Bradley SN2003 Guía de inicio rápido

P.O. Box 309, Menomonee Falls, WI USA 53052-0309

800 BRADLEY (800 272 3539) +1 262 251 6000

bradleycorp.com

Parts & Service

Sentry Washfountain

Current Models After

February 1, 2013

SN2003

36" Semi-Circular, Floor-Mounted

SN2004

54" Semi-Circular, Floor-Mounted

SN2023

36" Semi-Circular, Wall-Mounted

SN2024

54" Semi-Circular, Wall-Mounted

SN2005

36" Circular, Floor-Mounted

SN2008

54" Circular, Floor-Mounted

SN2013

54" Corner, Floor-Mounted

SN2033

54" Corner, Wall-Mounted

Table of Contents

How to Determine Drain Type...................................................... 2

IR Assemblies, Troubleshooting and Wiring ................................ 3

Sentry Transformers................................................................... 14

Supply Valves ........................................................................... 15

AST4 Assemblies, Adjustments and Troublshooting ................. 16

Navigator®Thermostatic Mixing Valve ...................................... 26

Control Valve Illustrations........................................................... 27

Check Valve Troubleshooting Instructions ................................. 28

Care and Cleaning of Stainless Steel Sentry Washfountains.... 28

Soap System ............................................................................. 29

Pedestal Assembly..................................................................... 31

Backsplash Retrofit Kits............................................................. 32

Shroud/Towel Dispenser (Installed on a Shroud) ...................... 33

Towel Dispenser (Installed on a Pipe) ....................................... 34

215-1472 Rev. J; ECN 15-00-002

Page 1 of 34 3/23/2015

SN2003 (AST shown)

SN2005 (AST shown)

SN2013 (AST-4 shown)

SN2008 (AST shown)

SN2033 (IR shown)

SN2023 (IR shown)

SN2004 (AST-F shown)

Sentry Washfountain Parts and Service

23/23/2015 Bradley • 215-1472 Rev. J; ECN 15-00-002

How to Determine Drain Type

Parts may vary depending upon drain type. Identify your drain type before continuing.

TYPE A:

SUPPLIES BELOW

VENT OFF DRAIN

P-TRAP FURNISHED BY OTHERS

TYPE B:

SUPPLIES ABOVE

CENTRALLY-RISING VENT

P-TRAP FURNISHED

TYPE O:

SUPPLIES ABOVE

VENT OFF DRAIN

P-TRAP FURNISHED BY OTHERS

TYPE H:

SUPPLIES BELOW

CENTRALLY-RISING VENT

P-TRAP FURNISHED

Parts and Service Sentry Washfountain

Bradley • 215-1472 Rev. J; ECN 15-00-002 3/23/2015

Infrared (IR) — Sprayhead Assembly

Item Part No. Description 54" Corner

Qty.

36" Semi

Qty.

54" Semi

Qty.

36" Circle

Qty.

54" Circle

Qty.

1 — Shell 1 1 1 1 1

2 269-982 Lens (window) 3 3 4 5 8

3 160-245 Screw 10-24 x 1/2" 6 6 8 10 16

4 142-002BT Lock Washer 6 6 8 10 16

5 142-002AV Flat washer 6 6 8 10 16

6 269-1184 Sensor 3 3 4 5 8

7 182-100 Lens Support (Rubber Block) 3 3 4 5 8

8 159-363 Sensor Mounting Bracket 3 3 4 5 8

9 161-082 Nut - Extension 1/4"-20 x 5-1/8" 2 2 2 2 2

10 269-621 Terminal - female disconnect 9 9 12 15 24

11 S05-157 Aerator Assembly (Std 0.5 GPM) 3 3 4 5 8

12 110-115 Nut - 1/2" - 14 3 3 4 5 8

Item Part No. Description Qty

1 S05-142A Std. Aerator, 0.5 GPM 1

2 153-402A Adapter 1

3 145-090 90° Connector 1/4" tube x 1/8" NPT 1

4* 130-141 Spanner Wrench for Aerator - Before August 2014 —

4* 130-149 Spanner Wrench for Aerator - After August 2014 —

Parts List — Infrared Sensor and Module

Parts List — Aerator Assembly (S05-157)

511

*Spanner wrench not included in Assemblies

Sentry Washfountain Parts and Service

43/23/2015 Bradley • 215-1472 Rev. J; ECN 15-00-002

Infrared (IR) Part 1 — Solenoid Valve Assembly (24V Transformer)

Item Part No. Description Qty.

1 S27-340 Stop Valve 2

2 269-2053 Flex Hose 2

3 140-928 Bracket 1

4 269-625 Terminal Block 1

5 P18-054 Screw #10-24 x 3/8 2

6 160-447 Screw #8-16 x 5/8 3

7 S01-526 Thermostatic Mixing Valve 1

8 S39-804 Adapter (Optional Single Tempered Line) 1

9 S07-067 Solenoid Valve - Closed Body (Black) 1

10 S07-067A Solenoid Valve - Thru Body (Gray) 2

11 R68-600011-B Tubing 1/4 OD Black *

12 R68-600011-G Tubing 1/4 OD Green *

13 R68-600011-R Tubing 1/4 OD Red *

14 S45-2521 Valve Assembly TMA 36S and 54K 1

* Specify Length in feet.

Parts List — Solenoid Valve Assembly (54" Corner and 36" Semi)

Parts and Service Sentry Washfountain

Bradley • 215-1472 Rev. J; ECN 15-00-002 3/23/2015

Infrared (IR) Part 1 — Solenoid Valve Assembly (24V Transformer)

Item Part No. Description Qty.

1 S27-340 Stop Valve 2

2 269-2053 Flex Hose 2

3 140-928 Bracket 1

4 269-647 Terminal Block 1

5 P18-054 Screw #10-24 x 3/8 2

6 160-447 Screw #8-16 x 5/8 4

7 S01-526 Thermostatic Mixing Valve 1

8 S39-804 Adapter (Optional Single Tempered Line) 1

9 S07-067 Solenoid Valve - Closed Body (Black) 1

10 S07-067A Solenoid Valve - Thru Body (Gray) 3

11 R68-600011-Y Tubing 1/4 OD Yellow *

12 R68-600011-B Tubing 1/4 OD Black *

13 R68-600011-G Tubing 1/4 OD Green *

14 R68-600011-R Tubing 1/4 OD Red *

15 S45-2523 Valve Assembly TMA 54S 1

Parts List — Solenoid Valve Assembly (54" Semi)

* Specify Length in feet.

Sentry Washfountain Parts and Service

63/23/2015 Bradley • 215-1472 Rev. J; ECN 15-00-002

Infrared (IR) Part 1 — Solenoid Valve Assembly (24V Transformer)

Item Part No. Description Qty.

1 S27-340 Stop Valve 2

2 269-2053 Flex Hose 2

3 140-940 Bracket 1

4 269-625 Terminal Block 2

5 P18-054 Screw #10-24 x 3/8 2

6 160-447 Screw #8-16 x 5/8 5

7 S01-526 Thermostatic Mixing Valve 1

8 S39-804 Adapter (Optional Single Tempered Line) 1

9 S07-067 Solenoid Valve - Closed Body (Black) 1

10 S07-067A Solenoid Valve - Thru Body (Gray) 4

11 R68-600011-Y Tubing 1/4 OD Yellow *

12 R68-600011-B Tubing 1/4 OD Black *

13 R68-600011-G Tubing 1/4 OD Green *

14 R68-600011-R Tubing 1/4 OD Red *

15 R68-600011 Tubing 1/4 OD Clear *

16 S45-2525 Valve Assembly TMA 36C 1

Parts List — Solenoid Valve Assembly (36" Circle)

* Specify Length in feet.

Parts and Service Sentry Washfountain

Bradley • 215-1472 Rev. J; ECN 15-00-002 3/23/2015

Infrared (IR) Part 1 — Solenoid Valve Assembly (24V Transformer)

Item Part No. Description Qty.

1 S27-340 Stop Valve 2

2 269-2053 Flex Hose 2

3 140-941 Bracket 1

4 269-647 Terminal Block 2

5 P18-054 Screw #10-24 x 3/8 2

6 160-447 Screw #8-16 x 5/8 8

7 S01-526 Thermostatic Mixing Valve 1

8 S39-804 Adapter (Optional Single Tempered Line) 1

9 S07-067 Solenoid Valve - Closed Body (Black) 1

10 S07-067A Solenoid Valve - Thru Body (Gray) 7

11 R68-600011-Y Tubing 1/4 OD Yellow *

12 R68-600011-B Tubing 1/4 OD Black *

13 R68-600011-G Tubing 1/4 OD Green *

14 R68-600011-R Tubing 1/4 OD Red *

15 S45-2527 Valve Assembly TMA/IR 54C 1

Parts List — Solenoid Valve Assembly (54" Circle)

* Specify Length in feet.

Sentry Washfountain Parts and Service

83/23/2015 Bradley • 215-1472 Rev. J; ECN 15-00-002

Infrared (IR) Part 2 — Solenoid Valve Assembly (24V Transformer)

12 or

Item Part No. Description Qty.

1 110-231 Nut 1/4 Tube 1

2 118-307 Valve Body 1/4" Closed 1

3 118-307A Valve Body 1/4" Thru 1

4 125-165 O-Ring 1

5 269-983 Diaphragm 1

6 269-577 Armature 1

7 269-578 Spring 1

8 269-1729 Armature Housing 1

9 269-1730 Clamp 1

10 160-447 Screw #8-16 x 5/8 3

11 269-579 Coil, Solenoid Valve 1

12 S07-067S Solenoid Valve Closed Body (Black) 1

13 S07-067AS Solenoid Valve Thru Body (Gray) 1

Parts List — Solenoid Valve Assembly

Parts and Service Sentry Washfountain

Bradley • 215-1472 Rev. J; ECN 15-00-002 3/23/2015

Infrared (IR) — Sensor and Solenoid Valve Troubleshooting

If a station is not functioning properly it is most likely either the solenoid valve or the sensor.

Troubleshooting multi station units is fairly easy, as you can swap parts (actually just by changing the wires) and use

the process of elimination to figure out which of the 2 parts is causing the problem.

How the system operates:

1. The transformer sends 24 volts to the sensor.

2. The sensor acts only as a switch.

3. When hands go into the active field of the sensor, the sensor activates and sends a power signal on to the

solenoid valve.

4. The power signal activates and opens the solenoid valve which allows the water to flow to the sprayhead.

The solenoid valve stays open allowing water to flow as long as it is receiving a signal form the sensor

(hands remain in the active field).

5. When hands are removed from the active field, the sensor turns off (note some models have a slight delay

feature built-in.) and shuts off the power signal to the solenoid valve.

CAUTION: Turn off water supplies to unit before troubleshooting.

Problem Cause Solution

An individual

operating station

fails to shut off and

drips.

There is debris

trapped between

the diaphragm

and the valve

seat.

Remove debris between diaphragm and the valve seat.

1. Remove the three #8 Phillips-head screws that hold the solenoid valve assembly

together. Be careful not to lose the armature or spring.

2. Remove the diaphragm. Remove any particles that have been trapped between the

diaphragm and the valve seat. Rinse off the diaphragm and inspect for damage.

Make sure the center orifice and both small side orifices are open.

3. Reassemble in reverse order, being careful not to overtighten the Phillips-head

screws or you may crack the plastic valve body. Tighten until the armature plate

makes contact with the plastic body.

4. Reconnect the wiring per the appropriate diagram on next 4 pages.

An individual

operating station

fails to turn on.

A failed coil for

the valve or

loose electrical

connection to the

terminal.

Test the station to determine cause.

1. Disconnect the wires from the coil of an adjacent valve. Disconnect the wires from

the problem valve and reconnect to the adjacent valve.

2. Turn on electrical and water supplies to the unit. Pass your hand in front of the

sensor of the problem station, and the adjacent station should turn on.

a. If the adjacent station turns on and cycles normally, replace the coil on the

problem valve.

b. If the adjacent valve fails to turn on, inspect the wires from the sensor cable

and do the following:

• make sure there are no breaks and that the fully insulated disconnect

terminals are firmly crimped in place;

• turn off the electrical and water supplies;

• reconnect to the adjacent valve and turn on the water supplies to the unit;

• pass your hand in front of the sensor. If the station still fails to turn on,

replace the sensor.

Sentry Washfountain Parts and Service

10 3/23/2015 Bradley • 215-1472 Rev. J; ECN 15-00-002

Infrared (IR) SN2003, SN2023, SN2013, SN2033 Wiring Diagram

IR Sensor

(269-1184)

Left

Sensor

(Black)

Center

Sensor

(Green)

Right Sensor

(Red)

Black

Blue

Brown

To p

Red

Blue

Black

Transformer

(269-645)

Red Supply

Tube

Green Supply Tube

Black Supply Tube

To p

Compression Nut

Navigator Mixing

Valve or Tempered

Line Adaptor

Valve Set

(S45-2521 or S45-2522)

Terminal Block

(269-625)

Otros manuales para SN2003

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Fuente al aire libre de Bradley

Bradley

Bradley Terreon Classic WF2500 Series Manual de usuario

Bradley

Bradley Terreon Classic WF2500 Series Manual de usuario

Bradley

Bradley Terreon Classic WF2500 Series Manual de usuario

Bradley

Bradley Terreon TDB3108 Manual de usuario

Bradley

Bradley Terreon Multi-Fount Series Manual de usuario

Bradley

Bradley Terreon Tri-Fount MF2933/IR Manual de usuario

Bradley

Bradley Terreon TDB3103 Manual de usuario

Bradley

Bradley Stainless Steel WF2700 Series Manual de usuario

Bradley

Bradley Bradstone WF2800 Series Manual de usuario

Bradley

Bradley Terreon Classic WF2500 Series Manual de usuario

Bradley

Bradley SN2013/AST4-F Manual de usuario

Bradley

Bradley Terreon Classic WF2500 Series Manual de usuario

Bradley

Bradley Terreon Classic WF2500 Series Manual de usuario

Bradley

Bradley BradMate S93-574 Manual de usuario

Bradley

Bradley S19-220SC Manual de usuario

Bradley

Bradley SN2005/AST4 Manual de usuario

Bradley

Bradley Sentry SN2004/IR Guía de inicio rápido

Bradley

Bradley Terreon Quadra-Fount MF2949/TT Manual de usuario

Bradley

Bradley WF2605 Manual de usuario

Bradley

Bradley SN2004 Manual de usuario

Bradley

Bradley Terreon Quadra-Fount TouchTime MF2944 Manual de usuario

Manuales populares de Fuente al aire libre de otras marcas

Sunnydaze Decor

Sunnydaze Decor XSS-578 Manual de usuario

Campania International

Campania International Bibendum FT-400 Manual de usuario

Elkay

Elkay FLEXI-GUARD EFHA8 1M Series Manual de instalación

S.R.Smith

S.R.Smith Color Light Stream 2CLSLBK Manual de usuario

Hozelock Cyprio

Hozelock Cyprio Cascade 1500 Manual de usuario

Campania International

Campania International Juliet Fountain Manual de usuario

YARDART

YARDART FT-155 Manual de usuario

Alpine

Alpine WIN732 Manual de usuario

Campania

Campania Valencia Manual de usuario

Campania International

Campania International FT-320 Manual de usuario

GardenWize

GardenWize SWGSL230 Manual de usuario

Kelkay

Kelkay Easy Fountain Rustic Windmill Manual de usuario

Alpine

Alpine WIN258 Manual de usuario

Bond

Bond Signature Series Manual de usuario

Kenroy Home

Kenroy Home 51112COPBL Guía de instalación

EasyPro

EasyPro Tranquil Décor HBB39 Manual de usuario

Angelo Decor

Angelo Decor Castillo Manual de usuario

Campania International

Campania International Girona FT-102A Manual de usuario