Camplux GG201S Manual de usuario
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
Model: GG201S
TABLE TOP GAS GRILL GRIDDLE
Instruction For Installation And Use
If you smell gas:
● Turn off gas to the appliance.
● Put out any open fire.
● If smell continues, walk away from the appliance
and call your gas dealer or firemen at once.
● Do not leave this appliance unattended.
● Don’t use this appliance within 25 ft to any
flammable liquid.
● In the event of a fire, walk away from the
appliance and call your firemen at once. Do not try
to put out any oil or a grease fire with water.
Not following these instructions may cause fire or
explosion which may cause property damaged,
personal injury, or death.
DANGER
CALIFORNIA PROPOSITION 65 WARNING:
The State of California is aware of this product can cause cancer and birth defects or other reproductive hard.
(California law requires this warning be given to customers in the State of California.)
WARNING
Please read all necessary information for the
proper assembly and safe use of the appliance
before installing this equipment. If you have any
problems, call your service team or supplier. Do not
try to fix the problems yourself, or it will cause injury
or property damage.
Installing this appliance must conform with state or
other codes, or, in the absence of such codes, with
either the National Fuel Gas Code, ANSI Z223.1 /
NFPA 54, or the Standard for Recreational Vehicles,
ANSI A/NFPA 1192, and CSA Z240 RV Series,
Recreational Vehicle Code, as applicable.
WARNING
Consumers must take responsibility to make sure the griddle is properly assembled, installed and maintained.
Not following the instructions could result in life injury and/or property damage.
WARNING
FOR YOUR SAFETY
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
1
www.camplux.com
Precautions
1. Don’t use the appliance indoors. It is only to be used outdoors.
2. During any pressure test, the griddle must be disconnected from the gas supply piping system at test pressures
in excess of 1/2 PSI (3.5 kPa).
3. The appliance must be separated from the gas supply piping system during any pressure testing of the gas
supply piping system at test pressures equal to or less than 1/2 PSI (3.5 kPa).
4. Before using this appliance, visually inspect the gas hose from the tank connection to the orifice in case there is
any wear, breaks, leaks, cracks, cuts or intrusions. If any of these discovered, replace hose prior to operation.
5. Under the condition of rain, snow, hail, sleet, or other forms of precipitation while cooking with oil or grease, it is
necessary that you must cover the cooking vessel immediately and turn off the appliance burners and gas
supply. Don’t try to move the appliance or cooking vessel.
6. Make sure the appliance must be on level, stable noncombustible surface in an area clear of combustible
material during cooking. An asphalt surface (blacktop) can not be accepted for this purpose.
WARNING
● This device is to be used outdoors only, and can not be used in a building, garage, or any other enclosed area.
● It is not acceptable to be used on or under any flats or condominium balcony or deck.
● Using alcohol, prescription or non-prescription drugs may damage the consumers’ ability to properly assemble or
safely operate the griddle.
● Type BC or ABC fire extinguisher is necessary to be ready during cooking.
● When an oil or grease fire arise, don’t attempt to extinguish with water. Must call the fire Department or use A
Type BC or ABC fire extinguisher.
● The appliance operation must be watched. Don’t let children and pets near the appliance at all times.
● This appliance is not designed and used as a heater and not suitable for frying turkeys.
● During and after use of the appliance, use insulated oven mitts or gloves for protection from hot surfaces or
splatter from cooking liquids.
● Never put empty cooking vessel on the appliance while in operation. Be cautious when placing anything in
cooking vessel while in operation.
Never move the appliance during the use. Must make sure the cooking vessel cool to 115°F before moving or
storing.
● Commercial purpose is not allowed to act on this griddle.
Installation Safety Precautions
● The installation of this appliance must conform with local codes, or in the absence of local codes, with either the
National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1 or
Propane Storage and Handling Code, B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA
1192, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable.
● It is not accepted to operate inside RV's or on boats.
● It is safely certified to be used in the countries of United States and Canada.
Never modify and use in any other countries. Modification will cause a safety hazard or damage.
● Replacing pressure regulators need to be those who are specified by the appliance manufacturer.
After you have read and understand all safety information, warnings and precautions, you can proceed to the
next page for assembly & installation instructions regarding your particular model.
2
www.camplux.com
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
What's In the Box
Key
1
2
3
4
5
6
7
8
9
Description
Griddle Plate
Cooking Grid
Flame Tamer
Grease Cup
Unit Body
Grease Tray
Rubber Foot
Pressure Reducing Valve
5/8"-18UNF Quick Connector
Qty
1
1
1
1
1
1
4
1
1
WARNING
Never use this appliance under extended awnings as it may cause a fire or personal injury. Install it on the opposite
side from the fuel distribution/dispensing system of the recreational vehicle.
Never let it be located or used under overhead unprotected combustible buildings or roof.
If not in operation or when in travelling, make sure all low pressure propane gas system precautions are in place
and all propane gas shut off valves are shut off.
1
2
3
4
5
6
7
8
9
3
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
www.camplux.com
Connecting the Gas Supply
CAUTION
Connect to the vehicle's propane system with a flexible hose connector which must comply with the high pressure
requirements of the Standard for Pigtails and Flexible Hose Connectors for LP Gas, ANSI/UL 569, and a length no
longer than that required to allow the griddle to be mounted when “in use” position of mounting. The hose that is
mounted can not be allowed to touch with the hot surface of the griddle while in operation or in the storage/travel
mode.
CAUTION
BEFORE STARTING THE INSTALLATION
MUST fit the recommended minimum clearances to combustible constructions:
6″ from sides
8″ from back
8″ from vertical
Installation
1. When you do not use this appliance or want to store this appliance, it is strongly recommended to place it in a
place with a size of 19.0" x 9.0" to ensure that the bakeware is completely placed in the storage location (keep it
cool during storage).
8''
6''
Don’t check leaks with an open fire. When not
using, it is a correct way by opening the gas
and apply soapy water to all joints to see if
bubbles are formed.
WARNING
17.95''
5.75''
1.3''
4
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
www.camplux.com
Installation Guide for Griddle
2. Put the griddle upside down on a soft surface. Put the four rubber feet to the bottom of the griddle as shown
below.
1. Remove the griddle plate from the griddle body.
4. Push the oil pan along the track.
3. Installing the oil cartridge.
1
6
7
4
5
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
www.camplux.com
5. Put the griddle upside down on a soft surface. Put the four rubber feet to the bottom of the griddle as shown
below.
1
WARNING
Never check leaks with an open flame. Turn on the gas and apply soapy water to all joints to see if bubbles are
formed.
Connection
Installation type 1: With this 5/8"-18UNF quick connector, you can easily and quickly connect with gas grill griddle
and enjoy food.
Installation type 2: With this 5/8”-18UNF gas regulator, you can easily connect with gas grill griddle and 20LB
propane cylinder, and you can enjoy life in camping, park or backyard.
5/8"-18UNF Male Connector
Installation Type 2:
5/8"-18UNF Femal to 5/8"-18UNF Quick Connector
Installation Type 1:
5/8"-18UNF Gas Regulator-5ft
6
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
www.camplux.com
7
1. Remove the griddle plate. 2. Reverse the oven body by 90 degrees and lock the 4
foot pads in turn.
3. Installing the oil cartridge. 4. Push the oil pan along the track.
5. Insert the grease tray. 6. Put on the cooking grill.
Installation Guide for Barbecue
1
46
3
2
7
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
www.camplux.com
Instruction of Operation
To light griddle
Must read all steps carefully
1. Push the control knob in and turn counter-clockwise to the “Light” position.
2. If fire does not appear in 5 seconds, shut the burner control off, wait for 5 minutes, and repeat the lighting
procedure.
Use match for lighting
1. Don’t lean over the griddle while lighting. Ensure no gas leaks occur.
2. Control knob must be in the “OFF” position. Get the griddle top off.
3. Light a long match, then put the match on the right or left side of the burner.
4. Press the control knob in and turn counterclockwise to the “HIGH” position.
Be sure the burner lights and keep it lit.
Check burner fire
Remove the griddle plate or the grease cup before lighting as to visually check the fire. Light burner and turn knob
from high to low you will see a smaller fire in the low position and bigger in the high position.
Check the fire before each use. If you only see low flame, refer to Burner has low flame regardless of knob position
in the TROUBLESHOOTING GUIDE. Change the griddle plate or grease drawer before cooking.
Grease Cup Low Flame
To turn off griddle
Turn the control knob to the “OFF” position.
Seasoning
Seasoning is baking oil into metal to make a sticky resistant surface and protect against oxidation.
There is a layer of soy oil on the appliance to protect against rust during transporting. It can be cleaned off with
warm soapy water when you begin your initial seasoning.
8
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
www.camplux.com
The choice of oil
The choice of some oils are important for seasoning.
Using Flax seed oil for your initial seasoning as it creates a very durable bond. Any of the following oil can be used:
● Flax Seed Oil
● Extra Virgin Olive Oil
● Vegetable Oil
● Soy Oil
The purpose behind your initial seasoning is to create a bond with the griddle top by coating your griddle with oil
and heat the oil above its smoke point to polymerize the oil. You will make a black, stick resistant surface easy to
clean.
Seasoning the griddle
1. Put small amount of chosen oil to the surface of the griddle
top and spread it around with a cloth or paper towel (use
tongs or metal spatulas to hold the cloth or paper towel).
2. Make it medium-high heat.
3. It is good to heat the oil until it reaches its “smoke-point”
and let it continue to discolor.
4. To make a good black surface , make sure to repeat steps 1
through 3 a few times after it cool down.
The Storage of Griddle
DANGER
Never put griddle in storage or travel mode at once after use when it is too hot to touch and make sure it cool
down. Not following the direction could result in fire resulting in property damage, personal injury or death.
● For portable/tabletop griddles, disconnect from the recreational vehicles low pressure LP gas supply system via
quick-disconnect fitting (following applicable safety steps).
● Turn it off before storing portable griddle indoors. Disconnect it from the low pressure gas system, and the unit
itself is at room temperature.
Clean the Burner
Follow these instructions to clean the burner.
1. Shut gas “OFF” at the control knob.
2. Ensure the entire griddle is cooled down.
3. Remove griddle plate from assembly.
4. Use wire brush to clean the entire outer surface of the burner to remove food residue and dirt.
5. Clean any blocked ports with a stiff wire such as an open paper clip.
6. Wear eye protection and use an air hose to force air into the burner tube and out the burner ports.
Ensure each port to make sure air is flowing out each respective nozzle.
Flame
9
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
www.camplux.com
Tabla de contenidos
Idiomas:
Otros manuales de Electrodoméstico de cocina de Camplux
