Bosch 715ES Manual de referencia

Models: 715ES, C800ES, C920ES, C920ESC, 2400ES, 2700ES

Descaling the heat exchanger

Service Bulletin G3-13

Introduction

Periodic descaling may be necessary in areas where the water

supply is highly mineralized. Scale build up in the heat

exchanger may result in reduced ow rates, error codes and boil-

ing sounds in the heat exchanger.

Tools needed:

Various plumbing wrenches

5 gallon bucket for descaling solution

Small circulator or pump

3 Hoses for circulating

Filter for descaling solution

Descaling procedure

1. Clear error code (if displayed) by pressing the reset button.

2. Press On/Off button to "Off".

3. Disconnect electrical supply from the water heater.

4. Shut off the water supply to the water heater using (installer

supplied) isolation or shutoff valves.

5. Open hot water taps to drain and relieve pressure from the

plumbing system.

6. Drain water by disconnecting the inlet and outlet water connec-

tions from the heater.

7. Connect a hose (A) from the outlet of the circulating pump

(installer supplied) to the inlet water tting on the water heater.

(Fig. 1)

8. Connect another hose (B) to the water outlet fitting on the water

heater. Route the other end of this hose into a descaling reser-

voior or bucket. (Fig. 1)

9. Using a 3rd hose (C) from the descaling reservoir, connect to the

inlet side of the circulator/pump. Install a filter on the end of

the hose in the descaling reservoir. (Fig. 1)

Figure 1

10. Make sure all connections are 'hand tight'.

11. Fill reservoir/bucket with descaling solution so both hoses inside

are submersed. We recommend straight white vinegar. If using

a commercial descalant, refer to manufacturer‘s instructions for

proper dilution ratio with water.

12. Operate the circulating pump.

13. Make sure there are no leaks and the solution is owing from the

descaling reservoir, through the heater and returning to the

reservoir.

Data subject to change without notice | Printed in the USA | BTC710002307 A | 01.2009 Bosch Thermotechnology Corp.

Service bulletin

18 | G3-13 | 715ES, C800ES, C920ES, C920ESC, 2400ES, 2700ES

Bosch Thermotechnology Corp.

50 Wentworth Avenue

Londonderry, NH 03053

Tel: 1-866-642-3198

Fax: 1-603-584-1681

www.boschhotwater.com

14. Run solution through the heater until the solution returning to

the descaling reservoir/bucket comes out clear. Changing to a

fresh solution may be necessary during this process.

15. Properly discard of dirty descaling solution. Disconnect lines A

and C (Fig. 1). Reconnect cold water supply to the water heater.

16. Open cold supply shutoff valve to ush water heater with clean

water. Allow enough water to ow through the heater to

properly ush it. Filling the 5 gallon descaling bucket once

should be sufcient.

17. Close cold water shutoff valve and disconnect line B (Fig. 1).

Reconnect hot water line to the water heater.

18. Plug in power cord and press On/Off button to "On".

19. Open water shutoff valves, and return water heater to service.

Water Quality

Water quality can have an impact on appliance longevity and may

void the manufacturer’s warranty.

 For water analysis data, call your local water department. If on a

well, have the well water analyzed periodically. If water quality

exceeds one or more of the values specied in Figure 2, Bosch

recommends consulting a local plumber about installing a water

conditioner or softener.

 If the tankless water heater is operating in applications where

the outlet temperature exceeds 140°F, a water softening system

is strongly recommended. The higher the set temperature is on

the appliance, the greater the risk for scale/mineral deposits.

Damage from scale/mineral deposits is not covered under

warranty. Refer to manufacturer’s limited warranty.

Figure 2

Description Max. Levels

pH pH 6.5 - 8.5

TDS (total Dissolved

Solids) mg/l or ppm 500

Total hardness gpg or ppm 100

(6 gpg)

Aluminum mg/l or ppm 2.0

Chlorides mg/l or ppm 250

Copper mg/l or ppm 1.0

Iron mg/l or ppm 0.3

Manganese mg/l or ppm 0.05

Zinc mg/l or ppm 5.0

Otros manuales para 715ES

Este manual sirve para los siguientes modelos

Otros manuales de Caldera de Bosch

Bosch

Bosch Tronic 4000 T Series Manual de usuario

Bosch

Bosch Gaz 6000 W Manual de usuario

Bosch

Bosch ZBR16-3A Manual de usuario

Bosch

Bosch WORCESTER GREENSTAR HE ZB 7-27 Manual de usuario

Bosch

Bosch Greenstar Series Instrucciones de funcionamiento

Bosch

Bosch Danesmoor 12-14 Manual de usuario

Bosch

Bosch Worcester GB162-50 V2 Guía del usuario

Bosch

Bosch GC7000WP 150 23 Manual de usuario

Bosch

Bosch Worcester GREENSTAR 12i System Manual de usuario

Bosch

Bosch CONDENS 5000W Manual de usuario

Bosch

Bosch Tronic 1000T ES 035-4 M 0 WIV-B Manual de funcionamiento

Bosch

Bosch Worcester 9/14CBI Manual de usuario

Bosch

Bosch Worcester Greenstar 8000 Series Manual de usuario

Bosch

Bosch GWH C 920 ES Manual de usuario

Bosch

Bosch Worcester Greenstar Danesmoor 12/18 Guía del usuario

Bosch

Bosch 520-HN -L Manual de usuario

Bosch

Bosch Condens 8300i W Manual de usuario

Bosch

Bosch benchmark Greenstar12i Manual de usuario

Bosch

Bosch Tronic 2500 TO Manual de usuario

Bosch

Bosch Uni Cindens 6000F Manual de usuario

Bosch

Bosch UT-L 1 Guía de inicio rápido

Bosch

Bosch W 500-5 Series Manual de instrucciones

Bosch

Bosch WORCESTER GREENSTAR DANESMOOR WALL MOUNTED OIL... Manual de usuario

Bosch

Bosch WBN 6000-30-H-E-N/L-S2400 Manual de usuario

Manuales populares de Caldera de otras marcas

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Manual de usuario

Radijator

Radijator BIO max 23.1 Manual de usuario

Brunner

Brunner BSV 20 Manual de usuario

Buderus

Buderus Logamax GB062-24 KDE H V2 Manual de usuario

Potterton

Potterton 50e Hoja de datos

UTICA BOILERS

UTICA BOILERS TriFire Manual de usuario

Joannes

Joannes LADY Series Manual

ECR International

ECR International UB90-125 Manual de instrucciones

Froling

Froling FHG Turbo 3000 Manual de usuario

Froling

Froling P4 Pellet 8 - 105 Manual de usuario

U.S. Boiler Company

U.S. Boiler Company K2 Manual de usuario

Henrad

Henrad C95 FF Manual de usuario

NeOvo

NeOvo EcoNox EF 36 Manual de usuario

Potterton

Potterton PROMAX SL 12 Manual de usuario

Eco Hometec

Eco Hometec EC 25 COMPACT Manual de usuario

Viessmann

Viessmann VITODENS 200 Guía

Baxi

Baxi Prime 1.24 Manual de usuario

REXNOVA

REXNOVA ISA 20 BITHERMAL Manual de usuario