM OR HER TO SAVE FOR
FUTURE REFERENCE.
A propane gas cylinder is required for
operation. This gas grill is not intended
for commercial use.
MODEL#DC50
Charcoal Grill Features
:
•
Start charcoal with gas burner
•
Adjustable Height Charcoal
Grate
•
Side Fire Box Optional for Texas
Style Smoking
Features
:
•
Porcelain Coated Cast Iron
•
Stainless Steel Thermometers
•
Chrome Plated Warming Racks
!
LOW
DANGER
If you smell gas:
Shut off gas to the appliance.
Extinguish any open flame.
Open Lid.
If odor continues, keep away from the appliance
and immediately call your gas supplier or your fire
department.
WARNING
•
Do not store or use gasoline or other flammable
liquids or vapors in the vicinity of this or any
other appliance.
•
An LP cylinder not connected for use shall not
be stored in the vicinity of this or any other
appliance.
page 2
!
!
Table of Contents
Important Safety Information.………………………..page 4 - 5
Illustrated Parts List……………………………..…..page 6 – 8
Tools Required, Assembly Tips and Hardware List..…..page 9
Assembly Instructions……………………………....page 10 – 18
Operating Grill
Connecting Gas Cylinder……………………….page 19
Checking for Leaks……………………………...page 19
Lighting Grill…...…………………………………page 20
Cleaning and Care………………………………page 21
Gas Grill Troubleshooting……………………………page 22 - 23
Grill Preparation………………………………………page 24
Recipes……………………………………………..….page 25 - 27
Accessories…………………………………………….page 28 - 29
page 3
page 4
Ｍodel # ＤＣ５０Owner’s Manual
WARNING
FOR YOUR SAFETY
•
DO NOT store or use gasoline or any other flammable vapors and liquids within 25 feet
(8m) of this or any other appliance.
•
When cooking with oil/grease, do not allow the oil/grease to exceed 350
°
F (177
°
C). Do not
store of use extra cooking oil in the vicinity of this or any other appliance.
•
An LP Cylinder not connected for use should be stored a minimum of 10 feet (3m) away
from this or any other appliance. Never fill the cylinder beyond 80 percent full. If the above
information not followed exactly, a fire causing death or serious injury may occur.
•
If you smell gas:
- Shut Off gas to the grill. -
Extinguish any open flame.
- Open Lid. - If odor continues, immediately call your gas
supplier or fire department.
For Your Safety
Stop! Call us first! Do Not return product to store. This grill has been made to high quality
standards. If you have any questions not addressed in this manual or if you need parts
please call our customer service department at 0031 (0) 114 671493 or mail to
NOTE: The use and installation of this product must conform to local codes. In absence of local
codes, use the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane
Installation Code CSA B149.1, or Propane Storage and Handling Code, B149.2, or the
Standard for Recreational Vehicles, ANSI A119.2/NFPA 1192, and CSA Z240 RV Series,
Recreational Vehicle Code, as applicable.
Minimum distance from sides and back of unit to walls or railings is 36 inches (914mm).
Do not use under overhead construction. This appliance not intended for commercial us
e.
Do not locate this outdoor cooking appliance under overhead unprotected combustible
surface.
For Outdoor Use Only, If Store Indoors, Detach and Leave Cylinder Outdoors.
IMPORTANT NOTICE: read all instructions prior to assembly and use.
Read and understand all warnings and precautions prior to operating your grill.
CAUTION
•
This grill is for use with propane gas only (propane gas cylinder not included).
•
Never attempt to attach this grill to the self-contained propane system of a camper trailer,
motor home or house.
•
Never use charcoal or lighter fluid with the gas grill.
•
Do not use gasoline, kerosene or alcohol for lighting. The LP-gas supply cylinder must be
constructed and marked in accordance with the specifications for propane gas cylinders of
the U.S. Department of Transportation (DOT) CFR 49 or the National Standard of Canada,
CAN/CSA B339, Cylinders, Spheres and Tubes for Transportation of Dangerous Goods; and
Commission, as applicable. This grill is not intended to be used in or installed on recreation
vehicles and/or boats..
•
Do not attempt to move the grill while it is lit.
•
Do not use the grill unless it is completely assembled and all parts are securely fastened and
tightened.
page 5
7. Do not use in an explosive atmosphere. Keep grill area clear and free from combustible
materials, gasoline and other flammable vapors and liquids.
8. Do not touch metal parts of grill until it has completely cooled (about 45 minutes) to avoid burns,
unless you are wearing protective gear (BBQ mittens, pot holders, etc.)
9. Do not alter this grill in any manner.
10. Clean and inspect the hose before each use. If there is evidence of abrasion, wear, cuts, or
leaks, the hose must be replaced prior to operating the appliance. The replacement hose
assembly will be that which is specified by the manufacturer.
•
Move gas hoses as far away as possible from hot surfaces and dripping hot grease.
•
Never keep a filled container in a hot car or car trunk. Heat will cause the gas pressure to
increase, which may open the relief valve and allow gas to escape.
•
Keep the grill’s valve compartment, burners and circulating air passages clean. Inspect the
grill before each use.
WARNING
•
This grill is for outside use only, and should not be used in a building, garage or any other
enclosed area.
•
The use of alcohol, prescription or non-prescription drugs may impair the operator’s ability to
properly assemble or safely operate the grill.
•
Always open grill lid slowly and carefully as heat and steam trapped within the grill can burn
you severely.
•
Always place your grill on a hard, level surface far away from combustibles. An asphalt or
blacktop surface may not be acceptable for this purpose.
•
Do not leave a lit grill unattended. Keep children and pets away from the grill at all times.
•
Do not place this grill on any type of tabletop surface.
•
Do not use the grill in high winds.
DANGER
Liquid propane (LP) gas is flammable and hazardous if handled improperly. Know its characteristics
before using any propane product.
•
Propane Characteristics: Flammable, explosive under pressure, heavier than air and settles in
pools and low areas.
•
In its natural state, propane has no odor. For your safety, an odorant has been added.
•
Contact with propane can cause freeze burns to skin.
•
This grill is shipped from the factory for propane gas use only.
•
Never use a propane cylinder with a damaged body, valve, collar or footing.
•
Dented or rusted propane cylinders may be hazardous and should be checked by your
propane gas supplier.
12.CHARCOAL CHIMNEY...1PC
11. CHARCOAL BODY….1PC
10. CHARCOAL HOOD…1PC
9. FLAME SHIELD…..3PCS8. BURNER
(with longer wire)…
1PC
7. BURNER
(with shorter wire)..
2PCS
6.WARMING.RACK…..2PCS5. HOOD HANDLE……..2 SETS
4. THERMOMETER……2 PCS
3. GAS CHIMNEY……..2PCS
2. GAS GRILL BODY……...1PC
1. GAS GRILL HOOD…....1PC
ILLUSTRATED PARTS LIST:
page 6
page 7
24. LEFT LEG..…….…..2PCS23. LEG CROSS BAR….2PCS22. CATCH PAN……..…..1PC
21. GREASE TRAY……2PCS20. ‘S’ HOOK……..…….3PCS19. SIDE BURNER / CONTROL
PANEL / HOSE & VALVE….1SET
18. POT STAND.…………1PC17.CONDIMENT BASKET….1PC16.SIDE HANDLE………...1PC
15. SIDE DAMPER…....1PC14. FIRE GRATE/ASH PAN.....1PC
13.FIRE GRATE HANGER..2PCS
page 8
33. GRATE HOOK….....1PC32. COOKING GRATE...6PCS31. AXEL CAP………....2PCS
Go to next page for
the Hardware List
and Assembly
Tips.
30. AXEL………………….1PC
29. WHEEL……………..2PCS
28. BASE…………………1PC
27. BOTTOM SHELF……1PC26. LEG BRACE….…….2PCS
25. RIGHT LEG……..…2PCS
page 9
HAIR COTTER PIN….3 PCS
CENTER HINGE PIN…1 PC
¼” LOCK WASHER…35 PCS
HINGE PINS………..2 PCS
¼-20 HEX NUT……..19 PCS
¼” FLAT WASHER…10 PCS
SCREW……………….3 PCS
¼-20x1/2” BOLT….... 43 PCS
¼-20x 1 ½” BOLT……8 PCS
Assembly: Requires 2 people. Get another person to help.
Tools Needed: Pliers, Phillips Head Screwdriver and a 7/16” Nut Driver.
NOTE: Do Not tighten any bolts unless instructed to do so. Tightening too soon may prohibit
parts from fitting together. All Hex Nuts should be on the inside of the grill unless stated
otherwise. Unpack all contents in a well cleared and padded area.
Estimated Assembly Time: 45 minutes
STOP! Do Not Return to Store. If you are missing parts or need assistance please email us at
info@patioworld.nl or call 0031 (0)114 671493. Do not attempt assembly if you are missing
parts.
HARDWARE:
page 10
Step 1
Attach the LEFT LEGS & RIGHT LEGS to the BASE using four (4) ½” BOLTS and four (4) ¼”
LOCK WASHERS as shown. When you install the LEFT LEG & RIGHT LEG, please make sure
that the holes at the top of the LEGS are facing out.
Assembly Instructions
Step 2
Attach the LEG CROSSBAR to the frame as shown making sure that the holes on the
CROSSBAR are facing inward. See below.
Step 3
Attach BOTTOM SHELF to the LEGS (as shown below).
Lock
Washer
x
covers
decorative
part of
AXLE
Tabla de contenidos
Otros manuales de Parrilla de Char-Griller
Char-Griller
Char-Griller Deluxe 2929 Manual de usuario
Char-Griller
Char-Griller Patio Pro 1515 Manual de usuario
Char-Griller
Char-Griller Outlaw #2137 Manual de usuario
Char-Griller
Char-Griller Smokin Pro 1244 Manual de usuario
Char-Griller
Char-Griller Super Pro #2121 Manual de usuario
Char-Griller
Char-Griller Akorn JR. Kamado 06614 Manual de usuario
Char-Griller
Char-Griller Grand Champ 8100 Manual de usuario
Char-Griller
Char-Griller 2123 Manual de usuario
Char-Griller
Char-Griller Flavor Pro 7400 Manual de usuario
Char-Griller
Char-Griller SMOKIN' CHAMP 1733 Manual de usuario
Char-Griller
Char-Griller 3001 Manual de instrucciones
Char-Griller
Char-Griller King-Griller Smokin' Ace 3018 Manual de usuario
Char-Griller
Char-Griller Side Fire Box #2424 Manual de usuario
Char-Griller
Char-Griller AKORN AUTO-KAMADO E6480 Manual de usuario
Char-Griller
Char-Griller 789792021218 Manual de usuario
Char-Griller
Char-Griller Pro Deluxe Manual de usuario
Char-Griller
Char-Griller 72424 Manual de usuario
Char-Griller
Char-Griller 5650 Manual de usuario
Char-Griller
Char-Griller AKORN 6520 Manual de usuario
Char-Griller
Char-Griller 2123 Manual de usuario
