BMW F 650 GS DAKAR - Instrucciones de funcionamiento

BMW Motorrad

After Sales

F 650 GS/GS Dakar

Repair Manual

Introduction

This Repair Manual will help you to perform all the main maintenance and repair work correctly and effi-

ciently. If it is consulted regularly by workshop personnel it will form a useful addition to the theoretical and

practical knowledge acquired at the BMW Training Centre. It is a contribution towards achieving even high-

er Service quality.

A new issue of this Repair manual will be published if amendments or additions (supplements) are needed.

All information in both text and illustrations refers to motorcycles in standard condition or with genuine

BMW accessories installed, and not to motorcycles which have been modified in any way to depart from

the manufacturer’s specification.

•The Repair Manual is structured in the logical sequence of the work to be performed: Removal, Disas-

sembling, Repair, Assembly, Installation.

•The entire contents are divided into individual chapters, corresponding to the Construction Groups.

11 . 10

Chap. Page number within chapter

If a reference is needed to a different page or chapter, an arrow symbol is shown followed by the chapter

and page numbers, e.g. (a 12.5)

•Work to be performed during an Inspection is described in Group “00”. The various inspection routines

are numbered I, II, III and IV. This numbering is repeated in the work descriptions which follow, so that

work can take place without interruption.

•Use of the BMW special tools needed for certain tasks is described in the work instructions.

If the need arises, repair instructions are also issued in the form of Service Information. This information is

of course incorporated into the next issue of the Repair Manual. We also recommend, as an additional

source of information, the Electronic Parts Catalogue (ETK), which contains clear and easy-to-follow

illustrations.

If the work described here is restricted to a particular equipment specification, for instance if a specific op-

tional extra (OE) is fitted, this is stated in square brackets at the start of the item concerned, e.g. [Dakar].

Please refer to the following pages as well for a description of other symbols used and how to work with them.

BMW Motorrad

After Sales

Published by BMW Motorrad

After Sales

UX-VS-2

D-80788 München

permission.

Errors and omissions excepted; subject to technical amendment.

Produced in Germany

Structure

Each chapter starts with the list of contents.

The list of contents is followed by the technical data table.

Chapter 00 “Maintenance and general instructions”lists all tightening torques and the operating fluids.

Key to symbols

In this Repair Manual for the F 650 GS/GS Dakar, the following symbols are used; their meanings are ex-

plained in the tables.

Special instructions aimed at improving the work procedures

LNote:

Special information on operating and inspecting the motorcycle as well as maintenance and adjustment

procedures.

eImportant:

Instructions and precautions specifically intended to prevent damage to the motorcycle. Disregarding them

may render the warranty invalid.

dWarning:

This symbol stands for precautions and measures which are essential in order to protect the rider or other

persons from possibly severe or fatal injury.

Contents

Headlines for the work described in the chapter............. with the relevant page number

Activities

•Activities

•The bullet symbol indicates work steps that are described in greater detail under another headline

–Preceding activities

–A line indicates work steps that are described in greater detail under another headline or in another

chapter

The term “remove”means that:

the fastener (e.g. screw) must be slackened off and taken out

a component (e.g. injection rail) has to be removed to the extent that components behind it (e.g. throttle

valve) are rendered accessible

The term “loosen”means that:

the fastener (e.g. screw) must be backed off, but not removed

X Tightening torques:

Values are stated if they differ from the DIN EN 24 014 or DIN 912 ISO industrial standards.

Order No. 01 71 0 021 836 UX-VS-2, 02/00 Printed in Germany

Customer Licence plate no.

Order No. Mechanic’s signature

BMW Inspection at

1,000 km (600 miles)

BMW Service

10,0 00 km

(6,000 miles)

BMW Inspection every

20,000 km

(12,000 miles)

BMW Annual Service

Read the fault code memory with the BMW MoDiTeC

Change the engine oil while at regular operating temperature; replace the oil filter

element

if motorcycle is used only for short journeys or at outside temperatures below 0°C (32°F): every

3 months or at the latest after 3,000 km (1,800 miles)

Renew oil in telescopic forks [Dakar version only]

Check the coolant and restore to correct level if necessary *)

Replace the coolant

(every 2 years) every

2years

Check valve clearances, adjust if necessary

Replace the spark plug

Drain the outlet hose from the air filter box

Replace intake air filter

If motorcycle is operated in very dirty or dusty conditions, clean or replace the intake air filter every

10,000 km (6,000 miles); check every 3,000 km (1,800 miles)

Replace fuel filter (every 20,000 km/12,000 miles) 20,000

Check clutch play, adjust if necessary

Check wheel spoke tension and tighten if necessary

more frequently if motorcycle is ridden in severe off-road conditions

Examine brake pads and discs for wear, replace if necessary *)

more frequently if motorcycle is ridden in severe off-road conditions

Check brake fluid level at front and rear and top up if necessary *)

Check for operation of brake system and freedom from leaks; repair/replace if necessary *)

Replace the brake fluid at least once a year

Replace the primary front/rear brake master cylinder cup

(every 40,000 km/24,000 miles on a motorcycle with ABS)40,000

Check or, if necessary, replace chain, sprocket, chain guide rollers and pinion *)

more frequently if motorcycle is ridden in severe off-road conditions

Check chain tension and adjust if necessary *)

Check battery acid level, add distilled water if necessary

more frequently if motorcycle is ridden in severe off-road conditions

Clean and grease the battery terminals, if necessary

Check steering head bearings and adjust *)or replace if necessary *)

Grease the side and main stands

Grease the brake pedal

Check bolts and nuts on engine mountings, frame connections, exhaust system

mountings, pivot lever [Dakar version only], main and side stands for tightness

Final inspection with road safety and functional check:

–(Clutch, gearshift)

–Steering

–Front and rear brakes

Side stand contact switch

–Condition of tyres and wheels, tyre pressures

–Lights and signalling equipment, indicator and warning lights, instruments

–Test ride, if necessary

*)Associated work invoiced separately, see Flat rates brochure, Motorcycle 2000

BMW Motorcycle

Maintenance schedule

F 650 GS/F 650 GS Dakar

Order No. 01 71 0 021 836 UX-VS-2, 02/00 Printed in Germany

Customer Licence plate no.

Order No. Mechanic’s signature

BMW

Pre-delivery check

Check the shipping crate for damage

Motorcycle:

–unpack

–inspect for damage

–install remaining items

–clean

Battery:

–remove

–add acid

–charge

–grease terminal posts

–fit (mark with fitting date)

Check that the delivery is complete:

–Toolkit

–Documentation

–Motorcycle keys

–Optional extras

Read the fault code memory with the BMW MoDiTeC

Check tyre pressures

Fill fuel tank

Final inspection as functional check:

–Oil inspection

–Clutch, gearshift

–Steering

–Hand brakes and foot brakes

–Check lights and signalling equipment, warning and indicator lights,

instruments, ABS

–Test ride, if necessary

BMW Motorcycle

Pre-delivery Check

F 650 GS/F 650 GS Dakar

Order No. 01 71 0 021 845 UX-VS-2, 02/00 Printed in Germany

Item Rated value Unit of

measurement/

specification

Oil capacities

Engine (with filter)

Telescopic fork –for each post [Dakar version only]

2.3 (4.05/2.43)

0.55 (0.97/0.58)

Litres (Imp. pints/US quarts)

Specification: see current

Service Information

Litres (Imp. pints/US quarts)

BMW telescopic fork oil

Coolant

Cooling system (entire)

Expansion tank

1.3 (2.29/1.37)

0.1 (0.18/0.11)

Litres (Imp. pints/US quarts)

Composition:

Water: 50%

Antifreeze: 50%

Antifreeze protection

to –25 °C ( –13 °F)

Brake fluid DOT 4

Valve clearances

Measured cold (max. 35 °C/95 °F)

Inlet: 0.10-0.15

(0.004-0.006)

Exhaust: 0.25-0.30

(0.010-0.012)

mm (in)

Spark plugs

Electrode gap 0.6...0.7 (0.02...0.03)

NGK D8 EA

mm (in)

Idle speed 1350 +100 rpm

Clutch cable play

Hand lever cable 1.0 - 2.0

(0.004 - 0.008)

mm (in)

Tyre pressure (on cold tyres)

solo

when fully loaded

front/rear

1.9/2.1 (27/30)

2.1/2.3 (30/33)

bar (psi)

Tightening torques:

Engine oil drain plug

Engine water drain plug

Oil tank drain plug

Oil filter cap

Valve cap

Camshaft bracket

Spark plug

Telescopic fork oil drain plug

Round nut, steering bearing

Steering bearing locking tube

Flanged nut on locking tube

Fork stabilizer clamping screws

Brake caliper at fork slider tube

Deflection lever/frame

Deflection lever/spring strut

Deflection lever/tension strut

BMW Motorcycle

Service data

F 650 GS/F 650 GS Dakar

00 Tightening torques Operating fluids

00 Pre-delivery check

00 Maintenance

11 Motor

12 Engine electrics

13 Fuel preparation and control

16 Fuel tank and lines

17 Radiator

18 Exhaust system

21 Clutch

23 Gearbox

27 Drive chain

31 Front forks

>> Continuation

Contents

<< Back

Group / Chapter

32 Steering

33 Rear wheel drive

34 Brakes

36 Wheels and tyres

46 Frame

51 Equipment

61 General electrical equipment

62 Instruments

63 Lights

<< Back

>> Continuation

Group / Chapter

00.1

Contents Page

Tightening torques .......................................................................................................................3

11 Engine ...........................................................................................................................................3

12 Engine electrics ........................................................................................................................4

13 Fuel preparation and control ...............................................................................................4

16 Fuel tank and lines ...................................................................................................................5

17 Radiator ........................................................................................................................................5

18 Exhaust system .........................................................................................................................5

21 Clutch ............................................................................................................................................6

23 Transmission ..............................................................................................................................6

27 Drive chain ..................................................................................................................................6

31 Front forks ...................................................................................................................................6

32 Steering ........................................................................................................................................7

33 Rear wheel drive .......................................................................................................................7

34 Brakes ...........................................................................................................................................7

46 Frame ............................................................................................................................................8

51 Equipment .................................................................................................................................10

61 General electrical equipment ............................................................................................10

62 Instruments ...............................................................................................................................10

63 Lights ...........................................................................................................................................10

Table of operating fluids ......................................................................................................... 11

00 Tightening torques

Operating fluids

00.2

Contents Page

Otros manuales para F 650 GS DAKAR -

Tabla de contenidos

Otros manuales de Motocicleta de BMW

BMW

BMW R 1200 GS ADVENTURE Manual de usuario

BMW

BMW K 1300 R Manual de instrucciones

BMW

BMW F 800 R - Manual de instalación y mantenimiento

BMW

BMW R 1100 S EVO Instrucciones de funcionamiento

BMW

BMW HP2 MEGAMOTO Manual de usuario

BMW

BMW K 1600 GTL Exclusive Manual de instalación y mantenimiento

BMW

BMW R 1200 GS ADVENTURE Manual de usuario

BMW

BMW 2011 R 1200 GS Manual de instalación y mantenimiento

BMW

BMW R 1100 S EVO Instrucciones de funcionamiento

BMW

BMW R 1150 R Instrucciones de funcionamiento

BMW

BMW F 800 GS - Manual de instalación y mantenimiento

BMW

BMW Motorrad K 1300 GT Exclusive Edition Manual de usuario

BMW

BMW R 1200 GS - Manual de instalación y mantenimiento

BMW

BMW S 1000XR Manual de instalación y mantenimiento

BMW

BMW F 650 GS DAKAR - Manual de instalación y mantenimiento

BMW

BMW R 1200 R Classic Manual de instrucciones

BMW

BMW K 1600 GT Manual de instalación y mantenimiento

BMW

BMW 2004 R 1200 ST Manual de instalación y mantenimiento

BMW

BMW F 800 ST Manual de instalación y mantenimiento

BMW

BMW R 1200RT Manual de instalación y mantenimiento

BMW

BMW HP2 MEGAMOTO Manual de instrucciones

BMW

BMW C 600 Sport Manual de instalación y mantenimiento

BMW

BMW K 1200 LT - 2005 Manual de usuario

BMW

BMW 1987 K75 Manual de instrucciones

Manuales populares de Motocicleta de otras marcas

OHVALE

OHVALE GP-0 Manual de lista de piezas

Yamaha

Yamaha Star XV19CTSZ 2009 Manual de usuario

KTM

KTM 350 XCF-W USA Manual de usuario

HYOSUNG

HYOSUNG ST7 Manual de usuario

Husqvarna

Husqvarna FC 250 2016 Manual de usuario

Ducati

Ducati SCRAMBLER 800 Manual de instrucciones

MOTO GUZZI

MOTO GUZZI QUOTA 1100 ES Manual de usuario

APRILIA

APRILIA ETV MILLE CAPONORD - PART1 02-2001 Manual de usuario

Yamaha

Yamaha 2006 YZF-R1V Manual de usuario

KTM

KTM Freeride E-XC 2021 Manual de usuario

Fantic

Fantic Enduro 125 Manual de usuario

Ducati

Ducati Supersport 750 desmodue Manual de usuario

MV Agusta

MV Agusta 2008 F4 312RR 1078 Manual de instrucciones

Yamaha

Yamaha XVS650A Manual de usuario

Yamaha

Yamaha YZF-R6T(C) Manual

Ducati

Ducati 748 monoposto strada Manual de usuario

ATK

ATK 1988 250 Manual de usuario

Excelsior-HENDERSON

Excelsior-HENDERSON 1999 HCX Manual de usuario