Carrier Harmony 53VMC18A-H Guía de instalación y uso

03502566

SERVICE & MAINTENANCE MANUAL

Revision : (0) - 2009

Specifications are subject to change without notice according to Carrier Policy of continuous development.

TABLE OF CONTENTS

PAGE NO.

1. Precautions for Service & Maintenance 1

2. Split System Description 2

3. Unit Model Designation 3

4. Unit Models & Part Numbers 3

5. Options 4

6. System Operating Limits 5

7. System Safety Protections 5

8. Wiring Diagrams 6

9. Field Electrical Connections Matching 7

10. Refrigeration Cycle – 53QG Series 8

11. Replacing Batteries of Remote Control 10

12. Emergency Operation of Air-Conditioner 11

13. Standard and Optional Air Filters 12

14. Air Filter Cleaning 13

15. Indoor Unit Cleaning 14

16. Considerations After Operational Season and Before Long

Shutdown Period Of Air Conditioner 14

17. Periodical Checks 15

18. Self Diagnostic Function For Malfunction Detection 16

19. Trouble Shooting 17

1. PRECAUTIONS FOR SERVICE AND MAINTENANCE

SAFETY CONSIDERATIONS

• Installation of air conditioning equipment can be hazardous due to system pressures and

electrical components.

• The installation of the air conditioner must be done by Carrier or one of Carrier authorized

dealers.

WARNING

• This installation manual describes the installation procedures of Carrier split room air

conditioner consisting of an outdoor unit and an indoor unit manufactured by Carrier.

What is not covered in Carrier warranty?

1- Failure due to wrong electrical connections between the electrical power supply and

circuit breaker of air conditioner leading to fire due to short-circuiting. As these electrical

connections are owner’s responsibility.

2- Failure due to Misuse, Abusing, overloading, negligence of air filters cleaning and

negligence of instructions included in the owner’s manual.

3- Failure due to Accident / Weather Natural catastrophe, accident due to bad weather

(Hail Storm, Sand Storm, lightning, Flooding, Acid Rain and Air Borne fallout, etc).

4- Failure due to damages during transport done through the owner.

5- Failure due to any modifications in the product done through the owner and not done by

Carrier or one of Carrier authorized dealers.

6- Failure due to Installation done through the owner and not done by Carrier or one of

Carrier authorized dealers.

7- Failure due to Service and Maintenance done through the owner and not done by Carrier

or one of Carrier authorized dealers.

8- Failure due to repair by using non-genuine Carrier Parts, or substituting other than

Carrier parts done through the owner and not done by Carrier or one of Carrier

authorized dealers.

9- Product normal sound ( refrigerant – moving parts )

10- Inconvenience or commercial loss is not covered.

The decision of Carrier in ascertaining the same will be final. Any such repairs will be carried -

out at the expense of the owner ( purchaser ).

Outdoor Unit

2. SPLIT SYSTEM DESCRIPTION

1: Remote control signal receiver.

2: Operating status leds. 6: Supply air outlet.

3: Supply air flap. 7: Characteristics nameplate.

4: Air return grille. 8: Inter connecting tubing.

5: Air filter ( behind return grille ). 9: Condensate drain line.

Floor/Wall/Ceiling Split System

53VMC14-18-24

Indoor Unit

3. UNIT MODEL DESIGNATION

4. UNIT MODELS & PART NUMBERS

SPLIT SYSTEMS FOR LOCAL MARKET

System Indoor Unit Outdoor Unit

Compressor

Model P/N Model P/N Model P/N Type Supplier

53VMC14-H

46303279 42VMC14-H

46303290 38VMC14-H

46303278 Rotary LG

53VMC18A-H

46303118 42VMC18A-H

46303276 38VMC18A-H

46303117 Rotary Hitachi

HEAT

PUMP

53VMC24-H

46303359 42VMC24-H

46303292 38QG24-H

46302128 Rotary LG

SPLIT SYSTEMS FOR MILD AMBIENT EXPORT MARKETS

Indoor Unit Outdoor Unit

Compressor

Model P/N Model P/N Type Supplier

42VMC14-H

46303221 38QG15-H

46303300 Rotary Mitsushita

42VMC18A-H

46303533 38VMC18A-H

46303534 Rotary Hitachi

HEAT

PUMP

42VMC24-H

46303233 38QG24-H

46303644 Rotary LG

Indoor Unit Outdoor Unit

Compressor

Model P/N Model P/N Type Supplier

42VMC14-C

46303293 38QG15-C

46302110 Rotary Mitsushita

42VMC18-C

46303294 38QG18-C

46303517 Rotary Mitsushita

COOL

ONLY

42VMC24-C

46303295 38QG24-C

46303365 Rotary Mitsushita

SPLIT SYSTEM FOR HIGH AMBIENT EXPORT MARKETS

Indoor Unit Outdoor Unit

Compressor

Model P/N Model P/N Type Supplier

42VMC18-H

46303219 38QG18-H

46303516 Rotary Mitsushita

HEAT

PUMP

42VMC24-H

46303220 38QG24-H

46303363 Rotary Mitsushita

Indoor Unit Outdoor Unit

Compressor

Model P/N Model P/N Type Supplier

42VMC18-C

46303294 38QG18-C

46303517 Rotary Mitsushita

COOL

ONLY

42VMC24-C

46303295 38QG24-C

46303365 Rotary Mitsushita

VMC

42 = Indoor Unit

38 =Outdoor Unit

System

Cooling Capacity

At ISO Conditions

14 = 14,000 Btu/hr

18 = 18,000 Btu/hr

24 = 24,000 Btu/hr

Unit Family

Unit Type

H = Heat Pump

C = Cool Only

5. OPTIONS

DESCREPTION CONFIGURATION QTY USAGE

Electrical Cables Set

for Heat Pump System

Main Power cable

Outdoor Unit–Circuit Breaker

Power cable

Outdoor Unit – Indoor Unit

Control & Defrost cable

Outdoor Unit–Circuit Breaker P/N : 02500894

Set of 3

To electrically connect between

circuit breaker, outdoor and

indoor units

Electrical Cables Set

for Cool Only System

Main Power cable

Outdoor Unit – Indoor Unit

Power & Control cable

Outdoor Unit – Indoor Unit P/N : 02500893

Set of 2

To electrically connect between

circuit breaker, outdoor and

indoor units

Optional set of air filters

(Carbon air filter + Photo-

catalytic air filter) P/N : 02802563

( for 42VMC14-18-24 )

Set of 2

To eliminate odor and cigarette

smoke in the room air

respectively.

PTC starting device for

38QG15-18-24

P/N : 02501579

To start the compressor in

outdoor unit at low voltage down

187V

Floor support for indoor units

42VMC14-18-24

P/N : 46300822

To mount the indoor unit on the

floor in case of impossibility of

mounting the unit on the wall

6. SYSTEM OPERATING LIMITS *

COOLING HEATING

Difference Dry Bulb

Temp. C°

Wet Bulb

Temp. C° Difference Dry Bulb

Temp. C°

Wet Bulb

Temp. C°

Indoor temperature

Maximum

Minimum

Indoor temperature

Maximum

Outdoor temperature

Maximum

Minimum

Outdoor temperature

Maximum

MAIN POWER SUPPLY

Difference Nominal

200-240V/1PH/50HZ

Min. Voltage 187

Max. Voltage 264

NOTES:

* When the unit is operated above or below these limits for a long time, system diagnostics may detect

a malfunction and the unit will not operate properly.

** During heat pump operation the system will undergo several defrost cycles to remove ice that might

collect on the outdoor unit in very low ambient temperature.

After completion of defrosts cycle, the system will normally operate.

7. SYSTEM SAFETY PROTECTION

7-1 FOR HEAT PUMP SYSTEM

PROTECTION TYPE PROTECTION EFFECT OPERATION MODE WHEN ON

Cold draft prevention Indoor fan off Heating mode During unit operation

Defrost cycle Indoor fan off Heating mode During unit operation

Indoor coil

Freeze protection Compressor off Cooling mode During unit operation

Against frequent

Compressor cycling

Compressor

Time delay

Cooling or heating

modes

At unit start-up or change

of operating mode

7-2 FOR COOL ONLY SYSTEM

PROTECTION TYPE PROTECTION EFFECT OPERATION MODE WHEN ON

Indoor coil

Freeze protection Compressor off Cooling mode During unit operation

Against frequent

Compressor cycling

Compressor

Time delay Cooling mode At unit start-up or change

of operating mode

8. WIRING DIAGRAMS

WIRING DIAGRAMS (Cont.)

LEGEND

Earth

LLive power supply.

NNeutral power supply.

RLive connection indoor/outdoor unit.

CNeutral connection indoor/outdoor unit.

YCompressor control.

OReversing valve control.

W2 Outdoor fan motor control.

S Outdoor coil sensor.

LEGEND

Earth

LLive power supply.

NNeutral power supply.

RLive connection indoor/outdoor unit.

CNeutral connection indoor/outdoor unit.

Com

ressor control.

9. FIELD ELECTRICAL CONNECTIONS MATCHING

- Connect the power supply to the outdoor unit and then get the power required for the indoor unit from the outdoor unit.

- Refer to wiring diagrams and stickers-caution sticked inside the outdoor & indoor units.

9-1 CONNECTING ELECTRICAL WIRING FOR HEAT PUMP SYSTEM

Sizes of electrical wires connecting outdoor and indoor units

R C Y O W2 S

1 mm2 1 mm21 mm21 mm21 mm21 mm2

9-2 CONNECTING ELECTRICAL WIRING FOR COOL ONLY SYSTEM

Sizes of electrical wires connecting

outdoor and indoor units

R C Y

1 mm2 1 mm21 mm2

200 - 240V ~ 50Hz

Circuit

Breake

Main

Switch

200 - 240V ~ 50Hz

Circuit

Breake

Main

Switch

Indoor Unit

Outdoor

Unit

Outdoor

Unit

Indoor Unit

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Acondicionador de aire de Carrier

Carrier

Carrier CU-O Series Guía del usuario

Carrier

Carrier WeatherExpert 48N2 Manual de usuario

Carrier

Carrier MINIMUM LOAD CONTROL ACCESSORY 30RB060-390 Manual de usuario

Carrier

Carrier 42QSS009DS series Manual de usuario

Carrier

Carrier 51HK Manual de usuario

Carrier

Carrier 50SD Instrucciones de funcionamiento

Carrier

Carrier 38GJ Series Instrucciones originales

Carrier

Carrier bryant Preferred 577E Manual de instrucciones

Carrier

Carrier 38MVC Manual de usuario

Carrier

Carrier 38HD018 Dimensiones y guía de instalación

Carrier

Carrier 50VL-D Manual de usuario

Carrier

Carrier 38EN Dimensiones y guía de instalación

Carrier

Carrier 50VL-C Manual de usuario

Carrier

Carrier 42TSR018~025 Series Manual de usuario

Carrier

Carrier 42QZA009DS series Manual de usuario

Carrier

Carrier 42GW Manual de usuario

Carrier

Carrier 40MBFQ243 Manual de usuario

Carrier

Carrier 38HVM109303 Manual de usuario

Carrier

Carrier 42QZL018R8S Series Manual de usuario

Carrier

Carrier 40MAHB Series Manual de usuario

Carrier

Carrier 50A020 Manual de usuario

Carrier

Carrier 438MG series Manual de usuario

Carrier

Carrier 40MHH Manual de usuario

Carrier

Carrier 42TVGS018-703 Manual de usuario

Manuales populares de Acondicionador de aire de otras marcas

Spheros

Spheros CC 355 Manual de usuario

Bosch

Bosch Climate 5000 SCI 24 CAS/ OU- OUE Manual de usuario

Panasonic

Panasonic CS-E12HKEW Manual de usuario

nedis

nedis ACMB1WT7 Manual de usuario

Samsung

Samsung AR KV Series Guía

Daikin

Daikin FCFV50A Manual de usuario

Fujitsu

Fujitsu Inverter ASBA30JFC Manual de usuario

Toshiba

Toshiba RAS-M10SMUV-E Manual de usuario

Daikin

Daikin FXLQ20MAVE Manual de usuario

Hitachi

Hitachi RAS-E24CAK Manual de usuario

CIAT

CIAT Magister 2 Series Guía

Bestron

Bestron AAC6000 Manual de usuario

Hisense

Hisense 7K Manual técnico

Frigidaire

Frigidaire FFRE0533S1E0 Manual de usuario

Samsung

Samsung AS09HM3N Manual de usuario

Frigidaire

Frigidaire CRA073PU11 Manual del propietario

Soleus Air

Soleus Air GB-PAC-08E4 Manual de usuario

McQuay

McQuay MCK020A Manual de usuario