Camplux SG101 Manual de usuario
GAS INFRARED GRILL
Model No.:CAMPLUX SG101
USE & CARE MANUAL
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
11
DANGER
If you smell gas:
● Extinguish any open flame.
● Open lid.
● If odor continues,keep away from the appliance and immediately call your
fire department.
Failure to follow these instructions and result in fire or explosion which could cause
property damage,personal injury or death.
DANGER
● Never operate this appliance unattended.
● Never operate this appliance within 10ft (3.0 m) of any structure，combustible
material or other gas cylinder.
● Never operate this appliance within 25 ft (7.5 m) of any flammable liquid.
● If a fire should occur,keep away from the appliance and immediately call your fire
department.Do not attempt to extinguish an oil or a grease fire with water.
This instruction manual contains important information necessary for the proper
assembly and safe use of the appliance.
Read and follow all warnings and instructions before assembling and using the
appliance.
Follow all warnings and instructions when using the appliance.
PLEASE KEEP THIS MANUAL FOR FUTURE REFERENCE.
Table Of Content
For Your Safety ………………………………………………………............…..........
Explosive View ………………………………………………..................................…
Assembly Instructions ……………………………………………………...............….
In the Box …………………………………………………...................…...............….
Quick Installation ……….......……………………………......………...............….
Connecting/Disconnecting LP Gas Cylinder …………………………..……….......
Leakage Test …………………………...............................................................…
Lighting Instruction ………………………...........................................…………
Shutdown Instruction ……………………………...................………………………
Maintenance …………………………….........................................................……
Troubleshooting ……………………………………………………................………
2
4
5
6
6-10
11
11
12-13
13
14
14
www.camplux.com
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
2
For Your Safety
FOR OUTDOOR USE ONLY!
Never use this appliance in a building, garage or any other enclosed area.
This appliance is not intended to be installed in or on a boat or recreational vehicle.
The appliance is not intended for commercial use.
Minimum clearance from sides and back of unit to combustible construction,
24 inches from sides and 24 inches from back.
Do not use this appliance under a combustible surface.
This appliance is for use with liquid propane (LP) gas only. The conversion to or
attempted use of natural gas in this LP gas appliance is dangerous and will void
your warranty.
The LP gas supply cylinder to be used must be constructed and marked in
accordance with the specifications for LP gas cylinders, U.S. Department of
Transportation (DOT) or the Standard for Cylinders, Spheres and Tubes for the
Transportation of Dangerous Goods, CAN/CSA-B339.
Use only 16.4 oz propane gas cylinder.
Only cylinders marked “propane” must be used.
The cylinder supply system must be arranged for vapor withdrawal.
The cylinder must be disconnected when the appliance is not in use.
a) Do not store a spare LP gas cylinder under or near this appliance.
b) Use only 16.4 oz (1 lb). capacity disposal propane gas cylinder, never
fill the cylinder, and if the instructions in (a) and (b) are not followed exactly, a
fire causing death or serious injury may occur.
The pressure regulator assembly supplied with the appliance must be used.
Replacement pressure regulators assemblies shall be those specified by the
appliance manufacturer.
www.camplux.com
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
3
CAUTION
The gas pressure regulator provided with this appliance must be used. Replace
only with regulator Model No. KR-106A.
WARNING
● The use of alcohol, prescription or non-prescription drugs may impair the
consumer's ability to properly assemble or safely operate the appliance.
● When cooking with oil or grease, have a type BC or ABC fire extinguisher
readily available.
● In the event of an oil or grease fire do not attempt to extinguish with water.
Immediately call the fire department. A Type BC or ABC fire extinguisher may,
in some circumstances contain the fire.
● Do not leave the appliance unattended. Keep children and pets away from the
appliance at all times.
● Do not move the appliance when in use.
● This appliance is not intended for and should never be used as a heater.
● This appliance will be hot during and after use. Use insulated oven mitts or
gloves for protection from hot surfaces or splatter from cooking liquids.
California Proposition 65
WARNING
This product can expose you to Carbon Monoxide/Lead, which is known to the
State of California to cause birth defects or other reproductive harm. For more
information go to www.P65Warnings.ca.gov.
www.camplux.com
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
4
1. Top Panel
2. Front Panel-top
3. Burner
4. Burner Support
5. Combustion Chamber-inner Around
6. Pilot, Electrode And Wire Assembly
7. Support Panel
8. Shell-outer Around
9. Lifting Handle Support
10. Lifting Handle
11. Bottom Panel
12. Legs
13. Grill Plate
14. Grill Tray
15. Adjustable Rack & Tray Support
16. Adjustable Rack & Tray Support Handle
Please contact the manufacturer or dealer to obtain replacement parts.
17. Guide Wheel 1
18. Guide Wheel 2
19. Adjustable Rack & Tray Support-support
20. Adjustable Rack & Tray Support-outter
21. Interlock
22. Adjustable Rack & Tray Support Handle
23. Front Panel-left Side
24. Control Knob
25. Burner Control Knob
26. Front Panel-bottom
27. Front Panel-right Side
28. Qdd With Female Connector
29. Regulator And Qdd With Male Connector
30. Cylinder (Not Supply)
31. Ignition Control
Explosive View
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
www.camplux.com
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
Assembly Instructions
The installation must conform with local codes or, in the absence of local codes,
with the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Storage and Handling of
Liquefied Petroleum Gases, ANSI/NFPA 58; or Natural Gas and Propane
Installation Code, CSA B149.1; Propane Storage and Handling, CSA B149.2, or
the Standard for Recreational Vehicles, ANSI A119.2/NFPA 1192; and
Recreational Vehicle Code, CSA Z240 RV Series, as applicable.
This appliance must be installed on the opposite side, from the fuel
distribution/dispensing system of RV.
The insallation of the appliance must preclude the possibility of operation or gas
flow when in storage (travel) position.
This appliance must be connected to the vehicles propane system with a flexible
hose connector complying with the high pressure requirements of the Standard for
Pigtails and Hose Connections for LP-Gas, ANSI/UL 569, and must be of the
length no longer than that required to allow the grill to be mounted in the “in Use”
position of its mounting system.
The hose must be installed in a manner that will not allow it to come in contact
with the hot surface of the grill while in use or in the storage/travel mode.
WARNING
Do not use this appliance under extended awnings. Failure to comply could result
in a fire or personal injury.
DANGER
Do not put grill in storage or travel mode immediately after use. Allow grill to cool
to touch before moving or storing. Failure to do so could result in fire resulting in
property damage, personal injury, or death.
5
www.camplux.com
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
In the Box 6
Quick Installation
1. Operating the grilling plate lifting and illustration,always pay attention to the
position of the thumb button up, and move up to adjust the grilling plate in the
proper position.
2. The ignition knob and the grille was not installed before the factory, please
install as per users manual.
3. To prevent excessive force damage,please always take wrenches by the torque
value 60-70 N when you connecting gas regulator and gas source. Or leads
gas leakage if sealed by small force.
Attention to the position
of the thumb button up
Screw
Camplux infrared gas grill
Grille handle
Grille
Trays (smaller one is at the bottom of the grille plate for
drippings/oil, bigger one is for warming cooked foods)
5 feet gas regulator
Male connector for propane tank
Instruction manual in English & French
1
1
1
2
1
1
1
1
2
3
4
5
6
7
Packing List Qty
www.camplux.com
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
Instruction Guide for Adjustable Grille
STEP 1: Hold the grille handle with four fingers, press the armrest knob with your
thumb (as shown below), pull out the grille handle and move it upward.
STEP 2: Move to desired layer.
STEP 3: Loosen the grille handle then you can regularize the layer position of the
steak rack. Repeat step 1 to step 3 to if you want adjust different layers
again.
Battery installation guide
1pcs AA battery required for ignition (not included)
Open the battery compartment cover on the left, insert one AA battery (not
included) and pay attention, make sure the AA battery is facing down before
ignition.
7
Armrest knob
Grille handle
www.camplux.com
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
8
Multiple & Quick Installation
1. You can connect to standard 20lb propane cylinder with supplied gas regulator
quickly.
STEP 1: Remove all parts from the carton and lay them out on a smooth, clean
place. Verify all parts in explosive view are included and without damage.
STEP 2: Connect regulator.
STEP 3: Tested outdoors in a well-ventilated area, away from ignition sources
such as gas fired or electrical appliances to make sure no gas leaks and
keep grills away from open flames or sparks.
www.camplux.com
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
9
2. Connect to standard RV propane directly.
STEP 1: Remove all parts from the carton and lay them out on a smooth, clean
place. Verify all parts in explosive view are included and without damage.
STEP 2: Connect the gas hose from RV.
STEP 3: Tested in a well-ventilated RV, away from ignition sources
such as gas fired or electrical appliances to make sure no gas leaks and
keep grills away from open flames or sparks.
5/8 "-18 UNF male connector
5/8"-18UNF female connector
Connect to RV gas supply
5/8"-18 UNF male connector
LPG gas regualtor
Connect to LPG cylinder
20LB LPG
cylinder
5/8"-18 UNF female connector
www.camplux.com
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420 1(844) 538-7475
Tabla de contenidos
Idiomas:
Otros manuales de Parrilla de Camplux
