Buderus GB142 Manual de usuario
7215 0300 - 02/2008 US/CA (en) For the user
Please read thoroughly before operating
User’s Instructions
Condensing gas boiler
GB142-24/30/45/60
This manual must be retained for future use.
2http://www.buderus.net
Warning: If the information in these instructions is not followed exactly, a fire or
explosion may result causing property damage, personal injury or loss of life.
– Do not store or use gasoline or other flammable vapors and liquids in the vicinity
of this or any other boiler.
– What to do if you smell gas
• Do not try to light any boiler.
• Do not touch any electrical switch; do not use any phone in your building.
• Immediately call your gas supplier from a neighbor’s phone. Follow the gas
supplier’s instructions.
• If you cannot reach your gas supplier, call the fire department.
– Installation and service must be performed by a qualified installer,
service agency or the gas supplier.
CAUTION !
The operating manual is part of the documentation that is delivered to the
installation's operator. Go through the information in this manual with the owner/
operator and make sure that he or she is familiar with all the necessary operating
instructions.
http://www.buderus.net 3
Contents
1 For your safety . . . . . . . . . . . . . . . . . . . . 5
1.1 Designated use . . . . . . . . . . . . . . . . . . . . . . 5
1.2 Safety instructions . . . . . . . . . . . . . . . . . . . . 6
2 Lighting Instructions . . . . . . . . . . . . . . . 8
2.1 Operating the BC10 basic controller . . . . . . 9
2.2 Opening and closing the control panel . . . . 10
2.3 Switching on and off . . . . . . . . . . . . . . . . . . 10
2.4 Setting the DHW temperature value . . . . . 11
2.5 Entering the space heating water
temperature . . . . . . . . . . . . . . . . . . . . . . . . 13
2.6 "Burner on" LED . . . . . . . . . . . . . . . . . . . . . 14
2.7 Other functions and economic heating . . . 14
3 Starting up and shutting down
the boiler . . . . . . . . . . . . . . . . . . . . . . . 15
3.1 Starting up the boiler . . . . . . . . . . . . . . . . . 15
3.2 Shutting down the boiler . . . . . . . . . . . . . . 18
4 Operating and error messages . . . . . . 19
4.1 Displaying operating messages . . . . . . . . . 19
4.2 Identifying and resetting faults . . . . . . . . . . 23
4http://www.buderus.net
Preface
About these instructions
These user's Instructions contain important information for the safe and proper operation of
GB142-24/30/45/60 condensing gas boilers.
If the information in this manual is not followed exactly, a fire or explosion may result causing property
damage, personal injury or loss of life.
Subject to technical changes!
Changes may be made following technical improvements!
Updating of documentation
Please contact us if you have any suggestions for improvements or corrections.
http://www.buderus.net 5
For your safety
1 For your safety
GB142 condensing gas boilers are designed and
built according to the latest technological advances
and safety requirements.
The design is specifically focused on ease of use.
To ensure the safe, economical and environmen-
tally friendly use of the heating system we urge you
to read and observe the User's Instructions.
1.1 Designated use
The GB142 was designed for heating water for a
central heating system and for generating domestic
hot water. The boiler can be fitted with a modulating
outdoor reset control AM10 (scope of delivery),
a room controller RC35 (optional) or an On/Off
thermostat (accessory).
Hazard definitions
ADANGER:
Indicates the presence of hazards that will
cause severe personal injury, death or
substantial property damage.
AWARNING:
Indicates the presence of hazards that can
cause severe personal injury, death or
substantial property damage.
ACAUTION:
Indicates presence of hazards that will or
can cause minor personal injury or property
damage.
HCAUTION:
Risk of electric shock.
Indicates presence of hazards due to electric
shock.
6http://www.buderus.net
For your safety
INOTICE
Indicates special instructions on installation,
operation or maintenance that are important
but not related to personal injury or property
damage.
1.2 Safety instructions
Make sure to observe these safety instructions.
Failure to do so can result in property damage,
personal injury or loss of life.
– Installation, gas and flue connection,
commissioning, electrical connection and
maintenance activities must only be carried out
by a trained service provider.
– Certain work, e.g. on gas lines, may require a
professional license. Only carry out such work if
you are licensed to do so.
– Only use the boiler for its intended purpose and
only when it is in working order.
– Have a trained service provider check, clean
and service the heating system once a year.
Buderus recommends a contract for annual
service and maintenance.
– The condensate collection and disposal system
must be periodically cleaned by a trained
service technician.
– Have your trained service provider give you
detailed instructions about the operation of the
heating system.
– Carefully read these user's instructions.
– Immediately have all defects to the heating
system repaired.
– Ensure that air intake and outlet openings are
open and free from obstructions at all times.
– Do not store any flammable material or liquids in
the immediate vicinity of the boiler.
http://www.buderus.net 7
For your safety
– Never use chlorinated detergents or
halogenated hydrocarbons (e.g. in spraycans,
solvents and detergents, paints, adhesives) in
the room where the boiler is installed.
– When Calcium Chloride is present in concrete
floors (when poured in winter) it is necessary to
seal the floor with a suitable paint.
– Do not allow too much dust to collect on the
device.
– Do not use the boiler if any part has been under
water. Immediately call a trained service
technician to inspect the boiler and to replace
any part of the control system and any gas
control which has been under water.
– Should overheating occur or the gas supply fail
to shut off, do not turn off or disconnect the
electrical supply to the pump. Instead, shut off
the gas supply at a location external to the
boiler.
– The venting system must be inspected annually.
Replace any parts which show deterioration
from corrosion or any other sources.
– This boiler does not have a pilot. It has an
ignition device which automatically lights the
burner.
– Check for smell of gas around the boiler area.
Be sure to smell next to the floor because
propane gas is heavier than air and will settle on
the floor.
– Use only your hand to turn the gas control knob
(fig. 3 on page 15). Never use tools. If the knob
will not turn by hand, don't try to repair it, call a
trained service technician. Force or attempted
repair may result in a fire or an explosion.
8http://www.buderus.net
Lighting Instructions
2 Lighting Instructions
ASTOP!
Read the chapter "For your safety" on page 5 before
lighting the boiler.
http://www.buderus.net 9
Lighting Instructions
2.1 Operating the BC10 basic controller
1) ECO mode means that the temperature inside the hot water tank is 140 °F.
Fig. 1 Logamatic BC10 basic controller – Controls
pos. 1: Main switch
pos. 2: DHW temperature knob 1)
pos. 3: LED "DHW status"
pos. 4: Display
pos. 5: Space heating water
temperature knob
pos. 6: LED "Burner status"
pos. 7: LED "Burner Operation"
pos. 8: Service Tool connector
pos. 9: "Service" button
pos. 10:"Chimney sweep" button
pos. 11:"Reset" button
190
170
150
130
90
110
140
130
120
90
100
110
42
1
5
711 910
3 6
8
10 http://www.buderus.net
Lighting Instructions
2.2 Opening and closing the control panel
zBriefly push the drawer to open the control panel (fig. 2).
The drawer will come out. The control panel consists of the
Logamatic BC10 basic controller (fig. 1).
z
Close the control panel by pushing it back into the boiler
.
2.3 Switching on and off
zSet the main switch on the BC10 to position "1" (On) to
switch on the boiler and set it to "0" to switch it off.
HCAUTION
Risk of electric shock.
If a hazardous situation occurs, shut off power to the
boiler using the emergency shutoff switch or the boiler
circuit breaker (see chapter 3 "Starting up and shutting
down the boiler", page 15). Make yourself familiar with
the location of the emergency shutoff switch and the
boiler loop circuit breaker.
Fig. 2 Opening and closing the control panel
Otros manuales para GB142
4
Tabla de contenidos
Otros manuales de Caldera de Buderus
Buderus
Buderus 600 - 11S Manual de usuario
Buderus
Buderus Logamax plus GB162 Guía de inicio rápido
Buderus
Buderus Logamax plus GB162 Manual de usuario
Buderus
Buderus Logano G115 WS US/CA Manual de usuario
Buderus
Buderus 500-24S Manual de usuario
Buderus
Buderus Logamax plus GB142-60 Manual de usuario
Buderus
Buderus Logamax plus GB142-24 Guía del usuario
Buderus
Buderus 500 - 24/S Manual de usuario
Buderus
Buderus Logano G215 WS Manual de usuario
Buderus
Buderus 500-24C Manual de usuario
Buderus
Buderus Logano US GC 144 II Guía rápida
Buderus
Buderus 500 - 28/C Manual de usuario
Buderus
Buderus SB735 Series Manual
Buderus
Buderus Logano G225 Guía rápida
Buderus
Buderus 500 - 24/C Manual de usuario
Buderus
Buderus Logano GA124 Manual de usuario
Buderus
Buderus Logano GE315 Manual de usuario
Buderus
Buderus Logano GA244-37 Manual
Buderus
Buderus Logano G334 X Manual de usuario
Buderus
Buderus Logano plus GB102 Manual de usuario
Manuales populares de Caldera de otras marcas
ECR International
ECR International UB90-125 Manual de instrucciones
Froling
Froling FHG Turbo 3000 Manual de usuario
Froling
Froling P4 Pellet 8 - 105 Manual de usuario
U.S. Boiler Company
U.S. Boiler Company K2 Manual de usuario
Henrad
Henrad C95 FF Manual de usuario
NeOvo
NeOvo EcoNox EF 36 Manual de usuario
