Cedar Summit F24720 Manual de usuario
INSTALLATION AND OPERATING INSTRUCTIONS
GRANDVIEW LODGE PLAY SYSTEM – F24720
10-14 Hrs
To reduce the risk of serious injury or death, you must read and
follow these instructions. Keep and refer to these instructions often
and give them to any future owner of this play system. Manufacturer contact information provided below.
OBSTACLE FREE SAFETY ZONE - 26’ x 31’6” area requires Protective Surfacing. See page 3.
MAXIMUM VERTICAL FALL HEIGHT - 6’5”
CAPACITY - 9 Users Maximum, Ages 3 to 10; Weight Limit 110 lbs. (49.9 kg) per child.
RESIDENTIAL HOME USE ONLY. Not intended for public areas such as schools, churches, nurseries, day cares or parks.
Two person
assembly
WARNING
7'-4"
19'6"
31'-6"
26'
3404720 Rev 02/11/2013
Table of Contents
Warnings and Safe Play Instructions. . . . . . . . . . . . . . . pg. 2
Protective Surfacing Guidelines. . . . . . . . . . . . . . . . . . . pg. 3
Instructions for Proper Maintenance . . . . . . . . . . . . . . . pg. 4
About Our Wood – Limited Warranty . . . . . . . . . . . . . . pg. 5
Keys to Assembly Success . . . . . . . . . . . . . . . . . . . . . . pg. 6
Metric Conversion Sheets . . . . . . . . . . . . . . . . . . . . . pg. 7,8
Part ID .......................................pg. 9
Installation of I.D./Warning Plaque . . . . . . . . . . . .Final Step
Cedar Summit
c/o ©Solowave Design L.P
Mount Forest, ON Canada
N0G 2L0
www.cedarsummitplay.com
support@cedarsummitplay.com
Customer Service
1-877-817-5682 (toll free)
1-519-323-2258
Warnings and Safe Play Instructions
CONTINUOUS ADULT SUPERVISION REQUIRED. Most serious injuries and deaths on playground equipment have occurred
while children were unsupervised! Our products are designed to meet mandatory and voluntary safety standards. Complying
with all warnings and recommendations in these instructions will reduce the risk of serious or fatal injury to children using
this play system. Go over the warnings and safe play instructions regularly with your children and make certain that they
understand and follow them. Remember on-site adult supervision is required for children of all ages.
Observe capacity limitations of your play-set. See
front cover.
Dress children with well fitting and full foot enclosing
footwear.
Teach children to sit with their full weight in the center
of the swing seat to prevent erratic swing motion or
falling off.
Check for splintered, broken or cracked wood; missing,
loose, or sharp edged hardware. Replace, tighten and or
sand smooth as required prior to playing.
Verify that suspended climbing ropes, rope ladders, chain
or cable are secured at both ends and cannot be looped
back on itself as to create an entanglement hazard.
On sunny and or hot days, check the slide and other
plastic rides to assure that they are not very hot as to
cause burns. Cool hot slide and rides with water and wipe
dry prior to using.
Do not allow children to wear open toe or heel footwear
like sandals, flip–flops or clogs.
Do not allow children to walk, in front, between, behind
or close to moving rides.
Do not let children twist swing chains or ropes or loop
them over the top support bar. This may reduce the
strength of the chain or rope and cause premature failure.
Do not let children get off rides while they are in motion.
Do not permit climbing on equipment when it is wet.
Do not permit rough play or use of equipment in a
manner for which it was not intended. Standing on or
jumping from the roof, elevated platforms, swings,
climbers, ladders or slide can be dangerous.
Do not allow children to swing empty rides or seats.
Do not allow children to go down slide head first or
run up slide.
2
SERIOUS HEAD INJURY HAZARD
Installation over concrete, asphalt, dirt, grass, carpet
and other hard surface creates a risk of serious injury
or death from falls to the ground. Install and maintain
shock absorbing material under and around play-set as
recommended on page 3 of these instructions.
COLLISION HAZARD
Place play-set on level ground at least 6 feet from any
obstruction such as a garage or house, fences, poles,
trees, sidewalks, walls, landscape timbers, rocks,
pavement, planters, garden borders, overhanging
branches, laundry lines, and electrical wires. (See
OBSTACLE FREE SAFETY ZONE on cover)
CHOKING HAZARD/SHARP EDGES & POINTS
Adult assembly required. This product contains small
parts and parts with sharp edges and points. Keep parts
away from children until fully assembled.
WARNING LABEL
Owners shall be responsible for maintaining the legibility
of the warning labels.
STRANGULATION HAZARD
• NEVER allow children to play with ropes, clotheslines,
pet leashes, cables, chains or cord-like items when using
this play-set or to attach these items to play-set.
• NEVER allow children to wear loose tting clothing,
ponchos, hoods, scarves, capes, necklaces, items with
draw-strings, cords or ties when using this play-set.
• NEVER allow children to wear bike or sport helmets
when using this play-set.
Failure to prohibit these items, even helmets with chin
straps, increases the risk of serious injury and death to
children from entanglement and strangulation.
TIP OVER HAZARD
Choose a level location for the equipment. This can reduce
the likelihood of the play set tipping over and loose-fill
surfacing materials washing away during heavy rains.
DO NOT allow children to play on the play-set until the
assembly is complete and the unit is properly anchored.
WARNING
WARNING – Safe Play Instructions
1 inch = 25.4mm
SOLO)WAVE DESIGN HARDWARE
For example:
BOLT LENGTH 4½ (4.5) inches long
114mm long
1 inch = 25.4mm
25.4mm
4.5 inches x
DIAMETER CONVERSION
LENGTH CONVERSION
=
BOLT DIAMETER 5/16 (0.31) inches
0.31 inches x 25.4mm = 8mm
For example:
HARDWARE LENGTH CHART
inches vs millimetres
6 152
5½ 140
5 127
4½ 114
4 102
3½ 89
3 76
2½ 64
2 51
1½ 38
1¼ 32
1-1/8 29
1 25.4
7/8 22
3/4 19
1/2 12.7
1/4" (6mm) Flat Washer
1/4" (6mm)
Lock Washer
1/4"(0.25) = 6mm Hex Bolt
1/4" (6mm)
T-Nut
5/16"(.31) = 8mm Lag Screw
5/16" (8mm)
Flat Washer
1/4"(0.25) = 6mm Lag Screw
1/4" (6mm)
Flat Washer
5/16" (8mm)
Flat Washer
5/16" (8mm) Lock Washer
5/16"(.31) = 8mm Hex Bolt
5/16" (8mm)
T-Nut
3/8"(.38) = 9.5mm Lag Screw
3/8" (9.5mm)
Flat Washer
1 x 2
1 x 4
1 x 5
1 x 6
1 x 3
1/2 x 4
5/4 x 6
5 1/2"
139.7
1"
25.4
11.1
.44
82.6
3 1/4"
4 x 4
3 1/2"
88.9
3 1/2"
88.9
4 1/2"
114.3
5/8"
15.9
15.9
5/8" 1 3/8"
34.9
2 x 6
5 3/8"
136.5
1 1/2"
38.1
15.9
5/8" 3 3/8"
85.7
60.3
2 3/8"
15.9
5/8"
1505mm
SOLO)WAVE DESIGN WOOD PROFILES
LENGTH CONVERSION
For example:
1 inch = 25.4mm
BOARD LENGTH 59¼ (59.25) inches
59.25 inches x 25.4mm =
Dimensions in brackets
[mm] represent millimetres.
5/4 x 4
3 1/2"
88.9
1"
25.4
5 3/8"
136.5
5/8"
15.9
2 x 4
3 3/8"
85.7
1 3/8"
34.9
5/4 x 5
4 1/2"
114.3
1"
25.4 2 x 3
2 1/2"
63.5
1 3/8"
34.9
5/4 x 3
63.5
2 1/2"
25.4
1"
2
x 2
1 1/2"
38.1
1 1/2"
38.1
26pc. - 0517 Cedar Roofing (3/8 x 3-1/2 x 48") - Box 1 - 3630517
5pc. - 1801 Cedar Siding (3/8 x 3-1/2 x 46-5/8") - Box 2 - 3631801
18pc. - 1852 CE Siding (3/8 x 3-1/2 x 36") - Box 2 - 3631852
12pc. - 1800 CE Siding (3/8 x 3-1/2 x 25-1/2") - Box 1 - 3631800
25pc. - 1503 Wall Board (1/2 x 4 x 20") - Box 1 - 3631503
Part Identification (Reduced Part Size)
Nominal Size
1" x 2"
1" x 4"
1" x 5"
1" x 6"
Actual Size
⅝" x 1⅜"
⅝" x 3⅜"
⅝" x 4½"
⅝" x 5⅜"
Part Identification (Reduced Part Size) Part Identification (Reduced Part Size)
1pc. - 1809 Door Trim (1 x 2 x 36-1/2") - Box 2 - 3641809
2pc. - 1956 Front Wall (1 x 4 x 25") - Box 1 - 3641956
2pc. - 1957 SL Roof Side (1 x 4 x 13-3/4") - Box 1 - 3641957
1pc. - 1876 Window Cross (1 x 2-1/2 x 28") - Box 2 - 3641876
2pc. - 1964 SW Wall Trim (1 x 2-1/2 x 40-3/8") - Box 2 - 3641964
2pc. - 1971 Window Upright (1 x 2-1/2 x 46") - Box 2 - 3641971
1pc. - 1806 Door Top (1 x 4 x 21") - Box 2 - 3641806
2pc. - 1858 Short Wall Support (1 x 4 x 24-1/4") - Box 2 - 3641858
1pc. - 1808 Short Trim (1 x 2 x 19-5/8") - Box 2 - 3641808
6pc. - 0318 Ground Stake (1-1/4 x 1-1/2 x 14") - Box 1 - 3650318
1pc. - 1870 Trim Short (1 x 2-1/2 x 19-5/8") - Box 2 - 3641870
1pc. - 1969 Seat Rail (1 x 4 x 28-3/8") - Box 2 - 3641969
2pc. - 1962 Post Couple (1 x 4 x 17-1/2") - Box 1 - 3641962
1pc. - 1988 Gusset Ground Support (1 x 5 x 15-5/8") - Box 3 - 3641988
9pc. - 1851 Cedar Floor Board (1 x 5 x 38-3/4") - (8X)Box 1 & (1X)Box 2- 3631851
2pc. - 1501 Floor End (1 x 5 x 38-1/4") - Box 1 - 3641501
1pc. - 0348 SL Ground (1 x 5 x 38-1/4") - Box 1 - 3640348
2pc. - 1973 Crowsnest Floor (1 x 5 x 30") - Box 3 - 3631973
2pc. - 1970 Seat Bottom (1 x 5 x 11-1/2") - Box 2 - 3641970
1pc. - 1865 Sw Roof Side (1 x 4 x 59-1/2") - Box 1 - 3641865
Nominal Size
1" x 6"
1½" x 1½"
1⅜" x 2½"
Part Identification (Reduced Part Size)
2" x 3"
2" x 2"
5/4" x 4"
Part Identification (Reduced Part Size)
Actual Size
⅝" x 5⅜"
1" x 3¼"
Part Identification (Reduced Part Size)
2pc. - 0357 Tarp Front Back (1 x 4 x 47-3/4") - Box 1 - 3640357
1pc. - 0358 Top Front Back (1 x 4 x 46-1/2") - Box 1 - 3640358
4pc. - 1814 Wall Support (1 x 4 x 45-1/2") - Box 2 - 3641814
1pc. - 0839 CE Gap Board (1 x 4 x 38-3/4") - Box 1 - 3630839
1pc. - 1502 Wall Support (1 x 4 x 38-1/4") - Box 1 - 3641502
1pc. - 1955 Divider (1 x 4 x 35-3/16") - Box 1 - 3641955
1pc. - 1958 Back Divider (1 x 4 x 31-3/4") - Box 1 - 3641958
4pc. - 1975 Cedar Wall (1 x 4 x 29") - Box 3 - 3631975
Tabla de contenidos
Otros manuales de Accesorios para bebés de Cedar Summit
